The document provides steps for assembling a basic computer, including opening the computer case, mounting the motherboard, installing the CPU and ensuring proper orientation, attaching the CPU cooler and fan, installing the power supply and connecting power cables, and inserting RAM sticks into slots on the motherboard.
The document provides steps for assembling a basic computer, including opening the computer case, mounting the motherboard, installing the CPU and ensuring proper orientation, attaching the CPU cooler and fan, installing the power supply and connecting power cables, and inserting RAM sticks into slots on the motherboard.
The document provides steps for assembling a basic computer, including opening the computer case, mounting the motherboard, installing the CPU and ensuring proper orientation, attaching the CPU cooler and fan, installing the power supply and connecting power cables, and inserting RAM sticks into slots on the motherboard.
The following below are the basic steps needed for assembly a computer
Step1 OPEN CASE
Remove back screw.
Take cover off. Step2 MOUNT MOTHERBOARD Screw motherboard standoff into case. Punch out rear I/O plate from the case and replace it with motherboard I/O plate. Fasten the motherboard in place on top of the mounting standoffs. Step3 MOUNT PROCESSOR (CPU) Locate the CPU socket holder on the motherboard. Lift up the latch lever to release and hinge open the CPU socket cover. Holding the CPU by it side line up any alignment notches or the triangle on the corner of the CPU to the triangle marked on the motherboard to ensure the correct orientation. Step4 INSTALL CPU COOLER If required, apply thermal to back of CPU. Seat CPU heatsink/cooler and fix in position. Plug the power cable attached to cooler fan into the motherboard connector. Step5 INSTALL POWER SUPPLY (PSU) Mount the supply and fasten with screw to the case mounting points. Plug the largest cabling connector from the power supply cabling into the motherboard power connector. Plug the 8 pin cabling connector for the power supply cabling into the CPU power connector. Step6 MOUNT MEMORY (RAM) Press open the clip at both ends of the RAM mounting slots. Line up the notch on the RAM stick with mounting slot Seat the RAM and press it firmly down into the slot.
ARDUINO PROGRAMMING FOR BEGINNERS: A Comprehensive Beginner's Guide, Tips and Tricks, Simple and Effective methods and Advanced methods to learn and understand Arduino Hardware and Software