Professional Documents
Culture Documents
VOLUME 1
Edited by
Yang Yang
Chongqing University, China
Sudharshan N. Raman
Civil Engineering Discipline, School of Engineering,
Monash University Malaysia, Malaysia
Bingxiang Yuan
Guangdong University of Technology, China
Zhijun Xu
Henan University of Technology, China
First published 2023
by CRC Press/Balkema
4 Park Square, Milton Park / Abingdon, Oxon OX14 4RN / UK
e-mail: enquiries@taylorandfrancis.com
www.routledge.com – www.taylorandfrancis.com
CRC Press/Balkema is an imprint of the Taylor & Francis Group, an informa business
© 2023 selection and editorial matter, Yang Yang, Sudharshan N. Raman,
Bingxiang Yuan & Zhijun Xu; individual chapters, the contributors
The right of Yang Yang, Sudharshan N. Raman, Bingxiang Yuan & Zhijun Xu to be identified
as the authors of the editorial material, and of the authors for their individual chapters, has
been asserted in accordance with sections 77 and 78 of the Copyright, Designs and
Patents Act 1988.
All rights reserved. No part of this book may be reprinted or reproduced or utilised in any
form or by any electronic, mechanical, or other means, now known or hereafter invented,
including photocopying and recording, or in any information storage or retrieval system,
without permission in writing from the publishers.
Although all care is taken to ensure integrity and the quality of this publication and
the information herein, no responsibility is assumed by the publishers nor the author
for any damage to the property or persons as a result of operation or use of this
publication and/or the information contained herein.
ISBN: 978-1-032-42537-5 (set hbk)
ISBN: 978-1-032-42538-2 (set pbk)
ISBN Volume 1: 978-1-032-37361-4 (hbk)
ISBN Volume 1: 978-1-032-37362-1 (pbk)
ISBN Volume 1: 978-1-003-33663-1 (ebk)
DOI: 10.1201/9781003336631
Table of contents
Preface xiii
Committee members xv
VOLUME 1
Keynote Lectures
Research progress on sustainable impact-resistant ultra-high performance concrete 3
Qingliang Yu
Development of an intelligent technology system for prefabrication and assembly of
new ductile tunnel structures 4
Xiangsheng Chen
Airport disaster prevention and smart construction 5
Yangping Yao
A new approach to constructing the constitutive models for soils based on
generalized potential theory 6
Guanghua Yang
Development and application of key technologies for conservation of earth
sites in arid environments 7
Wenwu Chen
Key technologies for seismic isolation and energy dissipation and damping of
industrial buildings 8
Ping Tan
Evolution of soil-water characteristics of expansive soils under dry-wet and
freeze-thaw cycles and slope stabilization practice 9
Weilie Zou
Analysis of load-bearing characteristics and dynamic response of offshore wind
turbines under complex environmental loads 10
Fayun Liang
Exploration of molecular dynamics simulations and distributed sensing system for
geotechnical engineering 11
Huafu Pei
Research progress on the durability of fiber-reinforced polymer (FRP)–reinforced
seawater–sea sand concrete (SWSSC) 12
Jianhe Xie
v
Research on concrete crack resistance in negative moment zone of steel-ECC
continuous beam bridge with uplift-restricted and slip-permitted Studs 22
Xinyu Zhang
Study on safety performance of large-thickness sandwich wall panels 27
Zhenlei Guo, Xiangyu Yao, Zhongjian Duan, Zhijie Gao & Feihua Yang
Damage analysis of sulfate erosion of pipe concrete under ultrasonic detection of
wet and dry cycle conditions 35
Yangjun Li, Huifang Liu, Jiaxi Wu, Yajian Wang & Linbing Wang
Effect of clay content and moisture content on fracture development of red clay 41
Baochen Liu, Xiaobo Wang, Junhua Chen, Bai Yang, Chunhui Su,
Chao Qin & Yanshuo Cui
Shearing and deformation characteristics of the sand compaction pile
inserted clay specimens in conventional triaxial and cyclic triaxial tests 48
Yue Zhang, Xianfeng Ma, Xi Zhang & Jian Leng
Mechanical properties of joints of a new type of steel-reinforced concrete
composite structure 56
Yizhe Feng
Simulation of mechanical properties of reinforced concrete beam based on ABAQUS 62
Xinyu Shi, Qiang Li, Bei Li & Jianbo Zhou
Axial compressive behavior of steel tube confined concrete column piers:
Experimental and FEA research 68
Yongping Man
Influence of local expanded holes in tower construction on the mechanical
properties of tower 74
Xinmin Yu, Jianping Cheng, Yiming Ruan, Junfeng Bai & Dehong Wang
Design and test analysis of an innovative grout sleeve with variable spacing
of shear grooves 80
Yuliang Qi, Keke Huang, Yingguang Fang, Wanlin Yang, Yibo Yang & Renguo Gu
Experimental study on deformation characteristics of marine soft soil
under long-term loading 90
Chao Yang & Guan-ghui Yang
Study on bonding stress between UHPC steel fiber and concrete:
Theory and experiment 97
Aijun Li, Zijiang Yang, Shizhong Liu, Yanhai Liu & Heng Liu
Experimental study on comprehensive performance of retractable
vertical drainage structure 106
Junlong Hu, Kaifang Deng, Jing Wang & Deyong Wang
Research and test on thermal function maintenance template of mass concrete 113
Xiaoyue Wang, Feng Gao, Yongqing Ren, Qiang Zhang & Kailong Liu
Experimental study on flexural behavior of autoclaved aerated concrete block
strengthened with textile-reinforced high ductile concrete 121
Yuren Ma & MingKe Deng
Application of expansion joints on the performance of prestressed reinforced
continuous beam bridge considering the temperature effect 128
Duo Li & Junyi Wei
vi
Fatigue parameter index analysis of steel-concrete composite beams 137
Jing Wang & Dong Zhao
Geopolymers as repair materials in civil engineering: Bibliometric analysis
based on cite space 143
Longhua Xu, Wei Zhang & Yuzi Zhang
Influence of mass ratio and stiffness ratio on whipping effect of
multi-degree-of-freedom system 151
Mingzhen Li & Changqing Guo
High-temperature condition impact on tensile strength of typical steel grade 158
Sangchu Quan
Study on road performance of mechanical foamed warm-mix rubber-modified
SMA asphalt mixture 167
Yongpeng Li, Kaiwen Lei, Rong Chang, Lishuai Jiang, Fujie Li & Liu Pan
Experimental research on silica fume exciting steel slag and ground
granulated blast-furnace slag to solidify soft soil 174
Chenda Liang, Haoyou Li, Xuying Wang, Yongqi Ren, Yaozu Yu, Yulong Zhang,
Mingquan Yang & Cheng Zhang
Numerical study of lateral breakout resistance for shallow-embedded pipeline in sand 180
Zheng Yu, Run Liu, Chengfeng Li & Xintong Hao
Analysis and design of coupled heat and moisture performance of new self-insulation
blocks of recycled ceramsite concrete 189
Weihua Zheng, Chao Song & Yuan Su
Electrical conductivity of asphalt concrete containing carbon fiber and graphene 199
Dongdong Yao, Haonan Chang, Zhuang Wang, Zhen-gang Feng & Xinjun Li
Mechanical characteristics of municipal solid waste incineration bottom
ash based on triaxial tests 205
Sulian Lan, Zhiqiang Xu, Hongri Zhang & Hongchun Zhang
Establishment and dynamic analysis of train-track coupling model for
high-speed railway 212
Longzhou Che, Kun Zhang, Xiaoyu Huang & Jiaming Wang
Study on the influencing factors of sulfate attack performance of shotcrete
under dry-wet cycle 218
Wen Zhan, Baobao Yan, Taoyong Li, Yujun Gao & Zhouyuan Wang
Mechanical performance analysis on castellated beam-column (H-shaped)
weak axis end-plate connections under monotonic loading 227
Yingchun Gu, Yan Jia, Qiurong Li & Lianguang Jia
Experimental study on the load-bearing performance of cantilevered circular
occlusion pile enclosure structure 234
Yong Deng, Hongyang Xie, Yunxue Ye, Jianjun Dong, Heng Li & Kaiwei Cao
Experimental study on bending stiffness of oil-filled pipeline 242
Simin Zou & Xiangyu Xu
Macroscopic and mesoscopic correlations in granular materials based on
rolling resistance linear contact model 248
Yi-Wei Wang & Run Liu
vii
Numerical study on mechanical behaviors of sandstone containing pre-existing
single fissures with different dip angles under uniaxial compression 257
Bin Tang, Neng Zhao & Xuzhi Chen
Experimental study on improvement of water stability of phosphogypsum
stabilized red clay 265
Kaisheng Chen, Xing Hu & Qinqin Wang
Study on loess degradation and high fill slope deformation evolution
mechanism based on model test 271
Zhijie Sun, Fei Wang, Ziyang Zhao & Xuesong Feng
Study on the anti-aging properties of TiO2 /basalt modified asphalt 278
Bin Luo, Chaoyue Rao, Lizhong Zeng, Dinghua Zhang, Zhilin Wu,
Yulong He & Kaixin Shi
Design and operation simulation of a kind of acoustic wooden sound
absorption board 284
Yucheng Li, Shouyi Bu, Wei Wang & Qing Li
Fire resistance analysis of profiled steel sheeting-concrete composite slab 289
Yuanhang Deng, Yaopeng Wu & Hongtu Lu
Experimental study on grout reinforcement mechanism in deep fractured mudstone 295
Zhanbiao Yang, Man Wang & Yuanguang Zhu
Experimental study on the damage of reinforced concrete columns under
explosion load 301
Lijun Zhao, Yongping Hao & Chaozhi Yang
Viscoelastic peridynamic theory of concrete and its application 307
Dechun Lu, Zhiqiang Song, Guosheng Wang & Xiuli Du
Study of the feasibility of using gangue as a concrete aggregate 316
Hanqing Liu & Guoliang Bai
Design and mechanical properties analysis of lightweight polymer composite plate 322
Zhuoyuan Chen, Xiaoyong Liu, Aizhong Qin, Zhihua Gao, Zongmiao Dai,
Wenfen Zhao & Peiyang Li
Simulation analysis of the force performance of the SRC Cantilever beam in the
transition layer 327
Long Chen, Yuan-chu Gan & Liang-ping Li
Study on fracture evolution law of red clay stabilized by high content
phosphogypsum 333
Kaisheng Chen, Xing Hu & Qinqin Wang
Study of the influence of pore structure characteristics on the properties of
recycled fine aggregate concrete 339
Jinqiao Huang, Yi Jiang & Wei Xu
Research on static test of modular steel structure beam-column joint 347
Yijian Shi, Liulian Li, Taoping Ye, Yang Ping, Zhongyang Yu, Yonglan Xie & Weiyong Li
Analysis on influencing factors of shear mechanical properties of
segmental beam joints 355
Yingfu Liu, Laijun Liu, Xiangyan Fan, Fangwen Wu, Liguo Zhao & Hongjun Chen
viii
Study on preparation and modification of synchronous grouting material with
waste fine sand slag by shield method 361
Zhouyuan Wang, Erpu Shen, Banban Yan, Taoyong Li & Wu Yang
Study on the mechanical properties of single spherical friction pendulum
supports under different parameters 370
Chunyu Li & Changjie Xu
Study on thermal performance of new building energy-saving wall insulation
materials 381
Shanshan Xu, Ming Cao, Yunli Zhang & Hao Jiang
Numerical simulation on shear performance of high-strength bolted
connections in steel-concrete composite beams 389
Yuanbin Xie, Junning Xiang, Xiangguo Li, Zhongqi Chen & Guotao Yang
Numerical simulation on cyclic behaviour of high strength bolt shear connector 395
Lingtong Lv, Wei Feng, Ruipeng Guo, Xi Qin & Guotao Yang
In-operation experimental research on fatigue characteristics of orthotropic deck 400
Hao Luo, Lili Li, He Qi, Haoyuan Gao & Ben Xiao
ix
Research on concrete perfusion technology of arch rib steel tube of
Nalao Bridge in Pingguo county 482
Hongjun Zhu, Kunqiu Zhang, Yun Huang, Qingyun Yao, Ben Chen,
Jing Li & Zheng Chen
Research on arch effect of high and steep slope asphalt concrete core dam
based on ABAQUS 493
Yanlong Li, Mingming Rao, Lifeng Wen & Heng Zhou
Application study and construction design of Trestle of Waisha Bridge 499
Xiaofu Wang, Yi Hou, Xiaofeng Qin, Wen Liu & Xianchuan Yao
Field test and study on construction ventilation of small-radius spiral tunnels 509
Shao-qiang Zhang, Wen-qiang Li, Sheng-jun Hou, Zhens-heng Cao,
Yi-han Li & Neng-zeng Long
Optimization analysis of excavation support parameters for deep foundation pits in
common wall sections of existing metro stations 518
Naiyun Deng, Hongjun Liu & Hong Lu
Research on timber construction based on robot arm technology 529
Zhenhua Xu, Cong Han & Siyuan Tong
Treatment technology and verification of shield tunneling through large-scale
anchor cable group 536
Fei Ding, Guokui Shen, Lei Chen & Meilong Deng
Research on application of non-support replacement concrete technology for the
shear wall of a high-rise building 547
Jian-peng Zhang & Jian-yang Zhang
Analysis on strength and microscopic homogeneity of cement stabilized macadam
mixture based on vibration mixing 558
Yuzhang Yang, Fei Chen, Zhoucong Xu, Huoming Wang & Haonan Zhou
On application of green building technology in Natatorium of Hangzhou
Huanglong Sports Centre 565
Fang Wang & Yan Long
Study on dynamic response of shield segment to approach blasting of connected aisle 572
Huapeng Zhao, Hailiang Wang, Jun Zhao, Jingxin Xiao & Chenchen Shi
Analysis of construction process of space grid steel structure of saddle-arch
combination type 583
Yueqiang Dai, An Wang, Zhengyan Wu & Hongda Feng
Causes analysis and repair methods of concrete cracks in aqueducts 597
Kun Li, Meng Li, Chong Sun & Pingping Bai
Application of lattice anchor rod in high and steep slope support 602
Shuijiang Li, Hongbo Liu, Yongkang Ye & Yunpeng Xie
Influence analysis of foundation pit construction of a subway station in
Nanchang on shield tunnel and adjacent buildings 608
Xi Tao, Kaihua Zeng, Zike Chen & Xingxing Liu
Seepage analysis of Chuanqin diversion tunnel under the condition of
deep well dewatering 614
Changsheng Wang, Liang Zhao, Yu Liu, Fuheng Ma & Lei Gan
x
Study on the response of surrounding rock with buried depth and
rock grade in tunneling 621
Bo Ma, Yunkai Leng, Weisong Sun & Kaixin Li
Effect of coefficient of charge distance on the vibration response law of
buildings in tunnel blasting 628
Yuanchen Fu, Hailiang Wang & Chen Zhao
Optimization of large span portal frame structure with tapered sections 636
Runze Yang
An analysis of the reliability of wave overtopping volumes of sloping seawalls 641
Chenyun Wang
Research on influencing factors of ventilation and cooling effect in high
geotemperature tunnel 647
Chao Zhang, Shaoqiang Zhang, Shengjun Hou, Quansheng Chen & Qibo Mou
Research on nondestructive detection and trenchless treatment of abutment
slab void 654
Fei Chen, Xueming Jia, Jianqiang Xu & Jie Wu
Research on response of water transmission pipeline crossing fault zone in
Han Wei River diversion project 661
Hangkai Dong
Study on curing technology of prefabricated concrete components 668
Hongbo Chen, Yi Jiang & Dongming Jia
Study on construction quality management of asphalt concrete pavement 676
Xiaonan He, Jingtao Zhang, Lin Cheng & Xiaodong Yang
Technology research and application of immersed tunnel underwater detection 682
Dongqing Huang, Yongfang Shen, Zhuo Cheng & Zhaowei Wang
Research on isometric model test of sand foundation of immersed tunnel 690
Bangxu Li & Yatong Chen
Analysis of the runoff and seepage drainage effects of prefabricated roof
double-layer drainage system 698
Jianwei Cheng & Guanghui Zhang
Application of viscous damper in vibration reduction of steel tube concrete
special-shaped arch bridge 710
Zhengxi Yang, Li Xu, Chaoyong Shen & Yuhong Ma
A method for line-shape and suspender force control of tied-arch bridges based on
stress-free state theory 717
Xu Zhao, Penglin Xie, Dianyong Wang, Junlong Zhou & Xiaomin Liu
Author index 727
xi
Advances in Frontier Research on Engineering Structures – Yang et al. (Eds)
© 2023 The Editor(s), ISBN: 978-1-032-37361-4
Preface
Due to the recent pandemic, the 2022 6th International Conference on Civil Architecture and Struc-
tural Engineering (ICCASE 2022) was held virtually online during May 20–22, 2022. The decision
to hold the virtual conference was made in compliance with many restrictions and regulations
that were imposed by countries around the globe. Such restrictions were made to minimize the
risk of people contracting or spreading the COVID-19 virus through physical contact. There were
200 individuals attending this online conference, representing many countries including China,
Australia, Nigeria, India, Iran and Malaysia.
The conference mainly focused on the development of engineering structure, intelligent building,
structural seismic resistance, monitoring and testing and other research fields of civil construction,
structural engineering. The conference aimed to provide an exchange platform for experts and
scholars, engineers, and research personnel of related fields. By discussing scientific research
achievements and advanced technology, we can understand the trend of academic development,
broaden our horizon in research, strengthen the level of academic research and discussion, and
promote the intelligent level of civil construction and structural engineering development and the
industrialization of academic achievements.
During the conference, the conference model was divided into three sessions, including oral
presentations, keynote speeches, and online Q&A discussion. In the first part, some scholars, whose
submissions were selected as the excellent papers, were given about 5–10 minutes to perform their
oral presentations one by one. Then in the second part, keynote speakers were each allocated 30-45
minutes to hold their speeches.
In the second part, we invited ten professors as our keynote speakers. Prof. Xiangsheng Chen,
Shenzhen University; Chinese Academy of Engineering; Russian Academy of Engineering (RAE),
performed a speech: Development of an intelligent technology system for prefabrication and assem-
bly of new ductile tunnel structures. And then we had Prof. Yangping Yao, Beihang University. He
delivered a speech: Airport disaster prevention and smart construction. Dr. GuanghuaYang, Guang-
dong Research Institute of Water Resources and Hydropower. He presented a wonderful speech:
A new approach to constructing the constitutive models for soils based on generalized potential
theory. Prof. Wenwu Chen, College of Civil Engineering and Mechanics, Lanzhou University. He
shared a speech: Development and application of key technologies for conservation of earth sites
in arid environments. Dr. Ping Tan, Guangzhou University, performed a speech: Key technologies
for seismic isolation and energy dissipation and damping of industrial buildings. Prof. Weilie Zou,
Wuhan University. He delivered a speech: Evolution of soil-water characteristics of expansive soils
under dry-wet and freeze-thaw cycles and slope stabilization practice. Prof. Fayun Liang, Tongji
University. He shared a speech: Analysis of load-bearing characteristics and dynamic response of
offshore wind turbines under complex environmental loads. Prof. Qingliang Yu, School of Civil
Engineering, Wuhan University. Prof. Yu is mainly engaged in: (1) basic theory and microstructure
control research of cement-based materials, (2) research on advanced concrete structural materials
(nano-modified concrete, ultra-high-performance concrete, lightweight concrete). Prof. Huafu Pei,
Dalian University of Technology, performed a speech: Exploration of molecular dynamics simu-
lations and distributed sensing system for geotechnical engineering. Prof. Jianhe Xie, our finale
keynote speaker, from Guangdong University of Technology. He delivered a speech: Research
progress on the durability of fiber-reinforced polymer (FRP)–reinforced seawater–sea sand con-
crete (SWSSC). Their insightful speeches had triggered heated discussion in the third session of
the conference. Every participant praised this conference for disseminating useful and insightful
knowledge.
xiii
The proceedings are a compilation of the accepted papers and represent an interesting outcome
of the conference. Topics include but are not limited to the following areas: Engineering Structure,
Seismic Resistance of Structure, and other related topics. All the papers have been through a
rigorous review process to meet the requirements of international publication standards.
We would like to acknowledge all of those who supported ICCASE 2022. The help and con-
tribution of each individual and institution was instrumental in the success of the conference. In
particular, we would like to thank the organizing committee for its valuable inputs in shaping the
conference program and reviewing the submitted papers.
The Committee of ICCASE 2022
xiv
Advances in Frontier Research on Engineering Structures – Yang et al. (Eds)
© 2023 The Editor(s), ISBN: 978-1-032-37361-4
Committee members
Conference Chairs
Prof. Lijuan Li, Guangdong University of Technology, China
Assoc. Prof. Sudharshan N. Raman, Civil Engineering Discipline,
School of Engineering, Monash University Malaysia, Malaysia
Academic Committee Chair
Prof. Feng Liu, Guangdong University of Technology, China
Academic Committee Members
Prof. Bing Bai, Beijing Jiaotong University, China
Prof. Xiaohua Bao, Shenzhen University, China
Prof. Wengui Cao, Hunan University, China
Prof. Zhangnv Zeng, Henan University of Technology, China
Prof. Fusheng Zha, Hefei University of Technology, China
Prof. Jinjian Chen, Shanghai Jiao Tong University, China
Prof. Xiaoping Chen, Jinan University, China
Prof. Xingzhou Chen, Xi’an University of Science and Technology, China
Prof. Wenwu Chen, Lanzhou University, China
Prof. Chunyi Cui, Dalian Maritime University, China
Assoc. Prof. Beibing Dai, Sun Yat-sen University, China
Prof. Guoliang Dai, Southeast University, China
Prof. Xuanming Ding, Chongqing University, China
Prof. Tianhui Fan, South China University of Technology, China
Prof. Yanjun Du, Southeast University, China
Prof. Rui Chen, Harbin Institute of Technology, Shenzhen, China
Prof. Yong Feng, Henan University of Technology, China
Prof. Hongmei Gao, Nanjing Tech University, China
Prof. Weiming Gong, Southeast University
Prof. Wei Guo, Tianjin University, China
Prof. Yongchang Guo, Guangdong University of Technology, China
Prof. Yuancheng Guo, Zhengzhou University, China
Prof. Chong Jiang, Central South University, China
Prof. Jian Ji, Hohai University, China
Prof. Tong Jiang, North China University of Water Resources and Electric Power, China
Prof. Gangqiang Kong, Hohai University, China
Prof. Liang Kong, Qingdao University of Technology, China
Prof. Diyuan Li, Central South University, China
Prof. Jinhui Li, Harbin Institute of Technology, Shenzhen
Prof. Lihua Li, Hubei University of Technology, China
Prof. Lianxiang Li, Shandong University, China
Prof. Xia Li, Southeast University, China
Prof. Yurun Li, Hebei University of Technology, China
Prof. Yuanhai Li, China University of Mining and Technology (Xuzhou), China
Prof. Fayun Liang, Tongji University, China
Prof. Shihua Liang, Guangdong University of Technology, China
Prof. Hang Lin, Central South University, China
Prof. Yuliang Lin, Central South University, China
xv
Prof. Run Liu, Tianjin University, China
Prof. Xianshan Liu, Chongqing University, China
Prof. Yongjian Liu, Guangdong University of Technology, China
Prof. Mengmeng Lu, China University of Mining and Technology (Xuzhou), China
Prof. Donghai Liu, Tianjin University, China
Prof. Hai Liu, Guangzhou University, China
Prof. Junwei Liu, Qingdao University of Technology, China
Prof. Jianbing Lv, Guangdong University of Technology, China
Prof. Guoxiong Mei, Hohai University, China
Prof. Huafu Pei, Dalian University of Technology, China
Prof. Xiusong Shi, Hohai University, China
Prof. Hongyan Shi, Guangdong University of Technology, China
Prof. Dong Su, Shenzhen University, China
Prof. Liang Tang, Harbin Institute of Technology, China
Prof. Liyuan Tong, Southeast University, China
Prof. Chenghua Wang, Tianjin University, China
Prof. Dongxing Wang, Wuhan University, China
Prof. Dong Wang, Ocean University of China, China
Prof. Wenbin Wu, China University of Geosciences (Wuhan), China
Prof. Yang Xiao, Chongqing University, China
Prof. Zhijun Xu, Henan University of Technology, China
Prof. Jiang Xu, Chongqing University, China
Prof. Zhenhao Xu, Shandong University, China
Prof. Yiguo Xue, Shandong University, China
Prof. Changbin Yan, Zhengzhou University, China
Prof. Rongtao Yan, Guilin University of Technology, China
Prof. Junjie Yang, Ocean University of China, China
Prof. Minghui Yang, Hunan University, China
Prof. Xueqiang Yang, Guangdong University of Technology, China
Prof. Zhongxuan Yang, Zhejiang University, China
Prof. Jiangtao Yi, Chongqing University, China
Prof. Jingke Zhang, Lanzhou University, China
Prof. Junwen Zhang, China University of Mining and Technology (Beijing), China
Prof. Liaojun Zhang, Hohai University, China
Prof. Mingyi Zhang, Qingdao University of Technology, China
Prof. Qianqing Zhang, Shandong University, China
Prof. Yongjun Zhang, Qingdao University of Technology, China
Prof. Wengang Zhang, Chongqing University, China
Prof. Gang Zheng, Tianjin University, China
Prof. Dequan Zhou, Changsha University of Science & Technology, China
Prof. Feng Zhou, Nanjing Tech University, China
Prof. Qizhi Zhu, Hohai University, China
Prof. Haiyang Zhuang, Nanjing Tech University, China
Prof. Yan Zhuang, Southeast University, China
Prof. Yonghong Wu, Kunming University of Science and Technology, China
Professorate Senior Engineer Guanghua Yang, Guangdong Research Institute of
Water Resources and Hydropower, China
Prof. Alessandro Bianchi, Landscape Representation and Architectural Survey at
DAStU, Politecnico di Milano, Italy
Prof. Ali Cheshmehzangi, Architecture and Urban Design, University of
Nottingham Ningbo, China
Assoc. Prof. Keping Chen, Central South University, China
xvi
Assoc. Prof. Youkou Dong, China University of Geosciences (Wuhan), China
Assoc. Prof. Qinwen Du, Chang’an University, China
Assoc. Researcher Yumin Du, Northwestern Polytechnical University, China
Assoc. Prof. Kai Gu, Nanjing University, China
Associate Researcher Huan He, Southeast University, China
Associate Researcher Yan Jiang, Guangdong Research Institute of
Water Resources and Hydropower, China
Assoc. Prof. Hailei Kou, Ocean University of China, China
Assoc. Prof. Jiale Li, Hebei University of Technology, China
Assoc. Prof. Weichao Li, Tongji University, China
Assoc. Prof. Peiyuan Lin, Sun Yat-sen University, China
Assoc. Prof. Chao Liu, Guangzhou University, China
Assoc. Prof. Kaiwen Liu, Southwest Jiaotong University, China
Assoc. Researcher Qingbing Liu, China University of Geosciences (Wuhan), China
Assoc. Prof. Congshuang Luo, Henan University of Urban Construction, China
Assoc. Prof. Linlong Mu, Tongji University, China
Assoc. Prof. Feifan Ren, Tongji University, China
Assoc. Prof. Xiang Ren, Xi’an University of Science and Technology, China
Assoc. Prof. Jiangwei Shi, Hohai University, China
Assoc. Prof. Liqiang Sun, Tianjin University, China
Assoc. Prof. Lei Su, Qingdao University of Technology, China
Assoc. Prof. Yixian Wang, Hefei University of Technology, China
Assoc. Prof. Lei Wang, Anhui University of Science & Technology, China
Assoc. Prof. Wanying Wang, Guangdong University of Technology, China
Assoc. Prof. Yonghong Wang, Qingdao University of Technology, China
Assoc. Prof. Xiaoyu Bai, Qingdao University of Technology, China
Assoc. Prof. Yulei Bai, Beijing University of Technology, China
Assoc. Prof. Zhongnian Yang, Qingdao University of Technology, China
Assoc. Prof. Junhong Yuan, Inner Mongolia University, China
Assoc. Prof. Bingxiang Yuan, Guangdong University of Technology, China
Assoc. Prof. Yong Wen, Zhongkai University of Agriculture and Engineering, China
Assoc. Prof. Yang Wu, Guangzhou University, China
Assoc. Prof. Jianlong Zhang, Guangdong University of Technology, China
Assoc. Prof. Lijuan Zhang, Guangdong University of Technology, China
Assoc. Prof. Ling Zhang, Hunan University, China
Assoc. Prof. Sulei Zhang, Qingdao University of Technology, China
Assoc. Prof. Wei Zhang, South China Agricultural University, China
Assoc. Prof. Xiaoling Zhang, Beijing University of Technology, China
Assoc. Prof. Yaguo Zhang, Chang’an University, China
Assoc. Prof. Heng Zhao, Hunan University, China
Assoc. Researcher Yanru Zhao, Shenzhen University, China
Assoc. Prof. Haizuo Zhou, Tianjin University, China
Assoc. Prof. Haizuo Zhou, Tianjin University, China
Assoc. Prof. Xinjun Zou, Hunan University, China
Assoc. Prof. Houssam Khelalfa, LGCE & Department of Civil Engineering of
University of Jijel, Algeria
Assoc. Prof. Norhisham Bakhary, Universiti Teknologi Malaysia, Malaysia
Dr. Jun Bi, Nanjing Tech University, China
Dr. Chunshun Zhang, Monash University, China
Dr. Anupoju Rajeev, Department of Civil Engineering, Indian Institute of
Technology Guwahati, Assam, India
xvii
Dr. Emmanuel Ikechukwu Ugwu, Michael Okpara University of Agriculture,
Umudike, Nigeria
Lecturer Qingzi Luo, Guangdong University of Technology, China
Lecturer Deluan Feng, Guangdong University of Technology, China
Lecturer Xing Gong, Guangdong University of Technology
Lecturer Mingjie Jiang, Guangxi University, China
Lecturer Binbin Yang, Xuchang University, China
Lecturer Shangchuan Yang, Southwest Jiaotong University, China
Lecturer Hao Zhang, Shanghai Normal University, China
Senior Engineer Zongjie An, Shenzhen Modern City Architectural Design Co. Ltd, China
Senior Engineer Zhongwei Wang, Shenzhen Modern City Architectural Design Co. Ltd, China
Chief Engineer Houbing Xing, CSCEC4 Civil Engineering Co. Ltd, China
xviii
Keynote Lectures
Advances in Frontier Research on Engineering Structures – Yang et al. (Eds)
© 2023 The Author(s), ISBN: 978-1-032-37361-4
Qingliang Yu
Wuhan University, China
ABSTRACT: This report mainly focuses on the research results of the reporter in impact-resistant
ultra-high-performance concrete in the past few years. Firstly, it elaborates on the design concept
of new sustainable ultra-high-performance concrete, then highlights the dynamic and static per-
formance response of ultra-high-performance concrete under different impact loads, discusses the
performance of ultra-high-performance concrete under different service conditions and the cor-
responding design optimization, and finally presents a brief conclusion and an outlook on future
research directions.
DOI 10.1201/9781003336631-1 3
Design of new green self-insulation block and experimental study on mechanical
and thermal properties
Chen F.G. Strategic Thinking of Wall Material Innovation [J]. Wall Material Innovation and Building Energy
Conservation. 2009 (7): 20–26.
Chen H , Fang G.X. , Zhang T , Cui W.S. , Experimental study on the frost resistance and thermal
conductivity of Environmental fair-faced concrete[J]. IOP Conference Series: Earth and Environmental
Science. 2021, 687(1):012171.
Huang Y.X. , Han L. Thermal Performance and Theoretical Calculation of Sintered Thermal Insulation Block
[J]. Brick and Tile. 2020, (09):28–31.
Li G.Z. , Application Status and Development Trend of New Wall Materials [J]. 21st Century Building
Materials, 2009, (01):31–33.
Ma Z.J. , Liang Z.Y. , Jin D.G. , Experimental study on Mechanical Properties of green and environmental
friendly self-compacting recycled IOP Conference Series: Earth and Environmental Science. 20121, 787(1):
012029
Technical Specification for Application of self-insulation Concrete composite block Wall (JGJ/T 323-2014)
[S]. China Architecture and Architecture Press, 2014.
Zhang T , Fang G.X. , Chen H , Cui W.S. , Experimental study on mix proportion of green environmental
protection type three-doped fair-faced concrete[J]. IOP Conference Series: Earth and Environmental
Science. 2021, 787(1): 012045.
Effect of clay content and moisture content on fracture development of red clay
Chen K S (2018). Evolution of cracks in red clay under wetting-drying cycles and its influence on shear
strength J. Hydrogeology and Engineering Geology. 45(01), 89–95.
Chen N S , Gao Y C , Yang C L and Hu G S (2018). Effect of clay content on the strength of gravel soil in the
source region of debris flow J. Journal of Mountain Science. 15(10), 2320–2334.
Chen Y J , Zhao Y L , Wen S S , He J T and Huang X Z (2017). Effect of clay content on the strength and
compressibility of sandy soil J. Science Technology and Engineering. 17(23), 281–286.
Constantinescu J and D Constantinescu (2010). Particularity of plasticity characteristics of fine glacial
materials (North Chicago area) J. Geoecomarina. 17, 59–66.
Cui Y S (2021). Experimental study on fracture development of Guilin red clay with different clay content
(Guangxi: Guilin university of technology).
Dafalla M A (2013). Effects of clay and moisture content on direct shear tests for clay-sand mixtures J.
Advances in Materials Science and Engineering. 2013 (4).
Fu L , Yan D , Huang Q and Song L H (2017). Experimental study on effect of clay content on permeability of
clayey soil J. Science Technology and Engineering. 17, 280–284.
Hu Q Z , Hong C W and Li M (2019). Effect of different clay content on the permeability of granite residual
soil J. Science Technology and Engineering. 19, 267–271.
Jong E D , Acton D F and Stonehouse H B (1990). Estimating the Atterberg limits of southern Saskatchewan
soils from texture and carbon contents J. Canadian Journal of Soil Science. 70(4), 543–554.
Krim A , Arab A , Chemam M , Brahim A , Sadek M and Shahrour I (2017). Experimental study on the
liquefaction resistance of sand-clay mixtures: effect of clay content and grading characteristics J. Marine
Georesources and Geotechnology. 1–13.
Lan T , Qin W X , Hu R , Wang J M and Jiang Z M (2018). Experimental study on impacts of clay content on
soil-water characteristics of silty clay J. Science Technology and Engineering. 18(28), 128–132.
Li S M , Wu M , Meng J P and Liu Z K (2021). Effects of compactness and initial water content on
disintegration characteristics of red clay J. Journal of Henan University of Science and Technology (Natural
Science). 42, 54-59+8.
Pan Z Y (2014). Research on fracture property and strength decay on red clay in Guilin (Guangxi: Guilin
university of technology).
Sadeghzadegan R , Naeini S A and Mirzaii A 2018 Effect of clay content on the small and mid to large strain
shear modulus of an unsaturated sand J. European Journal of Environmental & Civil Engineering. 1–19.
Tang C S , Shi B and Cui Y J (2018). Behaviors and mechanisms of desiccation cracking of soils J. Chinese
Journal of Geotechnical Engineering. 40(8), 1415–1423.
Wang P Q and Fu Q (2013). Analysis on stability of red clay with cracks based on rainfall infiltration J.
Highway Engineering. 38(5), 165-170+192.
Widjaja B and Kurniawan K (2020). Development of relationship between liquid limit and clay content for
west java soils J. In: Materials Science and Engineering. 1007(1).
Zhuang J , Peng J and Zhu Y (2020). Effects of clay content on loess slope failure mode and loess strength
J. Bulletin of Engineering Geology and the Environment. p.1.
Design and test analysis of an innovative grout sleeve with variable spacing of
shear grooves
Gao L.X. & Jin Y. (2004). Force analysis and improvement measures of casing connection thread. Journal of
Shanghai Jiaotong University. 38(10): 1729–1732.
Han T.Y. & Du M.G. & Shang Y.L. (2020). Research on development strategy of prefabricated buildings
under the industrialization trend. Journal of Railway Engineering. 37(7): 106–112.
Henin E & Morcous G. (2015). Non-proprietary bar splice sleeve for precast concrete construction.
Engineering Structures. 83: 154–162.
Hu Z.F. & Xu G.K. (2018). Research on the development trend and bottleneck of prefabricated buildings in
Guangzhou. Guangzhou Architecture. 46(04): 36–41.
Lamport W.B. & Jirsa I.O. (1991). Strength and behavior of grouted pile-to-sleeve connections. Journal of
Structural Engineering 117(8): 2477–2498.
Lamport W.B. (1987). Ultimate strength of grouted pile-to-sleeve connections. In: 19th Annual Offshore
Technology Conference, pp. 19-26, Houston, Texas.
Ling J.H. & Rahman A.B.A. & Ibrahim I.S. (2016). Tensile capacity of grouted splice sleeves. Engineering
Structures. 111: 285–296.
Wang J. & Zhao J.D. & Fu Z.Y. (2016). The present situation and thinking of the building industrialization
development in China. Civil Engineering Journal. 49(05): 1–8.
Wu T.G. (2014). Influence of sleeve type and inner surface shape on steel bar connection performance.
Shenyang Jianzhu University .
Xi J.T. & Nie G. & Mei X.S. (1999). Contact finite element analysis of connection performance of casing
thread joint. Journal of Xi 'an Jiaotong University. 33(11): 65–68.
Xi J.T. & Nie G. & Mei X.S. (2000). Influence of pitch error on load transfer characteristics of casing thread.
Journal of Xi 'an Jiaotong University 34(01): 46–49.
Xiao B.R. & Qiu Z.X. & Zhu J. (2020). A review of the current situation in grouting sleeve research. 20th
National Symposium on Modern Structural Engineering on Proceedings: 339-345.
Yamamoto K. & Kobayshi K. & Maguchi T. (1990). Stress analysis of premium threaded connection “FOX”
by finite element method. Kawasaki Steel Technical Report. (22): 41–47.
Zhao J. & Du Y.B. & Zhu W.X. (2019). Finite element analysis of grouting sleeve connecting members.
Concrete. (10): 150–154.
Zheng Y.F. & Guo Z.X. & Zhang X. (2018). Influence of sleeve cavity structure on bonding performance of
reinforcement sleeve grouting Joints. Journal of Building Structures. 39(09): 158–166.
Zheng Y.F. & Guo Z.X. (2016). Experimental research and finite element analysis of deformation grouting
sleeve connection performance. Journal of Building Structures. 37(03): 94–102.
Zheng Y.F. & Guo Z.X. (2016). Structural performance of innovative grout sleeve splicing for rebars under
cyclic loading. Journal of Hunan University 43(11): 131–140.
Experimental research on silica fume exciting steel slag and ground granulated
blast-furnace slag to solidify soft soil
Deng, Y. F. Zhao, Y. & Liu, Q. W. , et al. (2018). Na2SiO4-and cement-based activation on steel slag and its
application in soft-soil stabilization [J]. China J. Highw. Transp., 31(11): 11–20.
Gong, X. N. (2008). Foundation Treatment Manual [M]. Beijing: China Construction Industry Press,
2008:5–7.
Ministry of Housing and Urban-Rural Development of the People's Republic of China . (2009). Standard for
test method of basic properties of construction mortar [S]. Beijing: China Planning Press.
Wang, Q. (2010). Cementitious properties of steel slag and its role in the hydration and hardening process of
complex binder [D]. Beijing: Tsinghua University, 2010: 29–34.
Yi, Y. L. & Qing, X. W. & Zhuang, Y. et al. (2013) Utilization of GGBS in stabilization of soft soils and its
mechanism [J]. Chinese Journal of Geotechnical Engineering, 35(2): 829–833.
Numerical study of lateral breakout resistance for shallow-embedded pipeline in
sand
Bauer E. (1996). Calibration of a comprehensive hypoplastic model for granular materials. Soils Found.
36(1): 1326.
Brennodden H. , Sveggen O. , Wagner D. (1986). Full-Scale Pipe-Soil Interaction Tests, Proceedings of the
18th Offshore Technology Conference, OTC paper 5338, 433-440.
Cheuk, C.Y. , White, D.J. , Bolton, M.D. (2006). Large-scale modeling of soil-pipe interaction during large
amplitude cyclic movements of partially embedded pipelines[J]. Canadian Geotechnical Journal, 44 (8):
977–996.
Gudehus G , Amorosi A , Gens A , et al. (2008). The soilmodels.info project[J]. International Journal for
Numerical and Analytical Methods in Geomechanics, 32(12); 1571–1572.
Gudehus G. (1996). A comprehensive constitutive equation for granular materials. Soils Found. 36(1): 112.
Kolymbas D , Herle I , von Wolffersdorff PA . (1995). Hypoplastic constitutive equation with internal
variables. Int J Numer Anal MethodsGeomech. 19(6): 415436.
Kong D. , Feng L. , Zhu B. (2020). Assessment model of pipe–soil interaction during large-amplitude lateral
displacements for deep-water pipelines[J]. Computers and Geotechnics.
Kong D. , Martin C.M. , Byrne B.W. (2017). Modeling large plastic deformations of cohesive soils using
sequential limit analysis International Journal for Numerical and Analytical Methods in Geomechanics, 41
(18), pp. 1781–1806.
Lyons, C. G. (1973). “Soil resistance to lateral sliding of marine pipelines.” In Proc., Offshore Technology
Conf., 479-484. Houston.
Niemunis A , Herle I. (1997). Hypoplastic model for cohesionless soils with elastic strain range. Mech
CohesiveFrict Mater. 2(4): 279299.
R. Liu ., S. W. Yan ., H. B. Wang . (2011) Model tests study on restraint of sand soil on buried pipeline.
Chinese Journal of Geotechnical Engineering, 33(04): 559–565.
Rismanchian A. , White D.J. , Randolph M.F. , Martin C.M. (2019). Shear strength of soil berm during lateral
buckling of subsea pipelines[J]. Applied Ocean Research.
Veritas D N . Pipe-soil interaction for submarine pipelines[J]. Det Norske Veritas (DNV), Oslo, Norway. DNV-
RPF114, 2017.
Verley, R. , and T. Sotberg . (1994). “A soil resistance model for pipelines placed on sandy soils.” J. Offshore
Mech. Archit. Eng. 116(3): 145–153.
von Wolffersdorff PA . (1996). A hypoplastic relation for granular materials with a predened limit state
surface. Mech CohesiveFrict Mater. 1(3): 251271.
Wagner, D. A. , J. D. Murff , H. Brennodden , and O. Sveggen . (1987). “Pipe-soil interaction model.” In
Proc., Offshore Technology Conf., 181-190. Houston.
Wang L.Z. , Wang H. , Zhu B. , Hong Y. (2018). Comparison of monotonic and cyclic lateral response
between monopod and tripod bucket foundations in medium dense sand. Ocean Engineering, 155, pp.
88–105
Wang Y. , Liu R. , Wang L. (2018). Experimental and upper-bound analysis of lateral soil resistance for
shallow-embedded pipeline in Bohai Sand[J]. Journal of Pipeline Systems Engineering and Practice, 9(4).
Wang Z. , Tang Y. , Feng H. , Zhao Z. , Liu H. (2017). Model Test for Lateral Soil Resistance of Partially
Embedded Subsea Pipelines on Sand during Large-Amplitude Lateral Movement Journal of Coastal
Research, 33 (3), pp. 607–618.
Wang, L. , and R. Liu . (2016). “The effect of a berm on the lateral resistance of a shallow pipeline buried in
sand.” Ocean Eng. 121(Jul): 13–23.
White D.J. , Clukey E.C. , Randolph M.F. , Bransby M.F. , Zakeri A. , Hill A.J. , Jaeck C. (2017). The state of
knowledge of pipe-soil interaction for on-bottom pipeline design. Proceedings of the Annual Offshore
Technology Conference, 2, pp. 969-995.
White, D.J. , Cheuk, C.Y. (2008). Modelling the soil resistance on seabed pipelines during large cycles of
lateral movement[J]. Marine Structures, 21 (1): 59–79.
Wu W , Bauer E , Kolymbas D. (1996). Hypoplastic constitutive model with critical state for granular
materials. Mech Mater. 23(1): 143163.
Analysis and design of coupled heat and moisture performance of new self-
insulation blocks of recycled ceramsite concrete
Ashrae . 2017 ASHRAE Handbook-Fundamentals [M]. Atlanta: ASHRAE Inc, 2017.
Chen Y. M. , Dong W. Q. , Bao Y. , et al. Comparisons and Validation of Two Dynamic Models for Coupled
Heat and Moisture Transfer in Building Envelopes [J]. Journal of Hunan University (Natural Sciences), 2020,
47(11): 133–140.
Chongqing University . Evaluation Standard for Indoor Thermal Environment in Civil Buildings: GB/T 50785-
2012 [S]. China Construction Industry Press, Beijing, 2012.
Chu S S , Fang T H , Chang W J . Modelling of coupled heat and moisture transfer in porous construction
materials[J]. Mathematical and Computer Modelling, 2009, 50(7): 1195–1204.
GB/T15229-1994 . Lightweight Aggregate Concrete Small Hollow Block [S]. 1994.
K Nzel H Ȕ. Simultaneous heat and moisture transport in building components [M]. Suttgart: Fraunhofer IRB
Ver-lag, 1995: 39–40.
Khoshbakht M , Lin M W , Feickert C A . A finite element model for hygrothermal analysis of masonry walls
with FRP reinforcement[J]. Finite Elements in Analysis and Design, 2009, 45(8/9): 511–518.
Li Sihui . Experimental Study on Coupled Heat, Air and Moisture Transfer Characteristics of Composite
Block Walls [D]. China University of Mining and Technology , 2017.
Liu X. X. , Zhao Z. C. , Zou S. Q. , et al. Application of COMSOL Multiphysics Software in the Simulation of
Heat and Moisture Transfer of Composite Blocks [J]. Software Guide, 2022, 21(02).
Luikov A V . Heat and mass transfer in capillary-porous bodies [M]. Oxford: Pergamon, 1966: 75–99.
Philip J R , Devries D A . Moisture movement in porous materials under temperature gradients [J].
Transactions American Geophysical Union, 1957, 38 (2): 222–232.
Sui X.M. , Gong S. K. , Xu B. , et al. Thermal Performance Research and Optimal Design of Concrete Self-
insulation Compound Block [J]. Journal of Architecture and Civil Engineering, 2022, 39(1): 87–96.
Vasilyev G P , Lichman V A , Peskov N V , et al. Simulation of heat and moisture transfer in a multiplex
structure [J]. Energy and Buildings, 2015, 86: 803–807.
Wang J. Y. Experimental Study on the Performance of Recycled Ceramsite Concrete and Its Hollow Blocks
[D]. Guangxi University, 2014.
Yu H. , Yang K. M. , Wang Y. C. , et al. Multi-Scale Coupled Heat and Moisture Transfer in Grain Storage
with Horizontal Ventilation [J]. Journal of the Chinese Cereals and Oils Association. 2021, 36(08)
Yu S. Research on Issues Related to Heat and Humidity Coupling Action on Building Walls [M]. Northeastern
University Press, Shenyang, 2018.
Study on loess degradation and high fill slope deformation evolution mechanism
based on model test
Bao Xiaoyi , Chen Liang . (2012). Recent progress in distributed fiber optic sensors. J. Sensors. 12,
8601–8639.
Derbyshire, E. (2001). Geological hazards in loess terrain with particular reference to the loess regions of
China. J. Earth-Science Reviews. 54, 231–260.
Guo Yongjian , Wang Shaofei , Li Wenjie . (2013). Application of stress monitoring in highway rock slope. J.
Rock and Soil Mechanics. 34(5), 1397–1402.
Li Jian-Zhi , Sun Bao-Chen , Du Yan-Liang . (2014). Union self-compensated packaging of FBG strain
sensor. J. Optoelectronics Letters. 10, 30–33.
LI Yalan . (2005). Study on slope stability and prevention measures of loess slope. Xi'an: Chang'an
University.
Liu Jie , Yao Hai-Lin , Hu Meng-Ling et al. (2011). Moisture Changes and Influencing Factors of Unsaturated
Soil Subgrade under Atmospheric. J. Journal of Shanghai Jiaotong University. 5(1), 772–776.
Rahardjo H , Li X W , Toll D G , et al. (2001). The effect of antecedent rainfall on slope stability. J.
Geotechnical and Geological Engineering. 19(3), 371–399.
Simulation analysis of the force performance of the SRC Cantilever beam in the
transition layer
Isaac Montava , Ramón Irles , Juan Carlos Pomares , et al. Experimental Study of Steel Reinforced
Concrete (SRC) Joints[J]. Applied Sciences, 2019, 9(8):1528.
Li Junxia . (2009) Experimental Study and Ultimate Bearing Capacity Calculation of Chongqing Grand
Theater Steel Concrete Beams [D]. Chongqing University.
Wang Dasui , Zhou Jianlong . (2010) Development and prospects of steel-concrete hybrid structures for
high-rise buildings in China[J]. Journal of Building Structures, 31(06):62–70.
Wang Qiuwei , Zhang Yuekun , Zhang Hazhen . (2016) Finite element analysis of force performance of
nodes in steel and concrete space[J]. Journal of Xi'an University of Architecture and Technology (Natural
Science Edition), 48(06):853–861.
Wei Juntao . (2011) Finite Element Numerical Simulation of Steel Concrete Cantilever Deep Beam [D].
Chongqing University.
Research on concrete perfusion technology of arch rib steel tube of Nalao Bridge
in Pingguo County
Chen B C , Liu J P . (2020) Review of Construction and Technology Development of Arch Bridges in the
World[J] Journal of Traffic and Transportation Engineering(in Chinese), (01), 27–41.
Chen B C , Wei J G , et al. (2017) Application of Concrete-filled Steel Tube Arch Bridges in China: Current
Status and Prospects [J]. China Civil Engineering Journal(in Chinese), (06), 50–61.
Chen B C , Zhang M J , et al. (2021) Application and Prospects of Concrete Arch Bridges in China [J].
Journal of Fuzhou University (Natural Science Edition) (in Chinese), (05), 716–726.
Chen N , Ma J , et al. (2009) Construction Process of Self-compacting Minimum Inflation High Compressive
Strength Concrete-filled Steel Tube [J]. Concrete (in Chinese), (03), 76–78.
Han Y. (2015) Tests of Vacuum-Aided Casting of Concrete in Tubes of a CFST Arch Bridge and Application
of the Casting to Actual Bridges [J]. Bridge Construction (in Chinese), (02), 19–25.
Hou W Q , Yang J J , Zhang Z X , et al. (2021) Experimental Study and Application of Manufactured Sand
Self-Compacting Concrete in Concrete-filled-steel-tube Arch Bridge: A case study[J]. Case Studies In
Construction Materials, 15.
Hua L , Yi W A , Ywa B , et al. (2020) Effect of CaO and MgO based expansive agent on deformation and
mechanical properties of concrete-filled steel tubes - ScienceDirect[J]. Construction and Building Materials,
250.
Luo Y F , Wang J J , Chen G H . (2013) Pouring Construction of Concrete-filled Steel Tube for Arch Rib of
Hejiang Changjiang No.1 Bridge [J]. Journal of China and Foreign Highway (in Chinese), (03), 158–160.
Wang H W , Xie K Z , et al. (2019) Study of Stability of Arch Ribs of Long-Span Concrete-Filled Steel Tubular
Arch Bridge During the Concrete Casting Process [J]. World Bridges (in Chinese), (05), 49–53.
Wei M. (2021) Study on Construction Quality Control of Concrete Primary Jacking Booster Injection in Long-
span Concrete-filled Steel Tube Arch Bridge [J]. Engineering and Technological Research(in Chinese), (11),
79–80.
Yang D , Dong F M , et al. (2021) Research on the Sequence of Concrete Pouring in Pipe for Deck
Concrete-filled Steel Tube Arch Bridge [J]. Industrial Safety and Environmental Protection(in Chinese), (07),
60–64.
Zhang H , Luo C P . (2015) Numerical Simulation of Pouring Concrete in Concrete-filled Steel Tube Arch
Bridge [J]. Bridge & Tunnel Engineering(in Chinese), (06), 255–256+259.
Zheng J L , Wang J J , et al. (2014) Feasibility Study on Design and Construction of Concrete filled
Steeltubular Arch Bridge with a Span of 700 m [J]. Engineering Sciences in China(in Chinese), (08), 33–37.
Zheng J L , Wang J J , et al. (2014) Vacuum Aided Concrete Grouting Process Test of Concrete Filled Steel
Tube Arch Segment [J]. China Journal of Highway and Transport(in Chinese), (06), 44–50.
Zheng J L . (2016) New Development ‘Tendency of Large-Span Reinforced Concrete Arch Bridges in China
[J]. Journal of Chongqing Jiaotong University(Natural Science) (in Chinese), (S1), 8–11.
Zheng J , Wang J. (2017) Concrete-filled Steel Tube Arch Bridges in China[J]. Engineering, 4(001):
143–155.
Research on arch effect of high and steep slope asphalt concrete core dam
based on ABAQUS
Gao A , Su H , Liu C. (2015) Analysis of soil arching in high core-wall rockfill dam. Journal of Hydroelectric
Engineering, 34(9): 138–145
Gao Y , Wang L , et al. (2020) Evaluation of valley topography effects on the seismic stability of earth-rockfill
dams via a modified valley topography coefficient. Computers and Geotechnics, 128: 103814
Jiang S , Yang J , et al. (2016) Deformation coordination and seepage prevention of asphalt concrete core-
wall and transition layers. Journal of Hydroelectric Engineering, 35(4): 98–107
Lin J , Hu W , et al. (2013) Arching effect analysis of core wall in Pubugou dam. Rock and Soil Mechanics,
34(7): 2031–2035
Yang C , Dang F , et al. (2016) Influences of valley topography on deformation properties of asphalt concrete
core dam. Hydro-Science and Engineering, (4): 54–62
Yang C , Xue H. (2021) Mechanism and influence range of stress arching effect of CFRD in narrow valley
regions. Chinese Journal of Geotechnical Engineering, 43(S1): 214–218
Zhang Y , Wang W , et al. (2015) Investigation on conditions of hydraulic fracturing for asphalt concrete used
as an impervious core in dams. Construction and Building Materials, 93, 775–781.
Seepage analysis of Chuanqin diversion tunnel under the condition of deep well
dewatering
Deng, M.J. (2018) 'Three Water Lines' strategy: Its spatial patterns and effects on water resources allocation
in northwest China, Acta Geographica Sinica, 73(7): 1189–1203.
Golian, M. , Abolghasemi, M. , Hosseini, A. (2021) Restoring groundwater levels after tunneling: a numerical
simulation approach to tunnel sealing decision-making. Hydrogeology Journal, 29(4): 1611–1628.
Kong, L.X. , Liu, Z.X. , Ning, Y. (2016) Seepage Analysis of Headrace Tunnel of Nabang Hydropower Station
Project. Water Power, 42(11): 47–49,61.
Li, C. , Cheng, W.Q. , Shang, D.B. (2020) Study on supplementing water plan from Yellow River to
Baiyangdian. Journal of Hebei Agricultural University, 43(4): 97–103.
Ong'or, BTI ., Shu, L.C. (2007) Groundwater overdraft vulnerability and environmental impact assessment in
Arusha. Environmental Geology, 51:1171–1176.
Shang, W.X. , Peng, S.M. , Wang, Y. (2020) Competition and cooperation relationship of water utilization in
water shortage basins: a case study of Yellow River basin. Advances in Water Science, 31(6): 897–907.
Shi, Y. , Lu, C. , Liu, S.H. (2021) Stability analysis of high earth-rock cofferdam under the condition of deep-
well dewatering. Port & Waterway Engineering, pp. 207–214.
Wang, C.Y. , Zhang, H.C. , Zhang, W.J. (2004) The effects of deep well dewatering on the earth pressure of
supporting structure. Rock and Soil Mechanics, pp. 1845–1848.
Yang, J.M. , Zhao, L.H. , Shen, Z.Z. (2021) Depth optimization of anti-seepage curtain of the upper reservoir
in a pumped storage power station. Journal of Water Resources and Water Engineering, 32(2): 209–216.
Zhang, F. , Han, A.G. , Ren, G.M. (2015) Numerical Simulation on Landslide Stability Affected by Seepage
Field Variation Caused by Tunnel Excavation. Journal of Yangtze River Scientific Research, 32(05): 61–65.
Zhang, W.B. , Shen, Z.Z. , Chen, G.Y. (2021) Optimization design and assessment of the effect of seepage
control at reservoir sites under karst conditions a case study in Anhui Province, China. Hydrogeology
Journal, 29(5):1831–1855.
Zhou, R.J. , Shen, Z.Z. , Xu, L.Q. (2016) Effect of tunnel excavation on groundwater environment based on
three-dimensional unsteady seepage flow analysis. South-to-North Water Transfers and Water Science &
Technology, 14(6): 135–140.
Study on the response of surrounding rock with buried depth and rock grade in
tunneling
Guo Yukui , Ma Qihe , Guo Zhenshan . Numerical analysis of tunnel deformation and supporting force
considering rainfall infiltration[J]. Journal of Civil Engineering and Management, 2015, 35(4):52–57.
Hu Qunfang , Qin Jiabao . Statistical analysis of subway tunnel construction accidents from 2003 to 2011[J].
Journal of Underground Space and Engineering, 2013, 9(3):705–710.
Huo Lijie . Numerical analysis of unsupported excavation force of new Luyujiang tunnel in Shanghai [J]. Well
Construction Technology, 2014, 35(1):33–36.
Li Fengwei , Du Xiuli , Zhang Minju . Statistical analysis of subway construction accidents[J]. Journal of
Underground Space and Engineering, 2014, 10(2):474–479.
Li Shucai , Xu Zhenhao , Huang Xin , et al. Classification of disaster structures caused by water and mud
inrush in tunnel, geological identification, disaster model and typical case analysis[J]. Journal of Rock
Mechanics and Engineering, 2018, 37(5):1041–1069.
Li Yuansong , Li Xinping , Dai Yifei , et al. Stress characteristics test and numerical analysis of tunnel
surrounding rock and lining [J]. Rock and Soil Mechanics, 2007, 28 (7): 1348–1352.
Liu Hui , Zhang Zhichao , Wang Linjuan . Statistical analysis of tunnel construction accidents in China from
2004 to 2008[J]. Chinese Journal of Safety Science, 2010, 20(1):96–100.
Liu Pengju , Li Gang , Peng Wei . Research status and development of tunnel fire[J]. China Science and
Technology Information, 2008, (2):35–38.
Qiu Yunan , Zhang Changyong . Research on preventive measures for gas Accidents in railway Tunnels[J].
China Railway, 2009, (7):26–28.
Sun Xishou , Liu Shilong . Technical summary of comprehensive treatment plan for tunnel roof protruding
mud[J]. Highway Engineering, 2011, 36(3):119–121+130.
Wang Lei , Xu Lifen . Numerical analysis of surrounding rock pressure and initial supporting force of biased
tunnel[J]. Subgrade Engineering, 2009, 6:156–158.
Xia Chenxi , Han Hui . Research on the application of FTA in the safety control of subway tunnel blasting
operation[J]. The Construction Technology, 2017, 46 (add):1075–1077.
Zahng Junwei , Chen Yunyao , Chen Tuo . Analysis of the rules and characteristics of tunnel construction
accidents in China from 2006 to 2016[J]. Modern Tunneling Technology. 2018, 55(3):10–17.
Zhang Junwei , Chen Yunyao , Sun Yifu . Analysis of the distribution characteristics of collapse accidents in
tunnel construction in China (2006-2016)[J]. Disaster, 2017, 32(4):132–137.
Zhang Xu , Ye Guanlin , Wu Huiming . Numerical analysis of the mechanical and deformation characteristics
of surface access shield tunnel[J]. Underground Space and Engineering Journal, 2016, 12(2):436–441.
Analysis of the runoff and seepage drainage effects of prefabricated roof double-
layer drainage system
Bi Xinlei , Lin Haixia , Wang Xin. Design and Construction of Prefabricated Roof System in Inner Mongolia
Rongfu Garden Community (J). China Building Waterproofing, 2019(12):44–47.
Chen Xiaowen . Development and Application of High-performance Polymer Modified Asphalt Waterproofing
Paints (D). Hubei University of Technology, 2018.
CJJ142 -2014, Technical Specifications of Building Roof Rainwater Drainage System (S). : China
Architecture & Building Press, 2014.
GB/T-50123 -2019, Geotechnical Test Method Standard (S). Beijing: China Jihua Press, 2019
GB50345 -2012, Roof Engineering Technical Specifications (S). Beijing: China Architecture & Building
Press, 2012.
Lin Haixia , Bi Xinlei , Wang Xin . Application of Industrialized Prefabricated Roof System in the Xiong’an
Design Center (J). China Building Waterproofing, 2019(03):13–16.
Wang Liang . Research on the Causes of Building Roof Leakage and Prevention Strategies (J). Housing and
Real Estate, 2019 (12):34.
Zhu Jinli . Causes of Roof Seepage and Preventive Measures (J). Engineering and Technological Research,
2021, 6(19):155–156.
Application of viscous damper in vibration reduction of steel tube concrete
special-shaped arch bridge
Peng YH , He XH , Jing HQ , et al. Study on seismic damping of semi-floating system CFST arch bridge with
viscous dampers[J]. Journal of Railway Science and Engineering, 2021, 18(06):1504–1512.
A Lu Guichen,Hu Lei-ting. Parameter analysis of liquid viscous dampers for Xihoumen Bridge[J]. World
Bridge Bridges, 2005. (02):43–45.
Chen Yongqi , Geng Ruiqi , Ma Liangzhe . Design and selection of fluid viscous devices for shock control of
bridges[J] . China Civil Engineering Journal, 2007, 40(7) 55–61.
Chen Yongqi , Ma Liangzhe. Design and evaluation of limited displacement damper of Sutong Yangtze River
bridge [J] . Modern Transportation Technology, 2008, 5(4) 20–24.
Fan Dingqiang , Liu Jiahui , Ruan Hanlin , et al. Study on parameters of nonlinear viscous dampers of
Dinghai Bridge[J]. China and Foreign Highway, 2019, 39(04):60–63.
Nie Liying , Song Hui , Fan Lichu . Discussion on effects of a fluid viscous damper on protecting function for
expansion joints in long-span bridges[J]. Earthquake Engineering and Engineering Vibration, 2007, 27(2)
131–136
Zhou R , Wang H , Zong Zhouhong , et al. Study on the parameters of seismic control devices for large-span
steel pipe and concrete arch bridges[J]. Journal of Disaster Prevention and Mitigation Engineering, 2011,
31(05):535–541
A method for line-shape and suspender force control of tied-arch bridges based
on stress-free state theory
Chen C B , Zheng H Y . “Analysis on the Type of CFST Bird Arch Bridge.” Journal of China & Foreign
Highway. 43–51 (2006).
Han B Q . “Comparison and Selection of Tensioning Scheme for Hangers of concrete-filled Steel Tube Arch
Bridge.” Bridge Construction. 114–119 (2015).
Li J , Chen H , Jiang Y Y , Zhou M K . “Study on the calculation of boom force and method of cable
adjustment for steel and concrete tied arch bridges.” Railway Engineering. 7–10 (2014).
Li Z Y . “Research and Application of Stress-Free State Method in Concrete-filled Steel Tubular Arch Bridge.”
Xi’an: Chang’an University, 2019.
Qin S Q . “Bridge Construction Control - Theory and Practice of Stress-free State Method.” China
Communications Press, 2007.
Qin S Q . “Unstressed State Control Method for Bridges Constructed in Stages.” Bridge Construction. 8–14
(2008).
Shao Z X . “Research on Construction Control of Steel Box Tide Arch Bridge under Unstressed State
Method.” Xi’an: Chang’an University, 2018.
Wang H P . “Research on Application of Unstressed State Method in the Construction Control of Long-Span
CFST Arch Bridge.” Chengdu: Southwest Jiaotong University, 2013.
Wu H J , He L , Wang S R , Li J Q , Lu P. “Geometry Control Method Based on Stress-Free State Theory for
Long-Span Concrete-Filled Steel Tube Arch Bridges.” Bridge Construction. 20–26 (2020).
Xiao R C , Xiang H F . “Influence Matrix Method of Cable Tension Optimization for Cable-Stayed Bridges.”
Journal of Tongji University (Natural Science). 235–240 (1998).
Zhang C X , Zhang J S , Liu C L . “Study of Construction Monitoring and Control for San’an Yi Jiang River
Bridge.” World Bridges. 37–41 (2015).