Professional Documents
Culture Documents
AUTOCHEM INDUSTRY
Product Name: Master Penetrant MP-80
Revision Date: November 5, 2019
Page 1 of 5
_________________________________________________________________________________________________________________
PRODUCT
Product Name: Master Penetrant MP-80
Product Description: Penetrating oil
Intended Use: Penetrating oil - consumer product
COMPANY IDENTIFICATION
Supplier: PT. Autochem Industry
Jalan Gatot Subroto Km. 7 Jatake
Jatiuwung Tangerang
Banten 15136
Indonesia
COMPONENTS PERCENT
Synthetic Carbon 40 – 70 % wt
Mineral Oil 10 – 20 % wt
Solvent naphtha 10 – 30 % wt
Butane and/or Propane Propellant 20 – 30 % wt
Route(s) of Entry:
_________________________________________________________________________________________________________________
Eye Contact: Flush eyes with clean water for 15 minutes while lifting eyelids. Get prompt medical
attention.
Skin Contact: Wash with soap and water thoroughly. lf adverse effects persist, get prompt medical
attention. Launder contaminated clothing before reuse.
Inhalation: Remove to fresh air. lf breathing becomes difficult give oxygen and get prompt medical
attention. lf breathing stops, give artificial respiration and get prompt medical attention.
Ingestion: DO NOT INDUCE VOMITINGI Call Poison Control Center, physician, or hospital emergency
room immediately'
Aspiration of vomitus into the lungs can cause pneumonitis, which can be fatal.
Fire Extinguishing Media: Water Fog, Foam, Carbon Dioxide, Dry Chemical
Eliminate all ignition sources. Persons not wearing protective equipment should be excluded from area of spill
until clean-up has been completed. Dike or contain spill and absorb with inert materials (sand, sawdust,
absorbent sweeping compounds, rags, etc). Place contaminated material into an approved chemical waste
container. Where possible, vacuum spilled liquid using explosion proof vacuum to recover material. Prevent
run-off to sewers, streams, or other bodies of water. lf run-off occurs, notify proper authorities as required that a
spill has occured.
PT. AUTOCHEM INDUSTRY
Product Name: Master Penetrant MP-80
Revision Date: November 5, 2019
Page 3 of 5
_________________________________________________________________________________________________________________
Precautions to be Taken:
Handling: Use with adequate ventilation and proper protective equipment.
Store in a cool, dry area, away from oxidizers. Keep away from open flames, sparks, or other ignition
sources.
Other Precautions:
Do not used in confined area withoutt proper ventilation. Contact lenses may cause further damage in
case of splash into eye'
KEEP AWAY FROM CHILDREN AND ANIMALS! CAUTION: Combustible. Keep container closed tightly
when not in use.
Ventilation Requirements:
Use with adequate ventilation. lf TLV is exceeded, wear NIOSH approved respirator'
Typical physical and chemical properties are given below. Consult the Supplier in Section 1 for
additional data.
GENERAL INFORMATION
Physical State : Liquid
Appearance : Dark Liquid
Odor : Petroleum odor
Melting Point : N/A
Specific Gravity ( 25 °C ) : 0.790 - 0.860 gr/ml
Vapor Pressure (mm Hg.) : N/A
Vapor Density (AIR=1) : N/A
Viscosity ( 25 °C ) : 4.0 – 6.0 mPas
Stability:
Product is stable
Decomposition/ By Products:
Normal products of combustion, smoke, carbon dioxide, carbon monoxide, and sulfur trioxides.
Hazardous Polymerization:
Will not occur
PT. AUTOCHEM INDUSTRY
Product Name: Master Penetrant MP-80
Revision Date: November 5, 2019
Page 4 of 5
_________________________________________________________________________________________________________________
Not Established
Not Established
Do not use pressure to empty this container. When empty, container may contain vapor or product residue' Do
not puncture or cut with acetylene torch or other heal-producing devices. Do not weld on or near the container. Do
not reuse this container for any purpose. Empty container should be sent to a qualified drum re-conditioner or
curshed and disposed of according to procedures approved by local, state, and federal authorities. Do not dump
into sewers, on the ground or into any body of water. All cautions apply to empty containers after product use.
DOT MARINE POLLUTANTS: This product does not contain Marine Pollutants as defined in 49 CFR 171.8.
Warning: This product contains a chemical(s) known to the State of California to cause cancer or birth defects or
other reproductive harm.
PT. AUTOCHEM INDUSTRY
Product Name: Master Penetrant MP-80
Revision Date: November 5, 2019
Page 5 of 5
_________________________________________________________________________________________________________________
THIS SAFETY DATA SHEET CONTAINS THE FOLLOWING REVISIONS: No revision information is available.
---------------------------------------------------------------------------------------------------------------------------------------------------- -
The information and recommendations contained herein are, to the best of PT Autochem Industry knowledge and
belief, accurate and reliable as of the date issued. You can contact PT. Autochem Industry to insure that this
document is the most current available from PT Autochem Industry. The information and recommendations are
offered for the user's consideration and examination. It is the user's responsibility to satisfy itself that the product
is suitable for the intended use. If buyer repackages this product, it is the user's responsibility to insure proper
health, safety and other necessary information is included with and/or on the container. Appropriate warnings
and safe-handling procedures should be provided to handlers and users. Alteration of this document is strictly
prohibited. Except to the extent required by law, re-publication or retransmission of this document, in whole or in
part, is not permitted. The term, "PT Autochem Industry" is used for convenience.
----------------------------------------------------------------------------------------------------------------------------- ------------------------