Professional Documents
Culture Documents
For WagonR
1
Table of Contents
S.no. Title Page no.
3 Installation Precautions 5
2
1. List & Photo Of The Parts Contained In The Kit
01 02
Photos Of The Parts Contained In The Kit
1 2
3 4
3
2. Photos Of tools to be used
10 mm T-Spanner Aligne
r
4
3. Installation Precautions
5
4. Do’s and Don’ts
DO'S DON'TS
For any complaint regarding Camera not Do not use sharp tool while installation
working, Please contact NIPPON Toll Free-
1800-120-6532 or email on
customercare@nipponaudio.com
The Camera operates on 6 V DCof the Do not fix the camera withoutremoving
vehicle battery the battery connections
Please protect the unit from any Do not tamper any sticker on the camera
unwarranted tampering, Water&
damages.
Camera should be installed as per defined Do not cover & hide Panic switch with
process any object
6
5. Audio, Camera & Wiring Layout
AUDI
O
Camera
7
6. Camera installation
1. Mark the centre of rear bumper and make a hole using 28 mm drill bit
2. Place the camera in hole as shown in picture, insert the ring at back of
camera and tight it from inside the bumper
3. Open the rear bumper with spanner and screw driver to tie the camera harness
8
6. Camera installation
4. Tie the camera harness below the rear bumper and cut the extra
01
02
5. Remove the left Rear combi lamp assy. using spanner and pull the lampout
Grommet 01
9
6.Camera installation
7.Detach the grommet 2 from body, expand using expander, remove thetaping,
insert the camera pigtail connector and redotaping
Grommet 02
8. Put the grommet back, fix it with tie clip and cut the extra tie clip.
03
9. Remove the screw & trim (side plastic flap) with the help of screw driver as
shown in below picture
10
6. Camera installation
10. Now pull the camera wire from vehicle inside and connect with the extension cable
11. Fix the coupler. Tie the wires using tie clips in the kit as shown below
07
04 05 06
12 . Put the other side of extension camera cable on vehicle floor and pull it till rear door
and then till front door. Tie it along with the floor harness.
08 09 10 11 12
13
11
6. Camera installation
13. Open the compartment and take it out to reach fuse box for cable layout
14. Pull the extension cable layout towards fuse box & layout with the IP wiring harness
14
17
15
18
16
15. Layout the extension cable through the instrument panel wiring harness
19
12
6. Camera installation
16. Open the audio garnish using plastic tools and pull thegarnish out
17. Open the audio clamp screw and pull outthe audio
20
19. Refix the audio and screw the clamps again. Put the garnish back on thedisplay
13
6. Camera installation
Note: 01 Box with serial nos. denote the no. of cable tie used
14
7. Camera Fitment check-list
15