Fuel Level Sender Signal Conditioner
Used to filter the fuel level signal voltage from
the fuel sender and improve accuracy.
1. Enter ‘Main Setup’ and select ‘Functions’.
2. Search functions for "Fuel Level Sensor’and
enable
3. Click ‘Edit Connection’ and assign any
available Analogue Voltage Input (AVI)
4. Ensure PulL-up is disabled
Termination 5, Click the ‘Calibration’ tab at the top of the page.
7 Power (-12¥) 6. Two main measurements are required. The
2 Ground voltage of your selected AV! will need to be read
31 Faw sence Sia when the fuel tank is empty and again once filled
+] Fost Sener Frog Sora with a known fuel quantity. These voltages (0-5V
wanes 4 signal) and known fuel quantities (litres) should
be updated in the calibration table accordingly
* (see example calibration table below)
Ssoee| Pa} stnoutrcen oor >| “SES eg eg ee
Please take care when wiring this device as
incorrect wiring will damage this device!
Note: Fuel Level Signal Conditioner Out = 0 to 5V.
HT-038002
Revision #6
Need more help?
B rmtatecrcartusot speach con
6 rOS 00106 99<5u6
yes suid pue Bid p W1G
Buiyoyew ou - (/A\¥) jnduj abeyo,
anBoyeuy ue yim asn Joy jeubis
@ANSISA B S19}
JEUOHIPUOD [eUuBIS
dapuas |eaAe7 jen4
2008€0-LH
Suteoee ps uy sy ancosy ol 8x pant
(aye soodun 2 pound tes seu ou ube popes hy) Bees 0 B85
101 hep af wtzm Bubenced peundoun eve OBIE Hume sey um se
oni. ure psd our pode pany sass pues oa
‘si ede Ame Ser mre sem ont
sfesiae in onmucs rs oe