16.1-30 PIN-CONNECTED MEMBERS. [Sect. DS.
TABLE D3.1
Shear Lag Factors for Connections
to Tension Members
Case Description of Element ‘Shear Lag Factor, U Example
1 _|Alttension members where the tension oad is wans-
mitted directly to each ofthe cross-sectional elements
by fasteners or welds (except as in Cases 4, 5 and 6).
2 [Alltension members, except HSS, where the
tension load is transmitted to some but not all of
the cross-sectional elements by fasteners or by
longitudinal welds in combination with transverse un
welds. Alternatively, Case 7 is permitted for W, Snag
IM, S and HP shapes. (For angles, Case 8 is
permitted to be used)
| 3_[Alltension members where the tension load 5
transmitted only by transverse welds to some but | An=
not all of the cross-sectional elements, ‘connected elements
4a} [Plates, angles, channels with welds at heels, tees, i
jand W-shapes with connected elements, where
the tension load is transmitted by longitudinal
welds only. See Case 2 for definition of X. u
Prats or
connected
loment
5 _|Round HSS with a single concent 7213D, U=10
gusset plate through slots in the HSS.
6 _|Rectangular HSS. [with a single concentric
qusset plate
with to side gusset plates
7 |W..M.,S-orHP- |with lange connected with
shapes, or tees cut| three or more fasteners per
{from these shapes. | line in the direction of loading
{if Vis calculated
per Case 2,the [with web connected with four
larger value is per | or more fasteners per line in
mitted to be Used.) | the direction of loading
8 [Single and double | with four or more fasteners per
angles. line in the direction of loading
(i Vis calculated ith three fasteners perl
73 per line ih
[i cae 2,the | the direction of loading (with :
lange a fever than three fasteners per u=0.60
fs permitedto nein te deco loading,
weed) use Case 2)
B= overall width of rectangular HSS member, measured 90° to the plane of the connection, in. (mm); D = outside diameter of
ound HSS, in. (mm); H = overall Height of rectangular HSS member, measured in the plane of the connection, in. (mm);
= depth of section, in. (mm); for tees, d= depth of the section from which the tee was cut, In (mm); /~ length of connection,
in, (tm); w= width of plate, in, (mim); x = eccentricity of connection, in. (mm).
he
«112. where / and la shall not be fess than 4 times the weld size,
‘Specification for Structural Steel Buildings, uly 7, 2016
AN