Professional Documents
Culture Documents
WETCIT
A WETTING AGENT TO ENHANCE THE EFFICACY OF
INSECTICIDES, MITICIDES, FUNGICIDES, HERBICIDES, PLANT GROWTH
REGULATORS AND NUTRIENTS
PRECAUTIONARY STATEMENTS
Hazards to Humans and Domestic Animals
WARNING / AVISO
Causes substantial but temporary eye injury. Harmful if absorbed through skin or inhaled. Do not
get in eyes or on clothing. Avoid contact with skin. Wear goggles, face shield. Avoid breathing
spray mist. Wash hands before eating, drinking, chewing gum; using tobacco or using the toilet
Remove contaminated clothing and wash clothing before reuse.
FIRST AID
If in eyes: Hold eye open and rinse slowly and gently with water for 15-20 minutes.
Remove contact lenses, if present, after the first 5 minutes, then continue rinsing
eye.
Call a poison control center or doctor for treatment advice.
If inhaled: Move person to fresh air.
If person is not breathing, call 911 or an ambulance, then give artificial
respiration, preferably by mouth-to-mouth, if possible.
Call a poison control center or doctor for further treatment advice.
If on skin or Take off contaminated clothing.
clothing: Rinse skin immediately with plenty of water for 15-20 minutes.
Call a poison control center or doctor for treatment advice.
HOT LINE NUMBER
Have the product container or label with you when calling a poison control center or doctor, or going for
treatment. For Chemical Emergency (spill, leak, fire or accident) Call CHEMTREC (800) 424-9300
GENERAL INFORMATION
WETCIT is a highly effective surfactant designed for use with insecticides, miticides, fungicides, herbicides, plant growth regulators and
nutrients requiring a wetting and spreading agent. WETCIT assists in overcoming water repellence. A spray adjuvant added to some pesticide or
pesticide tank mixes may cause some phytotoxicity to susceptible crops or plants. Caution should be used when applying WETCIT; it is
advisable to apply to a small area before full-scale treatments are made.
MIXING DIRECTIONS
Fill tank one-half full of water. Add the required amount of pesticide while agitating. Add remainder of the water. Add the recommended
amount of WETCIT last and continue agitation until completion of spraying. For best results, use within 72 hours of mixing. DO NOT ADD
THIS PRODUCT AT A RATE THAT WILL EXCEED 0.8% (100 oz. per 100 gallons) OF THE FINISHED SPRAY VOLUME.
Treat a small area and observe results. If the results are satisfactory, proceed with a complete application. Caution: Do not apply to tree fruit or
other sensitive crops without first consulting your ORO Agri representative.
Wetting / Spreading / Surface Tension Reduction:
Insecticides, Miticides, and Fungicides - Use 25 to 100 fl. oz. of WETCIT per 100 gallons of pesticide and / or foliar fertilizer spray solution.
Plant Growth Regulators and Nutrients - Use 5 to 10 fl. oz. of WETCIT per 100 gallons of spray solution.
Herbicides – Use 25 to 100 oz. of WETCIT per 100 gallons of spray solution.
Backpack or Hand Held Sprayers - Use 1/4 to 1/2 teaspoon per gallon of spray solution.
WARRANTY STATEMENT: THERE ARE NO EXPRESS WARRANTIES OTHER THAN THOSE SET FORTH HEREIN. THE
MANUFACTURER NEITHER MAKES NOR INTENDS, NOR DOES IT AUTHORIZE ANY AGENT OR REPRESENTATIVE TO MAKE
ANY OTHER WARRANTIES, EXPRESS OR IMPLIED, AND IT EXPRESSLY EXCLUDES AND DISCLAIMS ALL IMPLIED
WARRANTIES OF MERCHANTABILITY OF FITNESS FOR A PARTICULAR PURPOSE, OR ANY WARRANTY OF QUALITY OR
PERFORMANCE. THIS WARRANTY DOES NOT EXTEND TO, AND THE BUYER SHALL BE SOLELY RESPONSIBLE FOR ANY
AND ALL LOSS OR DAMAGE WHICH RESULTS FROM THE USE OF THIS PRODUCT IN ANY MANNER WHICH IS INCONSISTENT
WITH THE LABEL, DIRECTIONS, WARNINGS, OR CAUTIONS.