Professional Documents
Culture Documents
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-1. Components Layout
U7003
Ambient sensor
SOC8003
RCAM3 CONN
SOC8002
RCAM1 CONN
CN7000
SIM/SD CARD
Socket
U1004
U6000
POWER AMP
IF PMIC
ANT6000,ANT6001
Motor Contact ANT6005, ANT6004
ANT6002, ANT6006
ANT1002 SIDE KEY CONTACT
U7001 UCP400 UME5000 U6005
GND CCP
SPK AMP AP MEM Direct charger
MIC7000 SOC8000
SUB MIC VT CAM
U2009
CONN
DRX LFEM
U3001
BT/WIFI/FM
PAM2000
HIGH BAND PA
SOC8004
RCAM4 CONN
U2001
Transceiver
LED6000
FLASH LED
U1000
RCAM2 CONN
U7006
CODEC
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
SOC1001
BTP CONN
SW1005
SW1002 RF Switch
RF Switch
ANT1007
Ant CONN
U1003
FM LNA
ANT1010
Ant CONN CON1000
Ant CONN
ANT1008
Ant CONN
ANT1009
Ant CONN U1001
Grip Sensor
ANT1005
SW1004 U1002 ANT1000 Ant CONN
RF Switch Hall IC Ant CONN
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
SM-A525F Block Diagram
ANIBAL GARCIA VENEZUELA
SM-A525F/M
Common
MAIN2 ANT
MB/HB
https://irepairvenezuela.com/
EBI0_CA(0:5)
PRX_TR_IN_B7 PRX_MHUHB1
EBI0_DQ(0:15)
EBI0_CLK/CKE/CS/DMI/DQS
TX_TR_OUT_B7_38_40_41_CH0 EBI1_CA(0:5)
TX_CH0_HB1
HB FEMid
TX_PA_OUT_B7
EBI1_DQ(0:15)
Memory
TRX_ANT_HB
SFMD3L0F001 EBI1_CLK/CKE/CS/DMI/DQS
LPDDR4 4/6/8GB
TRX_B40 HB PAM DDR_RESET_N
uMCP 128GB
Coupler Diplexer WIPS33232-01
UFS TX/RX
HHM22137A3 DPX252690DT-5075C1K LNA
@irepair.ve
K PRX_TR_IN_B38_40_41 PRX_MHUHB2
MXD8921HS UFS REFCLK
TRX_B38_41
UFS_RST_N
TX_PA_OUT_B1 VBUS_IF
OVP VBUS_OVP
TX_PA_OUT_B20 IF_PMIC_SDA/SCL
TX_PA_OUT_B12_17 LMB TX_TR_B5_8_12_13_17_20_28_71 TX_CH0_LB2 CC_SDA/SCL
Direct Charger
MAIN1 ANT IFPMIC
TX_PA_OUT_GSMHB MMMB PA IF_PMIC_INTB IF_PMIC_SDA/SCL PCA9468UK
LB QM58110
TX_PA_OUT_GSMLB TX_TR_OUT_GSMLB TX_CH0_LB1 TYPE_C_INT SM5714
TX_PA_OUT_B4_66 USB_AP_D_P/N VBATGND_DC_SENSE
VBAT_SENSE
TX_PA_OUT_B28 AP_UART_RXD/TXD
VBATTERY_CON
CAM_FLASH_EN CSP Battery
A525M Only
CAM_TORCH_EN
B13 DPX TX_PA_OUT_B13
PRX_ANT_MB TRX_B13
Coupler ANTMB B8682 VBATGND_SENSE
PRX_TR_IN_G1900_B2 SUB_REV
PRX_LMB3
GRIP_I2C_SDA/SCL GRIP SENSOR
PRX_TR_IN_G850_B5 GRIP_INT2 PMIC(SUB)
PRX_LMB2 LOWER
QLINK_CLK_P PM6150A VOL_UP Vol UP
PRX_TR_IN_EGSM_B8
PRX_MHB4 QLINK_CLK_N
CAM_FLASH_EN
PRX_TR_IN_B20
PRX_MHB2
FG_ERR
PRX_TR_IN_G1800_B3 RFFE1_CLK
PRX_MHB3 TSP_INT
OCTA_CON_DET
RFFE1_DATA
PRX_SW_IN_B1 PRX_TR_IN_B1_4_66
SPDT LNA SPDT TSP_SDA/SCL VDD_LCD_ELAVDD_7P6
VDD_LCD_ELVDD_4P6
MXD8621E MXD8921HS MXD8621E Display VDD_LCD_ELVSS_-4P4
PRX_SW_IN_B4_66 PRX_TR_IN_B1_4_66_CA OCTA_MIPI_D(0:3)_P/N Display
EL_ON2 PMIC
SUB ANT1 OCTA_MIPI_CLK_P/N
EL_ON1 S2DOS15X04-6030
LB OCTA_RST_N
EL_ON1_DET
SAW
A525F Only PI3WVR648GEAEX-71 MIPI_RCAM4_DATA/CLK RCAM4
DRX_B32
SAFFB1G47AA0F3K 5M
RCAM4_SENSOR_I2C_SDA/SCL
RCAM4_MCLK / RCAM_FSYNC
MACRO
GPS Extractor LNA SAW RCAM3 RCAM3 RCAM3 RCAM1 RCAM1 CAM MCU RCAM4 RCAM4
QM28014 GNSS_RF_L1_IN GNSS_RF_L1_IN GNSS_IN_L1 RCAM2_LDO_EN
MXDLN16U SFHG89BF302
AVDD LDO AVDD LDO DVDD LDO OIS AVDD LDO DVDD LDO AVDD LDO DVDD LDO
WiFi 5G ANT RCAM3_LDO_EN
WL_BT_RFIO_2G_CH0 RCAM1_LDO_EN
RCAM4_LDO_EN
WL_BB_IQ_TX CAM_PMIC_I2C_SDA/SCL
Global RF Band Information NFC ANT SPK AMP I2C SDA/SCL SPK_OUT_P/N SPK
SPK_I2S3_BCLK/DO/DI/WS SPK AMP SPK_SNS_P/N
GSM : 850/ 900/ 1800/ 1900 AMP_EN
SPK_AMP_INT
TAS2562HYFPR
NFC_SWP1
ANIBAL
U7003
GARCIA VENEZUELA BOTHHOLE4004
https://irepairvenezuela.com/
BOTHHOLE4008
BOTHHOLE4005
C8017
L8004
ANT3000
C3000
CON4001 TP3005
@irepair.ve
TP3006
TP3000
TP3001
TP3002
TP3004
ANT1001
TP3003
C3001
ANT3002
SOC8003
R7009
TP7010
C7042
U8004
R4014 R4013 C8019
C8031
ANT1000 U8011U8007
TP7020
C8030
C8018
U8003
C8033
C8026
C8032
R8011
TP8004
TP8003 C8027
R4012 R4010
U8001
C8059
U8006
TP8005
C8060
C8025
R8008
C7046
R8005
C7050
CN7000
L7019
R4028
R4026
R8010
R8009
C8061
C7049
C8054 C8055
R8006
L7018
R7010
C8067
L8001
C6104
C7052
C8068
U8008
R4009
R4007
R7012 C6103 R7014
C8049
C8050 C8051
R8007
C8010
SOC8002
C7000
R4019
R4020
BOTHHOLE4000 BOTHHOLE4001
TP7000 C7004
R4029
TP7002
C7019 C7020
R7016
GND1
L7002
U7000 L7008
TP7003
C8006
L6011
R4041
R4040
Common
C5074
R8004
UCP400
C8040
C8041
R7017 C1062 C1053 C1054 R5001
R5000 C8043
C8042
C8046
C8047
C8048
TP3014
C5094
C1082 C8038
U8005
U1004
L1034L1035L1036L1037C1058 L1054 L1048 C1089
C1042C1044 C1046 C1051L1040 L1055 C1088 C1093
C6032
C8034
TP7001
C1043 C1045 C1047C1052 C1064 L1056 L1051 L1053
L1046
SC9001
C8044
TP7013
C8039
C6012
C1083 TP7012
C5095
C1069
OSC6000
R4042
R4043
C8037
UME5000
L1043 C5101 C6010 R6002
C1073
TP5003 TP5002
C5130 C6110 R6003
L6000
C1061 C5127
TP5004
C6005 C6007
D6000
L1065 VBUS
TP_SLEEP_CLK
TP5001
TP5006
C5126 C5102
C4004
D6001
C1059 TP4002 TP5008
SC9002
C1060
C1067 C6017
U6000
C1066 C6001 R6009
ZD6000
C6008
C6009
L1041
C1049
C6002 C6019 GND
L1038 C6000
C1050
C6020
TH6000
R6012
C1056
C1055
C1057
C6004
C6016
C6003
C6078
R7004 TP5000
ANT6003
R4046 TP6003
TH4000 C4005
U7001
C7031 R4035
C9015 BOTHHOLE4007
TP4001
R4044 L6006
L9003
C7029
C7036
R4036
C6113
R4039
R4038
C9004
C9003
C9005
TP6006
BOTHHOLE4003
L9002
C7028
C9017L9004
C9016
R4034 C9014
C5079
C9011 L9005
C5077L3016L3015
C5118
C5078
R6007
C5100
C5080
R6006
C6114
R4024
R4022
U6005
R4045
C6119
C3043
C9010
C7037
R4027
C9013
C6120
TP3015 TP3012
C3051
R4025 TP3013
C7056
ZD6004
C6117
TP3016
L6015
C3058 C3048
C6115
ANT6000 ANT6001
L7015
L7014
R7021 R7022
C7038
R6026
R7019
U3007
ZD6006
TP3011
ZD6005
C3060 R6027
C7051
C7040
C7039
C6023
C9007
C9009
C9006
C9008
V5000
R5044
R6025
C9002
C9001
ANT1002
C3054 C6077
ANT6002 ANT6006
C3047
L6014
C3046
C3050
C3049
C3042
R4002
R4000
R6001
ZD6003
JTAG4000 JTAG4001
JTAG4002
ANIBAL GARCIA VENEZUELA
R7011MIC7000
ANT2001 ANT2000 ANT2002 ANT2004 ANT2003
L2050
L2053
U2000
L2001
L2007 C2043
https://irepairvenezuela.com/
L2006 L2010
C2130
L2004
R4015
L2000 C2000
C7043
C7003
R4016
R7003
C2036 C7006
L2005
C2001
F2000
C2109 C3035 L3011
C3023 C3022
C3020
C3021
C3019
C3018
C3029
C3028
R3000
C2039
L7003
L2003
C2045 C3033 C3034 U7005
C7007
L2016L2014
SOC8000
TP_WCSS_DATA TP_WCSS_CLK
C3016
U3001
C3017 C2021
@irepair.ve
L3005
L3004
C2044
C2046
L3018 C3063 C3067 TH3000
C3003
L3000
C9022 C3007
C3015
C3030
U3008
C3065
L3019
C3032
L3002
U3000
L3001
C2047
C3002
C2112 BOTHHOLE4006 C3014 L3003
U2008
L2013
C2113
C3013
C3025
C3027
F3000
L3010
C3004
C3062 L2012 TP3007
C3024
L2038
TP3008
C2117
R4003 R4001
C8002
C3068 C3069C3070
R4017 R4018
L2011
ZD1000 C2051
U2003
L2048
C8003
F2006
C8001
C8062
L8000
C2115 C2114 C2111 C2110
L2044
U2009
C2053
C2052
U9002
U9015
C2090
C2050
C2095
C2096
C7048
ANT7001 C2128 C2125 C2123
C2079 L2026
C7022 C7023
L2049 C2124 C2122 C2074
C2075
L2009 L2008
C2108
PAM2000
U9016
C2073
C2076
F1008
ANT7000 C2033
L2002
C2071
U2005 C2063
C2067
C2066 L2025
L2015
L2020
C2065
C2077
C2101 L2031
C2017
C2015
C2016
C2003 C2018
C2102
L2035
C2091
L2029
TP2001
C2087 C2089
C2002 C2004 C2106
U2007
C2135
C2008 C2011
C2134
C2105
C3064
U2001
F3003 C2014 C2129
C1029 L2037
C2012
L3021
SC9003
C1028
L3023 L3022 C1012
C2042
C1011
C2107
C2040
R1005
C2005
C2010 C2009
C2064
C2013
C2028
C2024 C2027 C2025
C1000
C2022 C2030 C2023
C2031
C1007 L1009
L1019 C1018
L1013 L1005
L1083 R2000
C2029
SOC8004
L1008
C1014 L1011
C2026
C6107
L1014
C6083
C6084
C6087
C6085
C6088
L1004 C1038
L1006
C1105
L1064
C1102
L1062
RFS1001
R6021 C1001
L1030
R6019
C6102 L1007
C6073 R6029 C6076 U1008 L1082
L1061 C1106
U6003
C6108 C1013
F1001
U1002
C1104
C1099 L1025
U1007
U1003
C6081
TP6004
C6079 C6105
L8003
L1029
C6100
C6095 L1000
L1002 L1001
C1101 C1021
L1079 C1004
L1080 L1003
C1002C1003
L6018
C6101
C8023 C8021 C8022 C1025 C1036
C6096
SM-A525F/M L6016
C6090
C1010
C6093 C1031
R1000
C1015
C1005
L1024
C1024
C6098
L1028 COUP1001
LED6000
TP6005
C1020
C6094 R1006
U1000
C1030
C6099
L1026
R6028
C6106
C6072
C6071
Common
C1008
L6007
C6070
L6013
R1001
C5123
C6074
C1016 C1009
L1015 L1010
C9027 R6013 C6029 C6075 C6080
C6086
C6082
RFC1000
L1016
C1017
ANT8000
L6009
L6010
C6089
SC9004
C6022
L6008
C5056 C5057 C5059
C6038
L6012
C6024
C6026
L6005
C6056
COUP1000
R1007
L1031
C1041 C1026
C6057 C6030
C1085
C5073 C1033
L1018 C1076 C1079 L1032
L1023
C5070
C5069
C6054 C5058 C5043
L6004
L1012
C5075 C6031 C6027
C5165
L8005 C5105
C5166 C5015 C5048 C5010 C5011 C5039
C5051
F1004
C5106
C5008
R1003 C1022
R1004 R1002 C1027
C6062 C6013R6005
C6055 C6014
R6008 R6030
C5001 C5068
C1091
C5026 L1017
C8014 C5009
C5137
C5167
C1090
C5124
C5052
C5156
F1006
C5096 C1098
HDC4000
C1094
L1058
C5062 C5046
L1057
C5148 C5045 C5054
C5047 C5037
C5125 C5093
C6021
C1097 C1096
C1023
C5002 C5030 C5014
U6002
C6006
L6001
C5115
L1020
C6011
C5147 C5155
C5164
C4001
C4000
R4033
R4032
C5153
USB_P
L6002 C5028 C5107
C5004 C5144
C7018
C7025
C6015 L7007 C7026 L7006 C7017
C6053
C6039
C5034 C5082
C5151
C5152
TP6000
C7035
TP7016 TP7018 C5044
L7013
ZD6002
C5085
C5128
U7006
TP4000
C7027
C5055
C5038
C5040
C5129
C7002
L6003
TP7008
C6060 C7011
C6042 C6041
C6040
C6049
F9000
R6014
C6043
TP7006
C6052 C7032
C6051
C6045 R7002
L7005 C7033
C7009
R7000
R7015
C7016
C7008
C7054
C3037 C3038
R7007
C8028 C8029
C7010
R4005 C7001
R7008
TP9001 TP9000
SOC6000
U3004
U9010
U9009
U9014
U9011
L7004
U8002
C6069
U6001
R9002 C7021
C2127
C2126
R4004
R4008
TP7014
R9000
C7045
R4049
R4048
SOC9000
C6064
D6002
R6017
ANT3009
U7004
CON4000
L7017
L7016
C7041
TP7015
R6018
TP7017
R6016 C3057
R4050
TP_UB1 TP7019
R9004
R9008
C3056
C9020
C9021
R9003
R9001
C9019
C9018
R4023
U9013
U9012
R4021
C9012
ANT3008
ZD9001
TP_UB0 U7002 R3003
C7044 TP7011
ZD9000
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-3. Flow chart of Troubleshooting.
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-1. Power On
No Power
YES
NO Charge device with TA.
Check Battery voltage ≥ 3.8V? Swap battery if battery voltage is too
low (less than 3.0V)
YES
No
NO
When pressing the Power key, SWAP Power key FPCB
R6025 voltage is low?
NO
Check clock of OSC6000 Swap OSC6000
38.4MHz? ※ Test condition (Oscilloscope setting)
: 20.0us.div (time division)
YES
Check Power on
YES
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-2. Initial
Yes
Not OK
Check whether the charging is ok with TA.
Not OK
Check whether the device is flooded or SW
Check 8-4-1 Power on
routing.
Check whether VBAT connect to GND
OK
Swap UCP400
Not OK
Swap PBA
OK
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-3. No Service
No service
Yes
No
Yes
No
Check the Voltage No
C6044, C6045 : 0.8V
Replace the U6002
C6053 : 1.8V
C6059 : 2.7V
Yes
No
No
Check the clock OSC6000
Is the frequency 38.4MHz? Replace the OSC6000
Yes
No
Yes
No
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-4. SIM Part
YES
예
NO
SIM is OK? Swap SIM socket
YES
YES
NO
Check SIM RST / CLK / DATA.
(SIM1 : TP7001, TP7010, R7012) Check UCP400 (Crack etc)
Signal OK?
YES
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-5. T-Flash Part
Yes
No
No
Is SIM socket ok? Replace SIM socket
Yes
Check the T-flashNo
Voltage. Change to the new T Flash card.
(C7048) = 2.96V ? No If it doesn`t still work T Flash card after
changing
the T FLASH, Check the CN7000
Yes
(Crack etc)
No
Yes
No
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-6. Cable Charging Part (Normal/Fast)
YES
NO
VBUS_OVP(C6064)
= 5V or 9V ? Change TA or cable
YES
NO
VBUS_IF(C6069)=5V or 9V ?
Swap U6003
YES
NO
Check charging Swap U6000
YES
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-7. OTG
OTG NOT OK
YES
NO
VBUS_IF(C6005) Check U6000
= 5V ? (crack, open, damaged, etc.)
YES
NO
Check voltage Check U6001
VBUS_OVP(C6064) = 5V ? (crack, open, damaged, etc.)
YES
NO
Check OTG Change OTG Gender
YES
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-8-1. Magnetic Sensor
YES
Voltage Check. NO
Check U6003 (Crack etc.)
C7043 = 1.8V
YES
UCP400 Check 이상
YES
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-8-2. 6Axis Sensor
YES
Voltage check NO
Check U6003 (Crack etc.)
C7045 = 1.8V ?
YES
NO
I3C line check Replace U7004
(R4048, R4049)
YES
UCP400 Check 이상
Replace UCP400
(crack, open, etc.)
YES
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-8-3. RGB Light sensor
YES
Voltage Check NO
Check U6003 (Crack etc.)
R7009 = 1.8V ?
(Sensor’s IO 전압)
YES
NO
R4010, R4012 Check
Replace U7003
(I2C is OK?)
YES
비정상
UCP400 Check
Replace UCP400
(crack, damaged, etc.)
YES
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-8-4. Hall Sensor
YES
NO
Voltage Check NO
Check U6003 (Crack etc.)
C1021 = 1.8V ?
YES
NO
비정상
U1002 Check Replace U1002
상
(crack, damaged, etc.)
NO
YES
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-8-5. Fingerprint Sensor
YES
NO
Check the connectors of Connect the Main PBA SOC9000
Main PBA & Sub PBA
And Sub PBA SOC1002 again
YES
o NO
Check voltage
Swap U6003 in Main PBA
C1002 = 3.3V in Sub PBA
YES
o NO
Check SPI of fingerprint sensor
Swap UCP400 in Main PBA
4, 6, 8, 10pin of SOC1001 in Sub PBA
YES
o
Swap fingerprint
sensor module
YES
o
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-9-1. Microphone Part - Main MIC
YES
YES
YES
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-9-2. Microphone Part - Sub(2nd) MIC
YES
YES
YES
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-10. Speaker Part - Bottom speaker
YES
NO
Check SUB PBA C clip
Swap SUB PBA ANT1001, 1002
ANT1001,1002 are normal
YES
NO
Check the SPK Output Swap Sub PBA L1001, L1002
at SUB PBA Swap Main PBA AMP (U7001)
L1001,L1002
YES
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-11. Speaker Part - Top speaker
YES
YES
YES
YES
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-12. BT/WIFI
YES
NO
No
Check RF path NO
2.4G – L2014, L2016 Re-solder or change
5G – L3000, F3000, L3001, C3003, C3004, RF path components.
U3000, C3002
YES
YES
Check U3001 Any damage Re-solder or change
(Crack, open, etc.) U3001 component.
NO
No
YES
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-13. GPS
YES
NO
Check GPS function ON Enable GPS Function in the setting
YES
NO
Check the ANT contact 1. Resolder or Replace the ANT1002, ANT1003
ANT2002, ANT2003 2. Replace the front
YES
YES
NO
Check 76.8MHz Clock at output Replace the OSC6000
OSC6000 PIN NUM3
YES
NO
Check the Voltage Replace the U3006 or U6002
L3014 = 1.8V
YES
NO
Check the Voltage
L3018 = 1.2V Replace the U3008
YES
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-14. NFC
YES
YES
Check ANT contact Any damage. Re-solder or change
ANT3008, ANT3009 Antenna path components.
NO
Check NO
NFC_CLK_19.2M Re-solder or change
(TP3013) U6002 component.
Is it ok?
YES
Check RF path
R3003, C3057, C3056, C3052, R3001, YES
Re-solder or change
L3015, C3053, C3054, C3058, L3016, Damaged components
C3059, C3060, R3002
Any damage
(Crack, open, etc.)
NO
YES
Check U3007 Re-solder or change
Any damage. U3007 components.
NO
YES
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-15. FM Radio
YES
NO
Check the Earjack Change Earjack
YES
YES
NO
Check the Voltage
Resolder or Replace the U1003(SUB)
L1021(SUB) = 1.8V
YES
NO
Check the below point
-SUB PCB : C1032,C1033,C1034 (a) Resolder or Replace the SUB PCB
-Main PCB : C3033,C3035,L3011, (b) Resolder or Replace the U3004
C3034
YES
YES
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-16. Display
Yes
No
Check the connection of Reconnect SOC9000
SOC9000
Yes
Yes
Yes
Yes
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-17. Rear CAMERA (64M)
yes
no
Check cam connector on pba Reconnect SOC8002
yes
Check Voltage
C8006 : 1.1V
no
C8067 : 2.9V
Replace U8005
C8068 : 1.8V
C8011: 1.8V
C8008 : 2.8V
yes
yes
yes
end
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-18. Front Cam (32M)
yes
no
Check cam connector on pba reconnect SOC8000
yes
Check voltage
no
C8003 : 1.05V Change U8005
C8002 : 1.8V
C8001 : 2.9V
yes
no
Check VTCAM_MCLK pulse
Change main pba
26Mhz (R8001)
yes
yes
end
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-19. TSP
Yes
No
Check the connection of Reconnect SOC9000
SOC9000
Yes
Yes
Yes
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-20. Motor
YES
NO
ANT6000, ANT6001 Check After reconnect, Check
YES
NO Replace
Voltage Check
C6025 = 3.3V ? U6007
YES
NO
MOT_EN Check
Replace UCP400
R6001 = 1.8V ?
YES
Replace motor
YES
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-21. GSM850/900, WCDMA B5/8, LTE B5/8/12/17/20/26/28 TRX
YES
YES
YES
NO Resolder or change
Check U1000 or U2001 path any damage
U1000 or U2001 TRX path
(Crack, open, etc), is it ok?
components
YES
YES
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-22. GSM DCS/PCS, WCDMA B1/2/4, LTE B1/2/3/4/7/32/38/40/41/66 TRX
YES
YES
YES
YES
YES
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-23-1. GSM850/900, WCDMA B5/8, LTE B5/8/12/17/20/26/28 DRX [SM-A525F]
YES
YES
YES
NO Resolder or change
Check U2008 or U2001 path any damage
U2008 or U2001 DRX path
(Crack, open, etc), is it ok?
components
YES
YES
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-23-2. GSM850/900, WCDMA B5/8, LTE B5/8/12/13/17/20/26/28 DRX [SM-A525M]
YES
YES
YES
NO Resolder or change
Check U2008 or U2001 path any damage
U2008 or U2001 DRX path
(Crack, open, etc), is it ok?
components
YES
YES
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-24-1. GSM DCS/PCS, WCDMA B1/2/4, LTE B1/2/3/4/7/32/38/40/41/66 DRX [SM-A525F]
YES
YES
YES
NO Resolder or change
Check U2009 or U2001 path any damage
U2009 or U2001 DRX path
(Crack, open, etc), is it ok?
components
YES
YES
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
ANIBAL GARCIA VENEZUELA
8. Level 3 Repair
https://irepairvenezuela.com/
@irepair.ve
8-4-24-2. GSM DCS/PCS, WCDMA B1/2/4, LTE B1/2/3/4/7/38/40/41/66 DRX [SM-A525M]
YES
YES
YES
NO Resolder or change
Check U2009 or U2001 path any damage
U2009 or U2001 DRX path
(Crack, open, etc), is it ok?
components
YES
YES
END
Confidential and proprietary-the contents in this service guide subject to change without prior notice
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.