You are on page 1of 45

SERVICE MANUAL

V59-C

M/S. VIDEOCON INDUSTRIES LIMITED,


This Service manual is property 14Km Stone, Paithan Road, Aurangabad,
Village Chitegaon, Taluka Paithan,
of Videocon Industries Ltd.
AURANGABAD – 431105, MAHASHTRA, INDIA

1
V59-C SERVICE MANUAL
SPECS REV DATE DESCRIPTION PREPARED BY
VER 1.0 REV 1.0 20.1.2015 V59-C SERVICE MANUAL VK

2
Index
1. Safety Precautions
2. Servicing Precautions
3. Chassis Block Diagram
A) Chassis block diagram
B) Actual Chassis view
C) Chassis Specification
4. Connectors and Electrical Parameters
A) Connector Details
B) Critical component list
5. Panel Information
A) Panel Specification
6. Software Installation Procedure
A) SW loading through USB
B) SW Loading through Jig
7. Circuit Diagram
8. Trouble Shooting

3
4
2. Servicing Precautions

2.1 General Servicing Precautions:


1. Always unplug the receiver AC power cord from the AC power
Source before:
a. Removing or reinstalling any component, circuit board module or any other receiver
assembly.
b. Disconnecting or reconnecting any receiver electrical plug or other electrical connection.
c. Connecting a test substitute in parallel with an electrolytic capacitor in the receiver.
CAUTION: A wrong part substitution or incorrect polarity installation of electrolytic
capacitors may result in an explosion hazard

2. Test high voltage only by measuring it with an appropriate high voltage meter or other
voltage measuring device (DVM, FETVOM, etc) equipped with a suitable high voltage probe.
Do not test high voltage by "drawing an arc".
3. Do not spray chemicals on or near this receiver or any of its assemblies.
4. Unless specified otherwise in this service manual, clean electrical contacts only by
applying the following mixture to the contacts with a pipe cleaner, cotton-tipped stick or
comparable non-abrasive applicator; 10% (by volume) Acetone and 90% (by volume)
isopropyl alcohol (90%-99% strength)
CAUTION: This is a flammable mixture. Unless specified otherwise in this service manual,
lubrication of contacts in not required.
5. Do not defeat any plug/socket voltage interlocks with which receivers covered by this
service manual might be equipped.
6. Do not apply AC power to this instrument and/or any of its electrical assemblies unless all
solid-state device heat sinks are correctly installed.
7. Always connect the test receiver ground lead to the receiver chassis ground before
connecting the test receiver positive lead. Always remove the test receiver ground lead last.

8. Use with this receiver only the test fixtures specified in this service manual. CAUTION: Do
not connect the test fixture ground strap to any heat sink in this receiver.

2.2 Electrostatic Sensitive (ES) Devices:


Some semiconductor (solid-state) devices can be damaged easily by static electricity.
Such components commonly are called Electrostatic Sensitive (ES) Devices. Examples of
typical ES devices are integrated circuits and some field-effect transistors and
semiconductor "chip" components. The following techniques should be used to help
reduce the incidence of component damage caused by static by static electricity.
1. Immediately before handling any semiconductor component or semiconductor-equipped
assembly, drain off any electrostatic charge on your body by touching a known earth
ground. Alternatively, obtain and wear a commercially available discharging wrist strap
device, which should be removed to prevent potential shock reasons prior to applying
power to the unit under test.
2. After removing an electrical assembly equipped with ES devices, place the assembly on a

5
conductive surface such as aluminum foil, to prevent electrostatic charge build up or
exposure of the assembly.
3. Use only a grounded-tip soldering iron to solder or unsolder ES devices.
4. Use only an anti-static type solder removal device. Some solder removal devices not
classified as "anti-static" can generate electrical charges sufficient to damage ES devices.
5. Do not use Freon-propelled chemicals. These can generate electrical charges sufficient to
damage ES devices.
6. Do not remove a replacement ES device from its protective package until immediately
before you are ready to install it. (Most replacement ES devices are packaged with leads
electrically shorted together by conductive foam, aluminum foil or comparable conductive
material).

7. Immediately before removing the protective material from the leads of a replacement ES
device, touch the protective material to the chassis or circuit assembly into which the device
will be installed.
CAUTION: Be sure no power is applied to the chassis or circuit, and observe all other safety
precautions.
8. Minimize bodily motions when handling unpackaged replacement ES devices. (Otherwise
harmless motion such as the brushing together of your clothes fabric or the lifting of your
foot from a carpeted floor can generate static electricity sufficient to damage an ES device.)

2.3 General Soldering Guidelines


1. Use a grounded-tip, low-wattage soldering iron and appropriate tip size and shape that
will maintain tip temperature within the range or 500°F to 600°F.

2. Use an appropriate gauge of RMA resin-core solder composed of 60 parts tin/40 parts
lead.

3. Keep the soldering iron tip clean and well tinned. 4. Thoroughly clean the surfaces to be
soldered. Use a mall wire-

4. bristle (0.5 inch, or 1.25cm) brush with a metal handle. Do not use Freon-propelled spray-
on cleaners.

5. Use the following unsoldering technique a. Allow the soldering iron tip to reach normal
temperature (500°F to 600°F) b. Heat the component lead until the solder melts. c. Quickly
draw the melted solder with an anti-static, suction-
type solder removal device or with solder braid.

CAUTION: Work quickly to avoid overheating the circuit board printed foil.

6. Use the following soldering technique.


a. Allow the soldering iron tip to reach a normal temperature (500°F to 600°F).

6
b. First, hold the soldering iron tip and solder the strand against the component lead until
the solder melts.

c. Quickly move the soldering iron tip to the junction of the


Component lead and the printed circuit foil, and hold it there only until the solder flows
onto and around both the component lead and the foil. CAUTION: Work quickly to avoid
overheating the circuit board printed foil.

d. Closely inspect the solder area and remove any excess or splashed solder with a small
wire-bristle brush.

2.4 IC Remove/Replacement: - Some chassis circuit boards have slotted holes (oblong)
through which the IC leads are inserted and then bent flat against the circuit foil. When
holes are the slotted type, the following technique should be used to remove and replace
the IC. When working with boards using the familiar round hole, use the standard technique
as outlined in paragraphs 5 and 6 above.
2.4.1 IC Removal:
1. Desolder and straighten each IC lead in one operation by gently prying up on the lead
with the soldering iron tip as the solder melts.

2. Draw away the melted solder with an anti-static suction type solder removal device (or
with solder braid) before removing the IC.

2.4.2 Replacement:
1. Carefully insert the replacement IC in the circuit board.

2. Carefully bend each IC lead against the circuit foil pad and solder it.

3. Clean the soldered areas with a small wire-bristle brush.(It is not necessary to re apply
acrylic coating to the areas).

2.5 "Small-Signal" Discrete Transistor Removal/ Replacement: -


1. Remove the defective transistor by clipping its leads as close as possible to the
component body.
2. Bend into a "U” shape the end of each of three leads remaining on the circuit board.
3. Bend into a "U" shape the replacement transistor leads.
4. Connect the replacement transistor leads to

the corresponding leads extending from the circuit board and crimp the "U" with long nose
pliers to insure metal to metal contact then solder each connection
.
2.6 Power Output, Transistor Device Removal/ Replacement: -
1. Heat and remove all solder from around the transistor leads.
2. Remove the heat sink mounting screw (if so equipped).
3. Carefully remove the transistor from the heat sink of the circuit board.
4. Insert new transistor in the circuit board.
5. Solder each transistor lead, and clip off excess lead. 6. Replace heat sink.

7
2.7 Diode Removal/ Replacement: -
1. Remove defective diode by clipping its leads as close as possible to diode body.
2. Bend the two remaining leads perpendicular y to the circuit board.
3. Observing diode polarity, wrap each lead of the new diode around the corresponding lead
on the circuit board.
4. Securely crimp each connection and solder it.
5. Inspect (on the circuit board copper side) the solder joints of the two "original" leads. If
they are not shiny, reheat them and if necessary, apply additional solder.

2.8 Fuse and Conventional Resistor Removal/ Replacement:


1. Clip each fuse or resistor lead at top of the circuit board hollows take.
2. Securely crimp the leads of replacement component around notch at stake top.

3. Solder the connections.


CAUTION: Maintain original spacing between the replaced component and adjacent
components and the circuit board to prevent excessive component temperatures.

2.9 Circuit Board Foil Repair


Excessive heat applied to the copper foil of any printed circuit board will weaken the
adhesive that bonds the foil to the circuit board causing the foil to separate from or "lift-off"
the board. The following guidelines and procedures should be followed whenever this
condition is encountered. At IC Connections to repair a
defective copper pattern at IC connections use the following procedure to install a jumper
wire on the copper pattern side of the circuit board. (Use this technique only on IC
connections).
1. Carefully remove the damaged copper pattern with a sharp knife. (Remove only as much
copper as absolutely necessary).
2. Carefully scratch away the solder resist and acrylic coating (if used) from the end of the
remaining copper pattern.
3. Bend a small "U" in one end of a small gauge jumper wire and carefully crimp it around
the IC pin. Solder the IC connection.
4. Route the jumper wire along the path of the out-away copper pattern and let it overlap
the previously scraped end of the good copper pattern. Solder the overlapped area and clip
off any excess jumper wire.

At Other Connections Use the following technique to repair the defective copper pattern at
connections other than IC Pins. This technique involves the installation of a jumper wire on
the component side of the circuit board.
1. Remove the defective copper pattern with a sharp knife. Remove at least 1/4 inch of
copper, to ensure that a hazardous condition will not exist if the jumper wire opens.
2. Trace along the copper pattern from both sides of the pattern break and locate the
nearest component that is directly connected to the affected copper pattern.
3. Connect insulated 20-gauge jumper wire from the lead of the nearest component on one
side of the pattern break to the lead of the nearest component on the other side. Carefully
crimp and solder the connections. CAUTION: Be sure the insulated jumper wire is dressed so
the it does not touch components or sharp edges.

8
3) Chassis block diagram:-

9
b) Actual Chassis view V59C:-

10
c) Chassis Specification:-
PARAMETERS SPECS
NUMBER OF PROGRAMS 200
TUNING SYSTEM FS
COLOUR SYSTEM PAL/ SECAM/AUTO
NTSC PLAYBACK YES
SOUND SYSTEM I/BG/DK
TURBO TUNING NO
PLUG & PLAY NO
TUNNING

CHANNEL NAME (PROGRAM NAME) YES


MANUAL SEARCH YES
UPDATE SEARCH NO
FINE TUNE YES
SKIP YES
EXCHANGE CHANNEL (SWAP) NO
INSERT CHANNEL NO
COPY CHANNEL YES
DELETE CHANNEL YES
AUTO DETECTION COLOR AND SOUND YES
SELECTABLE PICTURE MODES USER/CINEMA/SPORTS/VIVID/HI-BRIGHT
WHITE PEAK LIMITER YES (Inbuilt)
BLACK STRETCH YES (Inbuilt)
BLUE STRETCH YES (Inbuilt)
DYN. SKIN TONE (FLESH TONE) YES
ZOOM MODE Normal/16:9/4:3/Full (Direct Key ON REMOTE)
FAVOURITE COLOUR CONTROL NO
PICTURE IMPROVEMENT YES(Inbuilt)
DCDI YES (Inbuilt)
MADI MODE YES
CCS MODE Yes
PICTURE

ADAPTIVE LUMA CONTROL NO


ACTIVE COLOUR MANAGEMENT Yes(Active color 3D)
ADAPTIVE CONTRAST AND COLOUR No
AUTOMATIC IMAGE OPTIMIZATION YES
FLESH TONE ADJUST YES
GREEN TONE ADJUST NO
BLUE TONE ADJUST NO
DE-INTERLACING YES
3:2 2:2 PULL DOWN YES
DIGITAL COMB FILTER YES (3D)
AVERAGE PICTURE LEVEL (APL) No
3D NOISE REDUCTION YES(INBUILT)
DNR YES

11
PIP NO
POP NO
CINEMA MODE YES (Inbuilt)
CTI (Colour Transient Improvement) YES (Inbuilt)
FREEZE No
DYNAMIC SHARPNESS No
DYNAMIC CONTRAST (DCI) YES (Inbuilt)
BACKLIGHT ADJUST YES
COLOUR TEMP YES
AUTO ADJUST (IN PC) YES
H POSITION (IN PC) YES
V POSITION (IN PC) YES
PHASE (In PC) YES
CLOCK (In PC) YES
SELECTABLE SOUND MODES USER/SPEECH/MUSIC/SOEN
AUTO VOLUME LEVELLER YES
AUDIO OUTPUT POWER (RMS) 2x10W (+/-2W)
MUSIC MODE YES (Eco Vision =Audio Only)
REVERB NO
STEREO PLAYBACK Yes
BASS / TREBLE / BALANCE YES
EQUALIZER 5 BAND
INCREDIBLE STEREO NO
SOUND BOOSTER NO
LOUDNESS NO
AUDIO

SURROUND NO
VOLUME PP NO
NO.OF SPEAKERS 2
FRONT SPEAKER NO
TWEETER NO
WOOFER NO
VOICE NO
DYNAMIC BASS NO
OMNI SURROUND NO
EXTERNAL SPEAKER NO
V CHIP NO
SRS (SRS TSXT sound) NO
AV OUT VOLUME NO
CLOCK NO
ON CHANNEL NO
OFF TIME NO
TIMER

ON TIME NO
REMINDER TIMER NO
REMIND CHANNEL NO
SLEEP TIMER YES

12
CLOCK DISPLAY NO
AUTO SWITCH OFF(NO SIGNAL) YES
FM NO(OPTIONAL TRANSMITTER)

DTH NO
H/W FEAATURES

PANEL COMPABILITY YES


PANEL BRIGHTNESS YES

MESSAGE NO

TELEPHONE DIARY NO

PROGRAM DIRECTORY YES


CHANNEL ON DEMAND (COD) NO
(OFF/ POWER SAVING LOW/ POWER SAVING MID
ECO VISION
/POWER SAVING HIGH/AUDIO ONLY)
SCREEN SAVER No
CURTAIN EFFECT NO
SCAN NO
SORT NO
QUICK VIEW YES
FAVOURITE YES
ALARM NO
HOTEL MODE YES
VOLUME LOCK YES
CHILD LOCK YES (In User Lock)
TUNING LOCK YES
MAX VOLUME LOCK YES
HELP NO
FEATURES

SELF DEMO NO
OSD TRASPARENCY NO
OSD LANGUAGES(ATV) English
SKY-REMOTER NO
RF-REMOTE NO
Full HD panel support YES
CALENDAR NO
SOURCE LOCK (VIDEO LOCK) YES(In User Lock)
FRONT PANEL KEY LOCK YES
GAME NO
BLUE SCREEN No
CORDLESS HEADPHONE NO
OSD HPOS NO
OSD VPOS NO
OSD TIMER NO
GAME PORT NO
VGA UPDATE S/W(service) YES

13
Start on predefined Source YES
Start on predefined Channel NO. YES
CE,ROHS&EUP Directivies NO
RS232 SUPPORT NO
ENERGY METER No
SCENE SELECT No
BOOT UP SOUND YES
CAPTURE LOGO/BOOT LOGO NO
FAMILY FAVOURITE YES
SPECIAL FEATURES

TOUCH CONTROL KEY NO


RF REMOTE NO
BEE STAR RATING NO
DEMO SHOP(Eops) YES
BODY MASS INDEX(BMI) NO
EFFECTS NO
HEALTH CARE VIEW NO
WORLD CLOCK NO
VIDEO AND AUDIO DIAGNOSIS NO
MFM NO
RF 1
AV IN (FRONT/SIDE) 2
S-VIDEO IN No
DVD COMPATIBILITY (YPbPr/YCbCr) 1
HDMI INPUT 4
IDTV INPUT NO
PC(VGA IN) 1
CONNECTIVITY

PC AUDIO IN 1
EURO SCART IN NO
USB INPUT (2.0 SUPPORT) 2
BLUETOOTH NO
DVI INPUT NO
AV OUT 1(CVBS OUT)
EARPHONE SOCKET NO
CORDLESS HEADPHONE NO
OPTICAL OUT NO
SMART CARD SLOT NO
DIGITAL RF INPUT NO
USB 2.0 SUPPORT YES
STILL PICTURE SUPPORT YES
USB SUPPORT

REPEAT/GUIDE/ANGLE/INFO YES
SUBTITLE YES
MP3,MP4,AVI SUPPORT YES
WMA YES
RMVB YES
Program FUNCTION NO

14
REPEAT FUNCTION YES
SLOW NO
STEP NO
H.264 SUPPORT YES
RM,RMVB SUPPORT SUPPORTS UP TO SD
USB Update SW YES

4. Connectors and Electrical Parameters.


a) Connector Details:-

Power Connector CN26


No Pin Connection Voltages (Stand by) Voltages (ON Condition)
1 12V 12V 12V
2 12V 12V 12V
3 GND 0V 0V
4 12V 12V 12V
5 GND 0V 0V
6 GND 0V 0V
7 5V 5.03V 5.03V
8 5V 5.03V 5.03V
9 5V_STB 5.08V 5.08V
10 GND 0V 0V
11 SW 3.6V 3.6V
12 GND 0V 0V
13 Back Light ON/OFF 0V 5V
14 Dimming Control 3.6V 3.6V

IR & Key Board Connector CNB9


NO. Symbol Function Voltages (Stand by) Voltages (ON condition)
1 GND GND 0 0
2 KEY_2 KEY VOLTAGE 3.2V 3.27V
3 GND GND 0 0
4 KEY_1 KEY VOLTAGE 2.57V 2.57V
5 LED_R LED VOLTAGE 0.024V 4.96V
6 5V_SB 5VSB SUPPLY 3.3V 3.3V
7 LED_G LED_G 2.8V 0.024V
8 IR IR Signal 3.2V 3.2V

15
Key Voltage Matrix
KEY VOLTAGE AD1 VOLTAGE AD2
VOL+ 0.01
VOL- 1.02
CH+ 0.432
CH- 1.9V
MENU 1.03V
TV/AV 0.433V
STANDBY 0.01V

AUDIO OUTPUT CONN. CN14


NO. Symbol Function
1 L_OUT+ L_OUT+
2 GND GND
3 GND GND
4 R_OUT+ R_OUT+

LVDS PORT CNF1


No Pin Connection Voltages (Stand by) Voltages (ON Condition)
1 VCC 0V 12V (As per panel)
2 VCC 0V 12V (As per panel)
3 VCC 0V 12V (As per panel)
4 VCC 0V 12V (As per panel)
5 GND 0V 0V
6 GND 0V 0V
7 LVTX_A_CH0P 1.1V 1.1V
8 LVTX_A_CH0N 1.1V 1.1V
9 LVTX_A_CH1P 1.1V 1.1V
10 LVTX_A_CH1N 1.1V 1.1V
11 LVTX_A_CH2P 1.1V 1.1V
12 LVTX_A_CH2N 1.1V 1.1V
13 GND 0V 0V
14 GND 0V 0V
15 LVTX_A_CLKP 1.1V 1.1V
16 LVTX_A_CLKN 1.1V 1.1V
17 LVTX_A_CH3P 1.1V 1.1V
18 LVTX_A_CH3N 1.1V 1.1V
19 LVTX_A_CH4P 1.1V 1.1V
20 LVTX_A_CH4N 1.1V 1.1V
21 LVTX_B_CH0P 1.1V 1.1V

16
22 LVTX_B_CH0N 1.1V 1.1V
23 LVTX_B_CH1P 1.1V 1.1V
24 LVTX_B_CH1N 1.1V 1.1V
25 GND 0V 0V
26 GND 0V 0V
27 LVTX_B_CH2P 1.1V 1.1V
28 LVTX_B_CH2N 1.1V 1.1V
29 LVTX_B_CLKP 1.1V 1.1V
30 LVTX_B_CLKN 1.1V 1.1V
31 GND 0V 0V
32 GND 0V 0V
33 LVTX_B_CH3P 1.1V 1.1V
34 LVTX_B_CH3N 1.1V 1.1V
35 LVTX_B_CH4P 1.1V 1.1V
36 LVTX_B_CH4N 1.1V 1.1V
37 3D_EN/AL 0V 0V
38 LVDS_SEL (Rotate) 3.3V (As per panel) 3.3V (As per panel)
39 NC NC NC
40 NC NC NC

a) Critical component list:-


COMPONENT DESCRIPTION LOCATION
1100043109 CAP,CER,Y5U,400VAC,1KPF,M,10MM
1100043114 DIODE,CHIP,SOT23,LBAV70LT1G,TP
1100043194 IC,OPTO-COUPLER,KP10101B/KPC817B,DIP-4
1100043197 VARISTOR,560V,25AMP,TVR10681KSY
1100043202 THERMISTER,NTC,SCK,6A,2.5E,M,7.5MM,L-5M
1100057520 C,CER,Y5P,1KV,2.2KPF,K,P5MM
1100093176 CAP,CER,275VAC,330KPF,K,15MM
1100098978 C,CER,Y5P,1KV,100PF,K,P5MM
1100105840 IC,CHIP,MQFN76,SiI9687ACNUC,HDMI SW
1100105843 IC,CHIP,SOP8,MX25L3206D/E M2I-12G,NEW
1100106737 C,ELCT,500V,100MFD,M,20X36,P10MM,105°CKM
1100106760 IC,CHIP,EPLQFP,128Pin,TSUMV59XUS-Z1
1100107706 IC,PWM,OB2273A,SOT23-6
1100111347 C,ELCT,250V,33MFD,M,13X20,P5MM,TP,105°C
1100111348 CAP,CBB21,450V,100KPF,K,10MM
1100111349 CAP,CBB21,450V,470KPF,K,15MM
1100111353 PFC INDUCTANCE,GL-2634WH-ER26
1100111354 DIODE,CHIP,DO-201AD,1N5408
1100111356 IC,SOP8,OB6561PCPA-PFC
1100111358 IC,CHIP,SOP8,TP358
1100111361 TRANS,N-MOS,650V/11A MMF60R360P,TO-220MF
1100111362 TRANS,N-MOSFET,650V/4A 4N65L,TO263
1100111363 TRANS,N-MOSFET,800V/8A 8N80-TF1,TO-220MF

17
5. Panel information.
SCREEN SIZE 40" FHD 40" HD
LED / LED 98cm TFT LCD /LED 98cm TFT LCD /LED
Display Resolution 1920 x 1080 1366 X768
Viewing Angel 178(H), 178(V) Deg.
Lamp life time 50,000 Hours Minimum
PAL BG/I/DK
Receiving System Anlog NTSC (3.58 / 4.43) In
playback only
VHF-2-12
Channel Coverage UHF21-69
CATV(X-Z+2,S1-S41)
Power supply AC 110-240V, 50/60Hz
Antenna Input
Impedance 75 Ohms Unbalanced
Power Consumption
(TYP) 90W (115W MAX)
Audio Output (RMS) 10Watt x 2
Remote Handset, User Guide Book
Accessories Power Cord (Optional)
Battery UM-3, "AA" 1.5V (2no.)

18
6. SW INSTALLATION PROCEDURE
The ATV SW installation in B-Type V59 chassis can be done with USB in three
ways.
1.) SW Installation through USB in Set stand by condition.
2.) SW Installation through USB in Set ON condition.
3.) SW Installation through MST Tool.
A.) SW INSTALLATION THROUGH USB IN STAND BY CONDITION: -

Copy the SW (.bin) file in USB to root


1
directory.

Rename the SW file name as


2

3 Keep the TV set in Power OFF condition.


4 Plug in the USB drive in USB port of the TV.

5 Turn ON the Mains power of TV set.

Now after a few sec., RED LED indicator of


6 TV will start blinking, indicating the SW is
loading.

After a few sec. LED blinking will stop and


7 SW loading is finished. Then follow below
steps.

20
After SW update, go to Design Menu by
8
Pressing MENU => AUDIO MENU => 8 5 3 2

Go to Setup design menu and Select Clear


9
EEPROM option and press OK key of remote.

After Clear EEPROM, the set will go to stand


10 by and will again restart automatically in RF
source.

Then verify the modelwise Audio/ Video


settings as per Design data (in PLM). Verify
11
the SW date and version in Version info in
Design data

Then press Shipping in Setup design menu by


pressing OK key of remote, after shipping set
then
12
Switch OFF the set from main power and
again Switch ON. The SW loading process Is
complete.

21
B.) SW INSTALLATION THROUGH USB IN ON CONDITION: -

1 Copy the SW (.bin) file in USB to root directory.


Rename the SW
2
brand TV.
Turn the TV set ON and insert the USB in USB port
3
of TV set.

Press Menu key of remote, go to setting menu and


4
press OK on Software Update Menu.

It will give pop up window asking upgrade SW or


not? Press left arrow key here. The SW update will
5
start and LED will start blinking, indicating SW
upgrade is in process.

Also, indicator screen will appear o screen


showing SW loading progress.
6
Once SW update is started, do not switch OFF the
TV set.

After SW update is complete, the TV set will


7
automatically go to stand by mode and will restart.
Turn ON the TV set from stand by and follow
8
below steps.

22
STEPS TO FOLLOW AFTER SW INSTALLATION: -

After SW update, go to Design Menu by


9
Pressing MENU => AUDIO MENU => 8 5 3 2

Go to Setup design menu and Select Clear


10
EEPROM option and press OK key of remote.

After Clear EEPROM, the set will go to stand


11 by and will again restart automatically in RF
source.

Then verify the modelwise Audio/ Video


settings as per Design data (in PLM). Verify
12
the SW date and version in Version info in
Design data

Then press Shipping in Setup design menu by


pressing OK key of remote, after shipping set
then
13
Switch OFF the set from main power and
again Switch ON. The SW loading process Is
complete.

23
Note: -
1. Kindly DO NOT SWITCH OFF THE TV SET, While SW upgrade is in
process.
2. In M-Mode, if press stand by key of remote, then M-Mode
becomes OFF.
3. Can not update SW through USB if set is permanently in Stand
by. In this case, use MST jig to load SW.
4. If required to load Videocon SW in SANSUI brand chassis with

5. If required to load SANSUI SW in Videocon brand chassis with

24
SW INSTALLATION THROUGH JIG: -
Step1: - First Connect MST SW loading Jig to USB port of PC and 04 Pin Header
XS201 on chassis (near AV socket). SW loading jig is common with MST719 Jig.
MST Tool is also same as MST719.

Step2: - Kindly confirm pin configuration of Jig conn. should be


+5V/3.3V, RXD, TXD, GND, which is same as MST719 Jig. Connect the
Jig to chassis, then Red LED indicator on Jig will glow if it is connected
properly.

Step3: - on your PC . (Tool version may be


different).

25
Step4: - After opening tool, Press connect. If Jig is properly connected, then it
will select the chip automatically. If chip is not selected automatically, then go to
Device option in Jig and select the Chip from SPI list WIN25X32 or WIN25Q32
(the device may differ than mentioned here).
Then open the MSTV tool and select Baud rate 11500 (as shown below) and
select the COM Port (confirm COM port from your Computer properties, may
be different for different PC).

COM Port and Baud Rate selection from MSTV Tool

26
Step5: - Then go to option of ISP tool and select the SW file (.bin file).

Step6: - Then select option of ISP tool and after setting, press RUN in

Auto window, then SW loading will start as shown below.

Note: - 1.) Before running SW, uncheck options Reconnect, lank, Restore data,
Multi flashes, Verify, as these actions are not required.
2.) Kindly DO NOT SWITCH OFF TV Set or PC while SW loading or do not
disconnect the Jig from PC while SW loading.

27
Step7: - After Successful SW loading it will show PASS, as shown in below
window.

Step8: - After Successful SW loading follow below steps for Shipping.

28
After SW loading is complete i.e. 100%,
1 the set will go to stand by automatically
and will restart again.

The set is in M-Node now. Then go to


2 Design Menu by Pressing MENU =>
AUDIO MENU => 8 5 3 2

Go to Setup design menu and Select Clear


3 EEPROM option and press OK key of
remote.

After Clear EEPROM, the set will go to


4 stand by and will again restart
automatically in RF source.

Then verify the modelwise Audio/ Video


settings as per Design data. Verify the SW
5 date and version in Version info menu of
Design data

Then press Shipping in Setup design menu


by pressing OK key of remote, then Switch
6 OFF and again Switch ON the SET. The SW
loading process Is complete.

29
3_3V_TUN

R1
10K
R3 R4
AGC 100 0 TV_AGC
C3
27p

IF1 VIFP
C10
TUNER AGC C11
CLOSE TO CHIP
0.1uF 22nF
R2 220
C13
0.1uF CLOSE TO TUNER

IF2 VIFM
R5 220 0.1uF
C14
C2 3_3V_TUN 3_3V_TUN
27p CLOSE TO CHIP

CLOSE TO TUNER AGC

33
32
31
30
29
28
27
26
25
GND
N1 3_3V_TUN

GPO1
VCCRF
GPO2
GNDIF
VCCIF
TESTI3
AGCD
AGCA
C22 C21 C20 0.1uF
M1 120pF 50V 120pF 50V 1 24 IF1
1 RFG IFOAN
FRIN N16613861 2 RFIN IFOAP 23
2 3 RFG IFODN 22 IF2
GND1 4 21
3 TESTO1 IFODP
GND2

150p
4 5 20 C19 0.1uF
GND3 XTSEL CAPVCO

C23
5 6 TESTO2 VCCPL 19
GND4 D1
7 18
BAV99 GNDDIG GNDPL

330nH 140mA 5%
8 AS XTOUT 17

C27

0.1uF
220nH 120mA 5%
L1

TESTI1

TESTI2
XTALP
XTALN
TUNER_TANG

SCL
SDA
L3

VT
CP
TDA18275HN/N1

9
10
11
12
13
14
15
16
Each of these Vcc pins of TDA18275 is decoupled by a
single capacitor (pin 19, 28, 31)
R8 100

C15
I2C-SCL

C16
220
R6
I2C-SDA R7 100
3_3V_TUN

6.8nF

10%
C17

6.8nF
C24 C25 C8 C9

150nF

0.1uF

0.1uF

0.1uF
100pF100pF 27pF N16614253 27pF N16614261
X1 16M

C4

C6
C5
3.3VSTB L2 3_3V_TUN
120oHm@100MHz

C1 C26 C7

10uF 10V NC 0.1uF

DESCRIPTION V59-CTYPE CHK/DATE

GAOHL 20140906 Rev: V1.0 Simon/Gao

VIDEOCON APPD/DATE

Experience change
4
AV1 R130 100
AV1

6
R132

R131
10K

10K
R1

L1
IR KEY LED
D102 ICVL0518

D101 ICVL0518

D103 ICVL0518

10K
3

10K
5VSTB

75
3.3VSTB
XS101
AV3_WRY

4.7k
4.7K

4.7K
R135

R133

R134

R126 2.2K

10K
CON08-2.0

R121
R120
R127

R123
1

2 KEYB R119 100


AD1
3
4 KEYA R122 100
AD0-KEYA

AV2/OUT R143 NC 0
OUT-V
5

6
LED_R

Q103
LMBT3904
R128 10K
LED-R
7 LED_G
R125 1K
R 4
R102 100
VIN 5 AV2 8 R124 100

0.1uF

0.1uF
6 6 IR_IN

ICVL0518

ICVL0518
3 C103

ICVL0518
L

0.1uF
AR-OUT XS105
1 1
2

27p
GND NC 2.2uF 0402 6.3V R104 10K
R2

C106

C101
D105

C107
D106
C102

D104
C108
AL-OUT

NC 2.2uF 0402 6.3V R103 10K


L2
D108 ICVL0518

D107 ICVL0518

D109 ICVL0518

10K

10K
75
R101

R105

R106

AVOUT(option) 4 YIN
R111 100
Y
Y
5VSTB
1

R110 100
0.1uF

5VSTB
5 BIN PB
PB
R115 220

R113 100k

2
C104
E

R112 100
B
N20902322 6 RIN
Q102 PR
C

LMBT3906
D111 ICVL0518

D110 ICVL0518

D112 ICVL0518

3
C

75

75

B
75

N20902233 CVBS_OUT
Q101 XS104
G_AV1_001G40 LMBT3904 C105 10uF 10V
YPbPr
E

OUT-V
R107

R108
R109

V 2 N20902318 N20902320
GND 1 R118 75 R117 75
R114 100k
D113 ICVL0518

R116 75

DESCRIPTION V59-CTYPE CHK/DATE

YPbPr GAOHL 20140906 Rev: V1.0 Simon/Gao

VIDEOCON APPD/DATE

Experience change
15 5
VGA UART-TX 4
14
10
4
9 UART-RX 3
VGA AUDIO
RGB0-PB+
13 3 VGA-BIN
R205 33

8 RGB0-Y+ 2
12 2 VGA-GIN
R206 33

7 5VSTB 1
R207 33 RGB0-PR+
11 1 VGA-RIN
6 XS201

D206 ICVL0518

D205 ICVL0518

D207 ICVL0518
R210 5VSTB
R208 R209
CON04-2.0

16

17

R216 4.7K
XS202

R215 4.7K
VGA
PC-INL
75 75
75
2 R217 10K
4
R213 5 PC-INR
100 VGA-HS
3 R218 10K
R214 VGA-VS
100 1
VGAHS XS203

D209 ICVL0518

D208 ICVL0518

R220 10K

R219 10K
UART-TX
VGAVS
PHONE JACK PJ-314A
UART-RX

10K 10K

ICVL0518 D204

ICVL0518 D203
D202 ICVL0518

D201 ICVL0518
R211 R212

USB

5VSTB

L202 0
1
+5V
USB1-D-
R201 5.1
USB

2 USB2-DN
USB1-
USB2
3 USB2-DP
R202 5.1 USB1-D+
USB1+

4
GND

5
+5V
USB0-D-
R203 5.1
USB

6 USB1-DN
USB2-
USB1
R204 5.1 USB0-D+
ULCE0505

ULCE0505
ULCE0505

ULCE0505

7 USB1-DP
USB2+
DESCRIPTION V59-CTYPE CHK/DATE
0.1uF

100uF

8
GND
Rev: V1.0 Simon/Gao
C203

GAOHL 20140906
D213

D211
D212

D210

C204

XS204
G_USB_2

VIDEOCON APPD/DATE

Experience change
HDMI 1
XS302 HDMI_J
ARC:HDMI 4 XS303 HDMI_J

DAT2+
1
2 HDMI2-RX2P
1 DAD2_SHIELD
DAT2+ DAT2-
3 HDMI2-RX2N
2 4 5 HDMI1-RX2P
DAD2_SHIELD DAT1+
4 HDMI2-RX1P
3 3 6 HDMI1-RX2N
DAT2- DAD1_SHIELD
5 HDMI2-RX1N
4 2 7 HDMI1-RX1P
DAT1+ DAT1-
6
5 1 8 HDMI1-RX1N
DAD1_SHIELD DAT0+
7
6
DAT1- RN302 5.1*4 DAD0_SHIELD
8 HDMI2-RX0P
7
DAT0+ DAT0-
9 HDMI2-RX0N
8 4 5 HDMI1-RX0P
DAD0_SHIELD CLK+
10 HDMI2-CLKP
9 3 6 HDMI1-RX0N
DAT0- CLK_SHIELD
11 HDMI2-CLKN
10 2 7 HDMI1-CLKP
CLK+ CLK-
12
11 1 8 HDMI1-CLKN
CLK_SHIELD CEC
13 HDMI-CEC
12
CLK- RN301 5.1*4 NC
14
13 HDMI-CEC
CEC C320 1uF 6.3V DDC_SCL
15
14
NC HDMI4-ARC
DDC_SDA
16
DDC_SCL
15
17 0.1uF 5.1K
16 CECDD_GND
DDC_SDA +5V
18 C616 R360

10K
10K
17 HDMI1-5V

1K
CECDD_GND 19 R620 10
HPD

10K
18

ULCE0505

ULCE0505

ULCE0505

ULCE0505
HDMI2-5V

ULCE0505

ULCE0505

ULCE0505

ULCE0505
+5V
19 R308 100

R329
R330
HPD

R327
R326
ULCE0505

ULCE0505

ULCE0505

ULCE0505
ULCE0505

ULCE0505

ULCE0505

ULCE0505
HDMI2-SCL

ICVL0518
ULCE0505

ULCE0505
R324 100 HDMI2-SDA
HDMI1-SCL
100
ICVL0518

R307
ULCE0505

D352
ULCE0505

HDMI1-SDA
R325 100 HDMI2-5V

D307

D309

D331

D333
D308

D310

D332

D334
C 47K R310

D301

D306
R328

D302
Q303 4.7K 5VSTB
D322

D320

D318

D317
D321

D319

D316

D315

B 47K R309
BAV70
D305

D303
D304

E HDMI1-HPD_A
HDMI2-HPD

LMBT3904

R331 NC 0R350 NC 0 H31-CLKN

XS301 HDMI_J
MHL:HDMI3 R332
R333
R334

R335
NC 0R351
NC 0R352
NC 0R353

NC 0R354
NC 0
NC 0
NC 0

NC 0
H31-CLKP
H31-RX0N
H31-RX0P

H31-RX1N
HDMI 2
1
DAT2+ R336 NC 0R355 NC 0 H31-RX1P
2
DAD2_SHIELD CD4 R337 NC 0R356 NC 0 H31-RX2N
3 XS304 HDMI_J
DAT2- R338 NC 0R357 NC 0 H31-RX2P
4
DAT1+ 1
5 HDMI4-RX2P DAT2+
DAD1_SHIELD 2 HDMI3-RX2P
6 HDMI4-RX2N DAD2_SHIELD
DAT1- 3 HDMI3-RX2N
7 HDMI4-RX1P DAT2-
DAT0+ 4 HDMI3-RX1P
8 HDMI4-RX1N DAT1+
DAD0_SHIELD R339 5.1 5 HDMI3-RX1N
9 HDMI4-RX0P DAD1_SHIELD
DAT0- 6
10 R342 5.1 HDMI4-RX0N DAT1-
CLK+ 7
11 HDMI4-CLKP DAT0+
CLK_SHIELD 8 HDMI3-RX0P
12 HDMI4-CLKN DAD0_SHIELD
CLK- 9 HDMI3-RX0N
13 HDMI-CEC DAT0-
CEC 100/NC 10 HDMI3-CLKP
14 R343 CLK+
NC 100
H31-SCL 11 HDMI3-CLKN
15 MHL_SCL R322 CLK_SHIELD
DDC_SCL HDMI4-SCL 12
16 MHL_SDA R323 100 CLK-
DDC_SDA HDMI4-SDA 13 HDMI-CEC
17 R344 100/NC CEC
CECDD_GND R612 10 H31-SDA 14
18 MHL_5V HDMI4-5V NC
+5V 15 R617 10
19 DDC_SCL
R311 47k/10K

HPD 0.1uF 16
R312 47k/10K

DDC_SDA HDMI3-5V
17
ULCE0505

5.1K
ULCE0505

ULCE0505

ULCE0505

ULCE0505

ULCE0505

ULCE0505

ULCE0505

ULCE0505

ULCE0505

ULCE0505

ULCE0505

C613 CECDD_GND 0.1uF


18 5.1K
R358 +5V
D349 HPD
19 C615 R349

ULCE0505

ULCE0505

ULCE0505

ULCE0505
ULCE0505

ULCE0505

ULCE0505

ULCE0505
HDMI4-5V

ICVL0518
D313

D312

D314

D323

D324

D325

D326

D327

D328

D329

D330
D311

ULCE0505

ULCE0505
5VSTB
R311,R312:MHL 47k; HDMI 10K 0.1uF BAV70
R303 100
HDMI3-SCL
C322 HDMI3-SDA
MHL_5V

D350

D342

D344

D346
D339

D343

D345

D347
NC 10K

R304 100

D335

D337
D351
CD4 R611 33 D348
CD_SENCE NC 1K
R347

HDMI3-5V
R346
C321 47K R305
R359
HDMI4-HPD 5VSTB
300K 47nF 47K R306
BAV70
HDMI3-HPD
C
MHL_5V 5V_MHL Q333
R319 100K R348NC 4.7K
B HDMI4-HPD_D

1 2
E
DESCRIPTION V59-CTYPE CHK/DATE
N304

1 GND 5
OUT IN NC LMBT3904 GAOHL 20140906 Rev: V1.0 Simon/Gao
0.1uF

R321 100
2 FLG EN CD4
C309 10uF 10V

3 4
AP2171WG

VIDEOCON APPD/DATE
C308

Experience change
59 IO口变更 LDR

10K
AD1兼容LDR

PANEL-ON/OFF
R410
10K
3.3VSTB 3.3VSTB 3.3VSTB XS402
AD1

R409
100 3

ADJ-PWM
R428
FL-W

AD0-KEYA
C402
GPIO56 SII9687A 复位 2
10K 1

AD1
10K 5VSTB
R413 R415
R402 CON03-2.0
N402 0.1uF 1.25VSTB 1.8V

H31-RX1N
NC 100

HDMI4-HPD_D
H31-RX2P
H31-RX2N

H31-RX1P

H31-RX0P
H31-RX0N
H31-CLKP
H31-CLKN
H31-SCL

H31-SDA
FLASH-CZ 1 8
S VCC

UART-TX
UART-RX

**NC 0.1uF PIN 56#


FLASH-DO 2 7 GND
3
Q HOLD 6 PIN109

HDMI-CEC
FLASH-CLK

2.2uF 16V

2.2uF 16V

4.7uF 10V
W C

IR_IN
4 5 FLASH-DI
VSS D

C417

C423

C424
C420

C421

C422

C425
R401 10K

0.1uF

0.1uF

0.1uF
GD 25Q32 GND GND

PWR-ON/OFF
in IC in IC

220

1.8V
R407
3.3VSTB

FMIO
3.3VSTB

132
131
130
129
128
127
126
125
124
123
122
121
120
119
118
117
116
115
114
113
112
111
110
109
108
107
106
105
104
103

2.2uF 16V
HDMI1-HPD_A N401

C426
4.7K 4.7K

C427

C428

C429

C430
TEST
MASK2
MASK1
E-PAD
HOTPLUGA
RX2P_D
RX2N_D
DDCDD_CK
RX1P_D
RX1N_D
DDCDD_DA
RX0P_D
RX0N_D
RXCKP_D
RXCKN_D
HOTPLUGD
GND_EFUSE
HWRESET
CEC
IRIN
SAR2/GPIO73
SAR1/GPIO74
SAR0/GPIO75
AVDD_DDR
DDCA_DA
DDCA_CK
PWM1/GPIO25
PWM0/GPIO26
TESTPIN
GPIO64

C431
0.1uF

0.1uF

0.1uF

0.1uF

C443

C445

C432
0.1uF

0.1uF

0.1uF

0.1uF
R423 R424
in IC
I2C-SCL
HDMI1-CLKN 1 RXCKN_A
HDMI1-CLKP 2 I2C-SDA

FM RXCKP_A USB1-D+
HDMI1-RX0N 3 RX0N_A USB1_DP 102

XS405
HDMI1-RX0P

HDMI1-RX1N
3.3VSTB
4
5
6
RX0P_A
AVDD_33
USB1_DM
AVDD_MOD
101
100
99
USB1-D-
3.3VSTB
USB0-D+
IC POWER
RX1N_A USB0_DP
I2C-SCL R425 100 7 HDMI1-RX1P 7 98 USB0-D-
RX1P_A USB0_DM FLASH-CZ VCC-PANEL
HDMI1-SDA 8 DDCDA_DA SCZ 97
I2C-SDA R426 100 6 HDMI1-RX2N 9 96 FLASH-DO
RX2N_A SDO
HDMI1-RX2P 10 RX2P_A SDI 95 FLASH-DI
FMIO R427 100 5 HDMI1-SCL 11 94 FLASH-CLK
DDCDA_CK SCK
HDMI4-ARC 12 ARC PWM2/GPIO24 93 FL-W 1
AL-OUT C4491uF 0402 6.3V4 1.25VSTB 5.1 13 92 I2C-SCL 2
VGA-HS
AVDD1P2_DVI_A GPIO0
14 HSYNC0 GPIO1 91 I2C-SDA BL_ON/OFF 3
AR-OUT 3
C4481uF 0402 6.3V RGB0-PB+ C403 47nF 50V 15 90 4
BIN0P GPIO2
VGA-GIN R416 C444 1nF 50V 16 89 LED-R 5
2 47nF 50V SOGIN0 GPIO3
RGB0-Y+ 0 C404 17 GIN0P INT/GPIO65 88 AMP-MUTE 6
R403 C405 47nF 50V 18 87 1.25VSTB 7 RXO0+
R430 NC/0 1 68 C406 47nF 50V GIN0M VDDC
RGB0-PR+ 19 RIN0P LVB0M 86 RXO0- 8 RXO0-
5VSTB R431 0 VGA-VS 20 85 9
TSUMV59MS
CON07-2.0 RXO0+ RXO1+
3.3VSII VSYNC0 LVB0P
3.3VSTB 21 AVDD3P3_ADC LVB1M 84 RX01- 10 RX01-
PB C407 47nF 50V 22
BIN1P LVB1P 83 RXO1+ 11 RXO2+
YIN C408 1nF 50V 23 82 3.3VSTB 12 RXO2-
Y C409 SOGIN1 AVDD_MOD
47nF 50V 24 81 RXO2- 13
GIN1P LVB2M
R404 68C410 47nF 50V 25 80 RXO2+ 14
PR C411 GIN1M LVB2P
47nF 50V 26
RIN1P LVBCKM 79 RXOC- 15 RXOC+
27 VSYNC1 LVBCKP 78 RXOC+ 16 RXOC-
28 HSYNC1 LVB3M 77 RXO3- 17 RXO3+
C441 47nF 50V 29 76 RXO3+ 18 RXO3-
AV2 CVBS2 AV2 LVB3P
30 CVBS1 LVB4M 75 RXO4- 19 RXO4+
C442 47nF 50V 31 CVBS0 LVB4P 74 RXO4+ 20 RXO4-

CON30_2.0*2
AV1
AV1 R414 68 C438 47nF 50V 32
VCOM LVA0M 73 RXE0- 21 RXE0+
CVBS_OUT L402 0 33 72 RXE0+ 22 RXE0-
CVBSOUT LVA0P
34 AU33 LVA1M 71 RXE1- 23 RXE1+
C412 0.1uF 35 70 RXE1+ 24 RXE1-
3.3VSTB AUREF LVA1P
36 AUVAG LVA2M 69 RXE2- 25
PC-INL 37 AUL1 LVA2P 68 RXE2+ 26
PC-INR C434 1uF 0402 6.3V 38 67 3.3VSTB 27 RXE2+
C433 AUR1 AVDD_MOD

XS401
RXEC-
4.7uF 10V C435 1uF 0402 6.3V LVACKM 66 28 RXE2-
AVDD3P3_DADC

RXEC+
LVACKP 65 29 RXEC+ 3.3VSTB
AVDD_DMPLL

30 RXEC-
AVDD_DDR

NC/10K
AUOUTL0
AUOUTR0
AUOUTL1
AUOUTR1

31
GPIO55
GPIO56
RFAGC

LVA4P
LVA4M
LVA3P
LVA3M
32
AUL3
AUR3
AUL4
AUR4
AUL5
AUR5

XOUT

VIFP
VIFM

VDDP
VDDC
XIN

33 RXE3+
34 RXE3-
TSUMV59MS 35 RXE4+
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64

R419
36 RXE4-

XTAL 37
NC/10K R420
RXE3+
1.25VSTB

38
XIN

C413
3.3VSTB

3.3VSTB
1.8V

9876_RST

RXE3-

39
XOUT

1uF 0402 6.3V


RXE4+
MHL-CP
VIFM

RXE4-

C414 1uF 0402 6.3V


VIFP

C418 L2 40
27p
XIN
R2
2
24MMHZ

C4391uF 0402 6.3V


X401

L1
TV_AGC

R1
R405

V59-CTYPE CHK/DATE
1M

C440
DESCRIPTION
1

1uF 0402 6.3V


C419 AL-OUT
27p XOUT AR-OUT
L403

Simon/Gao
N17387348
Rev: V1.0
0

R406 GAOHL 20140906


C436

0.1uF
R421NC 100K

0
R422NC 100K

CLOSE 59 GND
3.3VSTB
AMP-AUOUTL0
AMP-AUOUTR0

VIDEOCON APPD/DATE
C447

C446
NC 1000p

NC 1000p

Experience change
5VSTB AH502 AH504
12VSTB 1 1 AH7 AH2
1 1
L504 4.7uH 3A
O_PCBHOLE_3.5MM O_PCBHOLE_3.5MM O_PCBHOLE_2.5MM O_PCBHOLE_2.5MM

NC 1000p
C536
C535
C525

C534 N507 1uF R519 AH5


mp1471 AH503 1
1 AH501
27K 1%
R522
1
100K
2.2uF 16V

3 6 C537 O_PCBHOLE_2.5MM
C533 C538
0.1uF

IN BST O_PCBHOLE_3.5MM

220uF 16V

10uF 10V
2 O_PCBHOLE_3.5MM
SW R521 0.1uF
5 4 AH6

GND
EN FB R520 1
75k AH4
5.1K 1% 5VSTB 1 AH1
1

D
5VSTB 1
O_PCBHOLE_2.5MM
TP1

O_PCBHOLE_3.5MM
反面2mm 待机测试 C509 O_PCBHOLE_3.5MM

G
R511
Q504

D
100K 1uF 16V ME2345A
PANEL POWER Q503

G
R510 NC
12VSTB
5VSTB N501 WPM9435
1.26V for V59 CORE POWER about 600mA ON R512
1
2 S D
8
7 VCC-PANEL
4.7K 10K
3 S D 6
R503 4 S D 5
OFF C520 G D
C523

C
R516 **27K 1% C522
4

1.25VSTB
R514

Q502
1

PWR-ON/OFF R513 10K B 2.2uF 16V


IN

FB

N504 LMBT3904 1uF 16V 0.1uF 50V


100K
SY8077
10K

GND

E
LX

EN
4.7uF 10V
C504

10uF 10V
3
2
1
2

R515

C524 NC1 0uF 6.3V 0603 R505 10K


**24K 1%

L502
R504
C515

PANEL-ON/OFF
4.7k

C
C516
0.1uF

6.8uH LTD43 B
Q501
LMBT3904

E
ON

OFF
0.6 X ( 1 + 27/24k) = 1.28V

LDO 12VSTB

L501 6.8uH 2A
5V_MHL

3.3VSTB 200mA 1.8V 300mA

NC 1000p
1.8V

C529
C528

C530

C527
3.3VSTB

N508 1uF R523


100 1%
1.8K 1%

mp1470
5VSTB 300mA
2
4

27K 1%
2
4

R526
5VSTB

100K
2.2uF 16V
3 6 C526 C531

0.1uF
C532
R518

3 1 IN BST
R502

3 1

4.7uF 10V
N505 2
1

N506 SW

100uF
C517 C518 C521 10uF 10V R525 0.1uF
ZTP1117-ADJ 5 4

GND
ZTP1117-ADJ EN FB
C510 C511 R501 C513 C514 75k R524
1

0.1uF 0.1uF
C519 5.1K 1%

1
10uF 10V 10uF 10V

TP2
C
0.1uF 10uF 10V 0.1uF MHL-CP R302
Q505
2

R517 10K B
2.7K 1% 47 1%
反面2mm 待机测试

E
LMBT3904

DESCRIPTION V59-CTYPE CHK/DATE

GAOHL 20140906 Rev: V1.0 Simon/Gao

VIDEOCON APPD/DATE

Experience change
5VSTB

HDMI2-HPD
10
3.3VSII

3.3VSII

R622
10K R601
10uF 10V C627
PWRMUX_OUT PWRMUX_OUT RESRT_N
2 1

C620
C602

C618

C619
C601

1.05VSII

33

1
1

1K R602 0.1uF C628


9876_RST Q601

10uF 6.3V
LMBT3904 59# 76#

2
2
10uF 10V

R619

0.1uF
4.7K

0.1uF
0.1uF

HDMI2-SCL
HDMI2-SDA
SCL
SDA
PWRMUX_OUT
1.05VSII

HDMI2-RX2P
HDMI2-RX2N
HDMI2-RX1P
HDMI2-RX1N
HDMI2-RX0P
HDMI2-RX0N
HDMI2-CLKP
HDMI2-CLKN

HDMI2-5V
R618
AVDD10 L602
LB

C623
C621

C622
57
56
55
54
53
52
51
50
49
48
47
46
45
44
43
42
41
40
39

1
R0X2P
R0X2N
R0X1P
R0X1N
R0X0P
R0XON
R0XCP
ROXCN
VDD10
ARC
SPDIF_IN
CSCL
CSDA
PWRMUX_OUT
SBVCC5
R0PWR5V
CBUS_HPD0
DSCL0
DSDA0
1# 58#

10uF 6.3V
2
0.1uF

0.1uF
AVDD10

2
3.3VSII
AVDD10 R1PWR5V
58 VDD33 CBUS_HPD1 38
59 R1XCN DSCL1 37
60 R1XCP DSDA1 36
61 R1X0N R2PWR5V 35 HDMI3-5V
62 34 R614 33 HDMI3-HPD
R1X0P CBUS_HPD2 1.05VSII
63 33 HDMI3-SCL
R1X1N DSCL2
64 32 HDMI3-SDA
R1X1P DSDA2
65 31 HDMI4-5V

C624
R1X2N R3PWR5V

C626

C625
66 30 R613 33 HDMI4-HPD
R1X2P CBUS_HPD3

1
HDMI3-CLKN 67 29 HDMI4-SCL 5VSTB
R2XCN DSCL3
HDMI3-CLKP 68 28 HDMI4-SDA
R2XCP DSDA3

10uF 6.3V
HDMI3-RX0N 69 27 10K 10# 49#

2
R615
R2X0N DSCL4(VGA)
HDMI3-RX0P 70
3 26 R616 10K

0.1uF
R2X0P DSDA4(VGA)

0.1uF
HDMI3-RX1N 71 25 CD_SENCE
R2X1N CD_SENSE
HDMI3-RX1P 72 24 RESRT_N
R2X1P RESET_N 3.3VSII
HDMI3-RX2N 73 23 R610 10K 1.05VSII
R2X2N INT
HDMI3-RX2P 74 22
75
76
R2X2P
VDD33 4 MHL RSVDL
TPWR_CI2CA 21
20 TXAVDD10 L603

TAVDD10
EPAD R609 4.7K

AVDD10
77 5VSTB

R3XCN
R3XCP
R3X0N
R3X0P
R3X1N
R3X1P
R3X2N
R3X2P
VDD10
LB

C629
TX2P
TX2N
TX1P
TX1N
TX0P
TX0N
TXCP
TXCN

C630

1
R621
NC 1K

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19

10uF 6.3V
2
SII9687A

0.1uF
N602
HDMI4-RX1N
HDMI4-RX1P
HDMI4-RX2N
HDMI4-CLKN
HDMI4-CLKP
HDMI4-RX0N
HDMI4-RX0P

HDMI4-RX2P

H31-RX2P
H31-RX2N
H31-RX1P
H31-RX1N
H31-RX0P
H31-RX0N
H31-CLKP
H31-CLKN
TXAVDD10
1.05VSII

SCL 100 R607 I2C-SCL

SDA 100 R608 I2C-SDA

5VSTB
1.05V for V59 CORE POWER about 350mA

C610

C611
33p

33p
GND GND
R606 **2K 1%
4

1.05VSII
R603
1

IN

FB

N601
SY8077
10K

GND

V59-CTYPE CHK/DATE
LX

EN
4.7uF 10V

DESCRIPTION
C603

10uF 10V

10uF 10V

3.3VSII
3
2
1
2

R604

R605

C607
20140906 Rev: V1.0 Simon/Gao
**2.7K 1%

C604

L605 5VSTB
GAOHL
2
4

0.1uF
C605

C606
0.1uF
NC

10uF 6.3V

10uF 6.3V
0.1uF

6.8uH LTD43
3 1
C6121uF 10V

N603
ZTP1117-3.3
VIDEOCON APPD/DATE
C609

C631
C608

0.6 X ( 1 + 2/2.7k) = 1.05V Experience change


R767 R770

8
68 68
R768 R771
6

C754 2200P 2KV


R749 7 68 68
100K 2W R750 NC C739
5 100P 1KV R769 R772
R751 NC 8
Q701-C 68 68
R752 4
NC
9
R753 NC D714
D707 3
NC FR207 10 SF59AG
2 D715

9
D706
11
L707 SF59AG
Q707 C E FR207 1
GND1 60-200V_LED+
LMBT3906
J12.5mm

R773
Q701-A

100K
2
R756 470 TMPF8N80

B
C727

D
100pF 1KV T703
R757 47 1
G SYEQ3214-T200A

33uF 250V
6
R758

C741
C752

C740
3
R762

NC

NC
2 10K

OUT
FB R763
30 30
R759 20

100K
R716

R774
R714 R715
1M 2M 1% 2M 1% 3 N702 R775
RI C742

OB2273A
60-200V_LED+
R712 R760 NC 51K
27K 1% 100K NC 0.1uF 450V

1nF 50V
R761

GND

VDD
R719 4
IS R776

C729
10 LED-
1K R765

C730

5
Q702 R764 2.2K

NC/
0.1uF 50V

NC 2.2

RA20 2R20 1%

R782 2R20 1%
KF 47uF 50V

GND1 C710 R711 LMBT3906 0.33


C715
C714

E C

R784 10
C743

R783 10
10nF
10K C728

D708
0.47uF 50V
OK***0.47uF 50V

C732

M7
R722
220p

B
C709 N701 R777 C744

20
R720
OB6561PC GND1
470 4.7K 0.1uF 50V
OK***0.47uF 50V 1 8
2 FB VCC 7 R721
GND1 GND1
3 CONTROL DRV
GND1
6 47
A-A
560 R709
4 CT GND 5 N708
CS ZCD R723 4 1 4.3
C712

C713

R779 R781 5VSTB


10K
OK1000p

510 100
100p

Q701-B C745 C746


4

MMF60R360P R700 0
RA17
20K

GND1 3 3.3
2

R780
G

3.3K
10uF 10V 0.1uF
5 6

A-A
D S EL817

C
GND1 R766 NC 1K 1.5K 1%
100 R725 B Q705
3.3VSTB R786
NC LMBT3904 IN-A
T701 N704

E
GND1 47P 1KV C733 N707 R785 AS358M
R710 100 R726 4 C753 0.1uF
PFC GL-2634WH 20K 1 510 GND 1 8
0.1 2W

OUT-A VCC 7
R727

R787 1.8K 1%
1.8V 2
4

BAV70
IN-A OUT-B 6

NC 47uF 50V
3
NC

NC

NC

3 C747 4 IN+A IN-B 5 0.3V

C726
2
GND IN+B
100P R795

D709
EL817 18K 1%
NC
NC

NC
NC

C707 GND1
RT701 GND1
10
9

3
11

100P 1KV

S
R729 68 SCK_2R55A R794
L705 GND1 Q710
NC 27K

G
R798 3.3VSTB

3.3K R788
R730 NC W41W
100uF 500V

68 C748
J12.5mm
C749 NC 20K

2K 1%
1

无 PFC R797
C708

0.1uF 50V

R793
RA18 1.5M RA19 1.5M

NC
R792
1uF
W702NC/7.5mm SF59AG
NC 1K

C
2

Q709 RA02 ADJ-PWM


D705 B RA01
W701NC/7.5mm NC 3904
560

C750 NC *10nF

R799 NC 4.7K
NC 4.7K

E
R789 R790 R791
GND1

L703 120k
0.47u 500V LGB1210-82uH ! 120k 120k
60-200V_LED+
C706

R732
0.47u 500V 56K 2W 1
C705 R731 10 11
2
2200p 2KV C718 10

+B
L704
FR207 3
GND1 9
安安安安1.5MM D716 J12.5mm 4
D704 1N5408

Q704
D702 1N5408

8
D701 1N5408

C E
D703 1N5408

Q703 安安安安1.5MM 5
LMBT3906
! R733
470 P4NK60ZFP 7
6

R738
R737
R734 100 G
T702
6

R736 47 47
10K SYEQ2612-T012A

S
2
OUT

FB XS702
1 2
R735 20 1 H901 2 CON04-2.0
R705 R706 330K R707 330K C719
R708 330K N14624603
3 N703 HEATSINK_2PIN
RI 100pF 1KV
OB2273A

MYG10K681
C722

2
1

3
4
R739
3

1nF 50V 100K


MBRB20200CT
R740
GND

VDD

4 N14654900 1 2 12VSTB
IS
! 1K
1

N14624438 C725 R742


! 3

GF-470uF 25V
L702
GND1 GND1 R741
C724 220p NC

R744 20
R743 20
20mH C723
0.47 1W
0.47uF 50V D717

C735
4

C751A
0.33uF 275V C704

270uF 16V 固固 C751


GND1
1000p 400V
C734 RA03 68

GF-470uF 25V
GND1
C701 NC 1.5M RA04
10uF 50V 68
1.5M R704
NC 470p 400V
NC 470p 400V
C703

C702

R703 GND1 C720


1000p 100V
RA05 68
GND
R701 R702 1.5M
GND BAV70 NC 100P 160V R745 NC 10
NC 1.5M
R746 10 D710
1

N706
FR107 R748 4 RA06
D711 1
1K 1K
L701 D712 C721
3
! 5mH Y9 KF 47uF 50V
2

EL817
GND1
2

11.3V RA10
D713
47K

GND1
R747

47K 1%
1K
T3.15A

Y6
F701

RA08
注意PCB封装 EBC N705 RA09
4
C

1.2V 3.3K
B Q712 1 BL_ON/OFF

2N4401L RA11

C
C737 1K Q708 RA15
3 B
E

2 LMBT3904
2

2.2K
0.1uF 50V

E
EL817
N

RA14 RA16
C738 47K 10K
XS701 ! GND1 0.1uF
10.3V
3

N709
1
CW431
2

12K 1%
2.488V

RA12 RA13
220
LED- 3

60-200V_LED+ 0/NC LED 1


R823 XS802
NC CON03-2.0

LED 3

2
1

60-200V_LED+ XS803
NC CON03-2.0

CON08-2.0 NC CON10-2.0
XS801 XS801A
LED- 8 10

7 9
XS804 6 8
2
5 7
1
4 6
CON02
3 5

2 4

1 3
60-200V_LED+

2
1

DESCRIPTION V59-CTYPE CHK/DATE

GAOHL 20140906 Rev: V1.0 Simon/Gao

VIDEOCON APPD/DATE

Experience change
PCM1808 3.3V/10mA 3.3VSII

3.3VSII PCM1808 5V/9mA C903


NC
To void earphone POP

C936
27p
5VSTB

C935
C902
R15 Left 24bit; NC I2S 24bit

10
12.288MMHZ
100

10uF 10V
R945
AMP-AUOUTR0

R916
R917

0.1uF
2 1 EAR_R+
R903

R939 470
R909 10K C911 10uF 10V
R902 1M X901
1 5
C913 NC VCC

5VSTB
R908 C910 0.1uF

10k
Q903

10k
1nF 50V 100K 1uF 0402 6.3V N901 2 LMBT3904
C957 10uF 10V 100 R940
C904 R901 1k 14 1 A
C905 13 VINR VREF 2 C908 0.1uF 100
R905 1k 3 Y 4
12 VINL AGND 3 10 GND MCLK'

150p
1uF 0402 6.3V 11 FMT VCC 4 R937 AMP-MUTE
MD1 VDD 10K R942 1K R944
1nF 50V 100K 10 5 3.3VSII R943 GND N902 Q905
C914 R910 MD0 DGND LMBT3904

C955
DATA R919 33 9 6 1uF 6.3V N_SGM7SZ04 EAR-L+
DOUT SCKI C909
BCK R920 33 8 7

10uF 10V C956


AMP-AUOUTL0 BCK LRCK
R911 10K
N_PCM1808 R918 33 Q904
MCLK

27pF
27pF
LMBT3904

C945
C944
7SZ04 3.3V/50mA
R904 33 LRCK 100 R941

27pF
27pF
PCM1808 3.3V/10mA
STA5711 3.3V/55mA

C980

C979
3.3VSII
4.7nF 50V
C946 4.7nF 50V
C949
47nF 25V
注意Boost电容耐压
R950 NC/15K

47nF 25V

2.2nF 50V
L901 15uH 3A

1uF 25V
C934

22k R946

C958
C947 R948 470 C948 R947 470
0.1uF 50V 1 2

C959

SPEAK_L
C940 1uF 16V

C938 1nF 50V


0.1uF
120oHm@100MHz 12VSTB

470uF 25V GF
3.3VSII L905 C950
R949 NC/18K
0.01uF 50V
C962

C961

12

11

10
C952

1
10uF 10V

C960

C939
0.1uF

SPK_L+
VR_ANA

PLL_FLTP

PLL_FLTM

AVSS

NC

OC_ADJ

SSTIMER

GVDD_OUT

BST_A

PVDD_A

PVDD_A

OUT_A
1nF 50V
0.1uF

C937
13 48 C915
AVDD PGND_AB C951
0.47uF 50V
14 47 GND 0.1uF
FAULT# PGND_AB
L902 15uH 3A
MCLK 15 MCLK OUT_B 46
1 2
3V3D
16 OSC_RES PVDD_B 45 12VSTB 1CON04-2.0
R951 18.2k-1% L+

C933 0.1uF 50V

0.1uF

1nF 50V 1nF 50V


17 44
4.7uF 10V

DVSSO PVDD_B 2

C932
L-
0.1uF
C963
C964

C973

C974
18 VR_DIG BST_B 43 3
R955 TPAS5707 R-
19 42

0.1uF 50V
PDN# BST_C SPEAK_R 4

0.1uF
4.7k
R+
AMP-MUTE LRCK 20 41

C972
LRCLK PVDD_C

C971
R954 100 XS902
BCK 21 40 12VSTB C941
SCLK PVDD_C
DATA 22 39

22uF 25V E3.5


SDIN OUT_C

SPK_R+
1 L903 15uH 23A
I2C-SDA 23 38 C901 0.1uF
SDA PGND_CD
R929 100 0.47uF 50V C943
24 37

C970A
I2C-SCL 1nF 50V
SCL PGND_CD
GVDD_OUT

R930 100
RESET#

PVDD_D

PVDD_D
STEST

BST_D

OUT_D

220uF 16V
DVDD

DVSS

AGND

VREG
GND

C942
1uF

1nF 50V C930


0.1uF C929
7 XS901
0.1uF
25

26

27

28

29

30

31

32

33

34

35

36

10uF 10V
1K
1uF 6.3V

C981

C918 R924EAR_R+
2
C968 1uF 25V

C970
C965

SPK_R+ 1
0.1uF

12VSTB
C931 SPEAK_R 5
0.1uF 50V 1 2
L904 15uH 3A
SPEAK_L 6
R952 100
C969

SPK_L+ 3
R953 C919 EAR-L+ 4
1K
4.7k R925
120oHm@100MHz
3.3VSII L906 10uF 10V
C966

C967

3V3D
10uF 10V
0.1uF

DESCRIPTION V59-CTYPE CHK/DATE

GAOHL 20140906 Rev: V1.0 Simon/Gao

VIDEOCON APPD/DATE

Experience change
VIDEOCON INDUSTRIES LTD. V59-CTYPE

. BOARD SERVICE MANUAL

1). Power supply Trouble (LED no bright)

OK
Check 5VSTB

NG
OK
Check LED & line Check 12VSTB Check N507 & peripheral circuit

NG

OK
Check +B (380V) Check N709,N703 & peripheral circuit
supply .
NG
NG
Check F701, RT701,D701∽D704
Or N701 & peripheral Circuit Repair the circuit

OK

Check X701 & Power Input circuit

2). Power supply Trouble (LED is bright)

NG Check the power supply circuit


Check 5VSTB
(See: Power supply Trouble (LED no bright))

OK
NG
Check N110 for 1.25VSTB Check N504 & 1.25VSTB Pins of N401
Check N121 for 3.3VSTB Check N507 & 3.3VSTB Pins of N401

OK

Check Q504 for 5V NG Check Q504 for 5V& 5V peripheral Circuit


Check N506 for 1.8V to DDR Check N506 for +1.8V & 1.8V circuit of N401

OK

See: Display Trouble

The information in the specification is subject to change without notice


20
VIDEOCON INDUSTRIES LTD. V59-CTYPE

3) Display Trouble (black screen)

OK
Check LED+ VCC Check ADJ-PWM VCC is low

NG

NG Check Q708 & BL-ON/OFF peripheral


Check if VDD(17V) of N702 ?
Circuit

OK

NG
Repair the circuit
CheckD714 D715 N702 N704
& peripheral circuit?

OK

Check The Panel.

The information in the specification is subject to change without notice


21
VIDEOCON INDUSTRIES LTD. V59-CTYPE

4) Display Trouble (abnormal screen)

Check if the LVDS cable is right and if


well connected with the board
NG

1、reconnect the cable; OK


2、Change the LVDS cable.

Check if the LCD panel is OK

NG

OK
Change panel.

Check if between the LVDS jack


and N401 is well soldered
NG
OK

Repair the damage circuit Change N401.

The information in the specification is subject to change without notice


22
VIDEOCON INDUSTRIES LTD. V59-CTYPE

5) Audio Trouble (no sound)

NG
Check if audio signal Input is normal

Check external OK
audio equipment

NG Check if Speaker ON/OFF set


or if mute function is off

OK

Set it ON Check if the voltage (1.5V) on NG


pin13 14 of N901?

OK

NG
Check if The Wave ON pin4 of Check N901 or
N902 is OK? Change N901

OK

NG
Check N902 & Check the voltage (6.4V) on
peripheral Circuit pin1 46 39 36 of N903?

OK

OK
Check if XS902 XS901 is OK?
Check N903 N902
& peripheral circuit
NG

Change Speaker Repair the circuit

The information in the specification is subject to change without notice


23
VIDEOCON INDUSTRIES LTD. V59-CTYPE

6) Function Trouble (ATV)

No channel be find

NG
Repair external RF equipment Check the RF cable for RF signal

OK

NG
Repair the power net to this Check the voltage (3_3V_TUN)
pin. on N1

OK

NG
Repair I2C net Check R7 & R8 for I2C data
Repair AGC net. Check IF_AGC voltage(0∽2.2V)

OK

Repair IF net NG
Check the R2 & R5 for IF NET.

OK

NG
Update the Software Check the Software

OK

Change N1

The information in the specification is subject to change without notice


24
VIDEOCON INDUSTRIES LTD. V59-CTYPE

7) Function Trouble (PC)

1. No signal Color fade


2. Image is not stable

Check if VS signal & HS Check R.G.B input


signal are regular signal.

NG OK NG OK

Repair the circuit It’s an unsupported Repair R.G.B Change N401


of VS, HS. mode. input signal net.

Picture is not in center

Do “Auto adjust “process.

The information in the specification is subject to change without notice


25
VIDEOCON INDUSTRIES LTD. V59-CTYPE

8) Function Trouble (YPbPr, CVBS)

CVBS / YPbPr no signal YPbPr Color Bad

1. Check CVBS IN /Y IN line 1. Check Pr & Pb line Connect is OK


Connect is OK 2. Check Pr & Pb net
2. Change N401 3. Change N401

9) Function Trouble (HDMI)

HDMI no signal & no sound

YES
HDMI terminal is badly soldered
Check if The HDMI terminal is
Check HDMI I2C
HDMI4?
Check the voltage (5V) for
hot-plug (PIN19) of HDMI
Repair N401 HDMIA in Circuit
NO

NG
Check if Sii9687 & peripheral Repair the circuit of N602 or
Circuit peripheral Circuit

OK

1. HDMI terminal is badly soldered


2. Check HDMI I2C
3. Check the voltage (5V) for hot-plug (PIN19) of
HDMI

The information in the specification is subject to change without notice


26

You might also like