Professional Documents
Culture Documents
Palatex PC - Prismadye
Palatex PC - Prismadye
2. Hazards Identification
Emergency overview
SENSITIZER.
May cause sensitization by skin contact.
Irritation / corrosion:
Not irritating to the skin. Not irritating to the eyes.
Sensitization:
Caused sensitization in humans.
4. First-Aid Measures
General advice:
Immediately remove contaminated clothing.
Safety Data Sheet
Primasol® Anticrease PC (Palatex® PC)
Revision date : 2012/01/14 Page: 2/6
Version: 1.0 (30052172/SDS_TEX_CA/EN)
If inhaled:
Keep patient calm, remove to fresh air. Assist in breathing if necessary. Consult a physician.
If on skin:
Wash thoroughly with soap and water.
If in eyes:
Wash affected eyes for at least 15 minutes under running water with eyelids held open.
If swallowed:
Rinse mouth thoroughly with water, seek medical attention.
Note to physician
Treatment: Treat according to symptoms (decontamination, vital functions), no known
specific antidote.
5. Fire-Fighting Measures
Flash point: > 100 °C (DIN 51758)
Autoignition: > 200 °C (DIN 51794)
Further information:
The degree of risk is governed by the burning substance and the fire conditions. Contaminated extinguishing
water must be disposed of in accordance with official regulations.
Environmental precautions:
Contain contaminated water/firefighting water. Do not discharge into drains/surface waters/groundwater.
Cleanup:
Place absorbed material in the same container as the spilled substance/product for disposal.
For small amounts: Pick up with absorbent material (e.g. sand, sawdust, general-purpose binder). Dispose of
absorbed material in accordance with regulations.
For large amounts: Pump off product.
Storage
General advice:
Keep container tightly closed and dry; store in a cool place.
Storage stability:
Storage temperature: 0 - 40 °C
Temperature tolerance
Protect from temperatures below: 0 °C
Protect from temperatures above: 40 °C
Hand protection:
Chemical resistant protective gloves
Eye protection:
Safety glasses with side-shields.
Body protection:
Impermeable protective clothing
Conditions to avoid:
Avoid open flames.
Substances to avoid:
No substances known that should be avoided.
Safety Data Sheet
Primasol® Anticrease PC (Palatex® PC)
Revision date : 2012/01/14 Page: 4/6
Version: 1.0 (30052172/SDS_TEX_CA/EN)
Hazardous reactions:
No hazardous reactions when stored and handled according to instructions.
Decomposition products:
Hazardous decomposition products: No hazardous decomposition products known.
Corrosion to metals:
No corrosive effect on metal.
Acute toxicity
Oral:
Type of value: LD50
Species: rat
Value: > 5,000 mg/kg
Irritation / corrosion
Skin:
Species: rabbit
Result: non-irritant
Method: OECD Guideline 404
Eye:
Species: rabbit
Result: non-irritant
Method: OECD Guideline 405
Sensitization:
Result: sensitizing
Experiences in humans:
Other Information:
The product has not been tested. The statement has been derived from the properties of the individual
components.
Acute:
Oncorhynchus mykiss/LC50 (96 h): 100 - 500 mg/l
Aquatic invertebrates
Acute:
Daphnia magna/EC0 (48 h): > 2,000 mg/l
Aquatic plants
Microorganisms
Safety Data Sheet
Primasol® Anticrease PC (Palatex® PC)
Revision date : 2012/01/14 Page: 5/6
Version: 1.0 (30052172/SDS_TEX_CA/EN)
Toxicity to microorganisms:
EC10 (6 h): > 2,000 mg/l
Inhibition of degradation activity in activated sludge is not to be anticipated during correct introduction of low
concentrations.
Degradability / Persistence
Biological / Abiological Degradation
Test method: OECD 301C; ISO 9408; 92/69/EEC, C.4-F
Method of analysis: DOC reduction
Degree of elimination: > 80 % (28 d)
Evaluation: Readily biodegradable.
Do not release untreated into natural waters. Inhibition of degradation activity in activated sludge is not to be
anticipated during correct introduction of low concentrations. The product has not been tested. The statement
has been derived from the properties of the individual components.
Container disposal:
Dispose of in a licensed facility. Recommend crushing, puncturing or other means to prevent unauthorized use
of used containers.
Land transport
TDG
Not classified as a dangerous good under transport regulations
Sea transport
IMDG
Not classified as a dangerous good under transport regulations
Air transport
IATA/ICAO
Not classified as a dangerous good under transport regulations
Federal Regulations
Registration status:
Chemical DSL, CA released; restriction on quantity / not listed
Safety Data Sheet
Primasol® Anticrease PC (Palatex® PC)
Revision date : 2012/01/14 Page: 6/6
Version: 1.0 (30052172/SDS_TEX_CA/EN)
WHMIS classification: D2B: Materials Causing Other Toxic Effects - Toxic
material
THIS PRODUCT HAS BEEN CLASSIFIED IN ACCORDANCE WITH THE HAZARD CRITERIA OF THE CPR
AND THE MSDS CONTAINS ALL THE INFORMATION REQUIRED BY THE CPR.
We support worldwide Responsible Care® initiatives. We value the health and safety of our employees,
customers, suppliers and neighbors, and the protection of the environment. Our commitment to Responsible
Care is integral to conducting our business and operating our facilities in a safe and environmentally responsible
fashion, supporting our customers and suppliers in ensuring the safe and environmentally sound handling of our
products, and minimizing the impact of our operations on society and the environment during production,
storage, transport, use and disposal of our products.