The document provides steps to configure a remote with VLAN 60, assign IP addresses to routed Ethernet and satellite interfaces, set DNS and default gateway settings, define an IP address range for clients, add a multicast group, configure port 1 as an access port assigned to VLAN 60, and save the configuration.
The document provides steps to configure a remote with VLAN 60, assign IP addresses to routed Ethernet and satellite interfaces, set DNS and default gateway settings, define an IP address range for clients, add a multicast group, configure port 1 as an access port assigned to VLAN 60, and save the configuration.
The document provides steps to configure a remote with VLAN 60, assign IP addresses to routed Ethernet and satellite interfaces, set DNS and default gateway settings, define an IP address range for clients, add a multicast group, configure port 1 as an access port assigned to VLAN 60, and save the configuration.
2. Add Vlan 60 3. Input the 10.10.x.x in the Routed ETH interface 4. Input the 10.100.x.x in the Sat interface 5. Primary DNS 8.8.8.8 6. “Default gateway” same with the routed ETH interface 7. Add client address range fist and last usable Ip address is +1 and +5 of the routed ETH interface respectively. 8. It should look like the screenshot below but with different Ip address 9. Go to multicast group and add persistent multicast group “234.5.6.7” 10. Go go to the ports tab. 11. For port 1 change the mode to access 12. Click assign vlans and check the vlan 60 in the port1 access as shown in the picture below
` 13. The final configuration of the ports should look like this
14. In saving the configuration click “ok” and if you see this tab below click “ok”