Professional Documents
Culture Documents
Operating systems
The ACS software can be installed under the following 32 and 64 Bit systems:
Windows Vista
Windows 7
Windows 8 / 8.1
Windows 10
Hardware requirements
Operating systems Processor RAM CD-ROM Free hard disk
drive space
Murrplastik devices
Approved for the following Murrplastik devices:
Plotter mvps G3 / T / XXL / Basic pavonis
Engraving option VEC mvps G3 / T / XXL mp-TM A4+M 300 / EOS 300 /
Plotter mp-PM a3 / Basic SQUIX
Engraving option mp-EM Opt. pictor² / pictor² Black
MGS 40-TO p3b
MGS 50 / MGS 60 pulsar M6 / A6
CAM mp-LM 1 / mp-LM 3 / mp-LM 10
V. 2.3.0.95
Support of two laser systems mp-LM 3 and mp-LM 10 was
added:
- New driver kit with option to install the laser device
automatically
Support of mp-LM 3 - Revision of the configuration tool for the connection
and mp-LM 10 setup
- New laser modes for the two new laser devices with
adjusted values
- The three different laser devices can be jointly controlled
by just one PC
Support mp-TM SQUIX Support of thermal transfer printer mp-TM SQUIX was added.
V. 2.3.0.90
- The driver supports Windows 10 completely
Revision of driver - New paper sizes were added for the devices mp-PM A3
and mp-PM Basic
A QR code generator was integrated in the software.
QR code generator Now it is possible to generate QR codes without an intermediate
step. Further information can be found in the separate manual.
A function was introduced that prints a fold line on the material
Fold line KCE-ECO
KCE-ECO.
The check mark 'stop each page' was removed by default and
mp-TM – Stop each page
can be set again if needed.
The filling of true type fonts using a vector device was improved.
Under certain circumstances it is possible that small spots are
Filling vector devices
not filled correctly. Please consider the correct width for the pen
/ tool / laser.
An optional vacuum cleaner will be turned off automatically now,
Vacuum cleaner CAM
if it is attached. Only possible with the controller 680.
The name of the print job and the date are added to the
Print overview mp-LM 1
printable overview.
V. 2.3.0.80 SP2
- A possibility was introduced to increase the max print job
to 120 MB
Improvements mp-LM 1 CAUTION: firmware 1.5.1 is essential
- To improve the support for some material an additional
correction value was created
The support for mp-TM devices under Windows 10 was
Thermal transfer devices
improved.
Maximum devices The support for more than 10 output devices was added.
V. 2.3.0.80
Support for plotter and Support for new plotter generation mp-PM A3 / Basic and the
engraving option compatible engraving option was integrated.
Sometimes characters have been cut off, if heading text was too
Heading text
long.
Parameter editor Removed an error that could cause a crash on 64 bit systems.
Cut after print on Added the option 'cut material after printing' for mp-TM thermal
Thermal transfer devices transfer printers.
Marking within the print Removed an error that disabled marking when rotation was set
preview in print preview.