.o Pre-Amplifier
‘YAMAHA THANKS YOU FOR CHOOSING THE C6 PREAMPLIFIER
CONTENTS
CAUTION: READ THIS FIRST
aaeeeer :
Genome
ransitars andthe DC guste amir wth
hghtramconductnoe ous! FET. combine to
provide the ebolute minimum of noe and» Sat
Parana tne conte
YAMAHA‘: orginal srvo contol cuit with te
Towewize 10 festurng 2 high dec strength
allows the cert frequeny, amiiiestion and
frequency bandwidth tobe vais eontnuouly and
for the sou flan ton! ela to be compen
“Tone made wsetor
mesic tone conto! with payback, recording ot
i noise eduction recording ae payback.
{F dub the contents of ape playing In one doh
arty f sco Sete
{LOW ard HIGH fiers for outing ov undseabe
ris, the balance conto for ataining bal
the sound hrough the left ec gh speaker, the
[AUDIO MUTING ste tat witha ip reds he
volume 29 one tenth and the headphones ck, eae
@& VAMAHA(G-G cavmons nev mais pest
|
oad ahs manual crf to get the bet
performance rom te Pre-Amoiie,
2
De not drop or othe jr he Pr-Amo:
fi
3
Do not expose the Pre-Amplifier to are
sgh, excessive eat eat du,
4
a not ie chemi! sent to clas the
‘of sgtly damp doth
5
Do not atampt to make intemal aust
‘id YAMAHA service opavnttve.
6
CCeck the “Troubiethooting” Ht provided
inthis manal for eammon operating eros
before suming that here malfenton
7
Operate at swlches and knobs according to
the instructions. Avoid spying undue
fore, Do not try £0 us inrmedite set
8
Note tht o muting tele kaeps the Pre
Ampito slont for seal conde eftr
9
(US, Canada & Generel mods ony) Do
tot comet suo squint 9 the AC out
lets on the mar anal if that auipent
‘ques met power than the outlet ae
‘ated 0 proce,
10
Keep this manual ina safe poe fr tute
referees.
IMPORTANT
Spec Instructions for Brith Standard Made! |
WaRwing
To prevent fre oF mock hazard, do not
exoare his appliance tenor msture(G-@_specirications
“Penna quan Chenin
TEVELGONTAOL Comic #956
Teulon wore Goiremarewe
“ng 18 oe
‘il Snoin AN(8-@_rront PANEL AND CONTROLS
POWER Switch @PARAMETRIC TONE CONTROL
Sniteh ON to con ef "
Lave OFF le
@TONE MODE Selector Switch
caAUDIO MuTING Gwen
Provides 20d rduetion In volume without
Jemant of VOLUME contol. Ust wher opr
ing owiehe, before lrg the pn carte
‘nto the record, oF when ansuting phone al,
@VOLUME Contra!
Tun clocivite tinea volume, We recom
Clockwise when no int
OPHONES (Hee:
Cannct your stereo headchones oti ck.
@PRE OUT Switch
‘This witch is uid to put ON and OFF the outer
OFWLTER Switene
LOW: When thie button swith pushed ues
low taquarey oie below 1642 out the
tune feauerey range, normally une:
tssry for musi eproduction, ict of s0
1 to prevent the speaker’ vita ow fe
funny reaction (tering of cane paper)
13103 warped i.
HIGH: Pshing ti button site, cue ih fe
MODE Switch
Sects ero. ono.
@PHOND Switch
Sects PHONO 1 oF PHONO 2, and HM phono
fartidge oF MC anonoearrige of HON 1
@BALANCE Contre!
‘Controle the diferees in output volume batween
et) nd Fig stereo chan Use 0 a
jst the banat inthe two Sanne” audio out
Dts or to eoect for 8 latening poston not
@REC OUT Selector Switch
‘an be recorded iralivnt tote program ssced
by the INPUT sector switch Fr ample, you
‘cu record an FM broadest by plcing the AEC
‘OUT lector aviten in the TUNER postion or
fib a tape wile Tatening t0 9 sie trough
“Typical examples:
mio neconT|
‘er
cm
wn ven
{8y matching other poeons ofthe REC OUT and
INPUT stehes, yu can enjoy various other pro
tim te REC OUT sector swt in the OFF
‘tho recording outout terminals Thus, when you
te not recording, the 3 wil be rated rom
tiny otere effets of unveed tape deck nowt
SSeult impedances Use the potion when not
reading.| rs a ! qn
a ie fi ee
(GENERAL Med)
ae to)
aUS.A. and CANADIAN Models
To
“yo
BRITISH
@GND Ground Termine!
@ INPUT Terminal
[Use the PHONO terminals to connect 9 tenabis,the TUNER termina to
onnact a tuner, andthe AUX termina to connect an xem ght track
(ridge player oe Slated by INPUT Selector onthe front pol
REC OUT Selector independent ofthe source being layed
@PRE OUT Terminale
{Connect she this termina tothe INPUT terminal on powar amir by
@ Ac Power Cord
Plug the receiver's power cord nto a main power supaly wal outlet (With &
Beith mode est retrto the IMPORTANT isructons on P.2
@ VOLTAGE SELECTOR (GENERAL Mode!)
‘Set this to your les! AC mains voltage, Failure todo so wil eit in seit
Ac OUTLETS (U5.A, CANADIAN and GENERAL Modes)
Provided for connecting ether ao equipment. Tha aft out, withNAL FUNCTIONS.
(-@_ave
‘TONE MODE SELECTOR PERWITS VERSATILE USE OF BUILTIN PARAMETRIC TONE CONTROL
‘The C4 incorporates newly dovloped Peramuttle Tone Conte cee, sitched over by the TONE MODE
Ssaetor onthe rot pant
Fi: 2 TONE CONTROL GRAPHS
‘= BANDWIDTH CONTROL
TONE MCoE
ee en Se
° SO
|PARAMETRIC TONE CONTROL
ESE
Pees ills
po
(ne of the mot excting and inno
of te CO i the Yamahaotclusin Parimetie
Tore Convo! cieuit using serve convo PTC
parmisurvesicted, Independent, continuous
fontzol of tee parameters ~ center fequercy
ff, tequeney bani (and ven 9
frequency bands HIGH BAND ara LOM BAND.
The cater fequerey (4) contra range inthe
LOW BAND i 31.5He — 640He and inthe HIGH
BAND, Stohs —125kHs, ther pemiting
Separate convo! of low an high roquanee the
frequency bandwicth contol slows contnuout
‘aration from narrow (0'= 3} t9 wide (= 03)
Ud the lvl conta offers +1208 cntucusly
‘rab range,
“his origina etre canes tone contol care
terior completely eiferore fom te tone
‘onto aphs sen unt new Fig 2, dpiting the
frequeney onto! adjnted at intel of 1/3
fete ech, shows thatthe PTC does cover the
tie auto frequency range, Fi. 2 shows the
fone control aserriie achieve when the
{reaueny bandwith contr (0) i apeatea i
2 inaratinaly enous tat the convention, ere
‘uly avabl tone onto characte can ho
carne — 2
while at fst glance It may ook rather como
fad to operate it, setualy gute sino
‘thanks othe 1/3 oct intra stion of
‘ta frequency made posse by 2 precion sb
erp side volume conta
EXAMPLES OF HOW PARAMETRIC TONE
‘CONTROL (PTC) CAN BE USED
PTC Aosomplihes All that Conventions Tone
‘Control Cireits Can and ch More
De i. 2 shows, PTC's insepandert, continuous
‘contol of thie parameters cantor frequency,
Frequency bandwith and level ~ means I
{ncomplits the ania ange of conto previa
‘tere by the conventions BASS/TREBLE tone
PTC Sharply Cuts Ont the Annoying Nose Head
Whi stoi
for oxampla, peculiar chaetrisies of the
‘arias or teakor Systm uae shoul eu
snoring oie, PTC permits thorough limination
‘of only that annoying frequency. One way of find
ing an slimiating the unwanted frequency i 0
lmphasre tothe grat extant pose han,
by completaly reversing the LEVEL Cont he
‘tect on othr dase reaveneie
Getting the Sound You Want Dring Reconting
shee in profesional meording mons, PTC
‘stows you t "shape the sound os yOu wat,
laheter it mean emphasing vot oF equaling
‘he tonal eharector of she: moses! instrament
beng recordes,
Compensting or Room Azoustics
“The prt soar choraterste ofthe ien
tng room ean havea huge fect on sound quay,
tsoeclaly othe mice requerces. The pat of
the Frequency range nein equation aften
bxromelynaron. PTC offers unvesited contol
ofthe banawith, are for ety of sal
Convenient Suton To Probus With Simple PA
Systems
hen sing mpl PA yrem of he mice amp
to sesker variety, slighty excessive volume oF
oor mie postoning andthe ike ean imoditly
‘ult In mowing. When this happens, PTC can Be
Shad, jatar 2 grahie equalizer fused in roe
Sonal setups, conv the frequency respon oF
the peer systems nd stables ie pant howling
{nd ale a haghan sound ela.
Nolte Raduction Eft, Too
len recording into 0 ape eck st the TONE
Snactor to REC OUT 1 or 2 and use the PTC 10
boos the high raquenies during ecrding. Then
dhring paysoce. se tn TONE Sector to PRE
‘QUT, tuning the LEVEL Control from the ps
foe al the way to the xem end onthe minus
Sic. Thiel eouce he annoying tape hi rng
tapeplaytack,TROUBLE SHOOTING
G6
| No power tnoush POWER sch is ON.
‘No sound although INPUT selector site is ON.
— |
| No sound fom Both speakers, oF ound only
| rom ether Lor speaker.
eases
| Poor bas espns and inferior see imag.
“Saint volume unobainabe though VOLUME
Sufiet volume of MC card unobtainable |
Loud ‘harming ecu dating ecordeudon
| Recrption of amateur or pret sation mixed with
{Loud howling nae when aig VOLUME during
_cord won.
[MC eat dls low sour volume,
“Treble or bas poorly balance
PARAMETRIC TONE CONTROL dow nat work
| Ae power co
[PRE OUT sich t OFF postion.
| Belanee conta not oropery adhe
‘AC powot cout not pluged nto supy socket
Power remain off eis of AC supa tough em
__INPUT selector switch in wrong position
[INPUT pia plusineorecdy inser
or bataen powers. bad
“Adverse conectd pase laity
ower amp. on peat.
“Turntab’s ground cord not connected to amp,'s GND
‘Suc sation leated iy.
‘Speakers and turntable re positioned else,
UC carrie output cord connected to PHONO?
‘PARAMETRIC TONE CONTROL not propery
porte,
TONE NODE wis ocho DEFEAT pao,
FEC OUT ecior wich at OFF posto,
‘Detective connections between controland power L Perlorm eoreet connectors, or aac operations
‘Check ne int ly i cnet pasion,
‘Check nc make ora connteion,
Switch # OFF and edt VOLUNE,
"Set PHONO switch PHONO and MC,
infer
CConeet sound card to GND trina on var)
paral |
Consult with your autoreve presto
lie «proper as Between a ae,
~ ona ito PHONO win and: PHONO
sector teh MC postion "|
|
‘Operate conrecly etarting wo. 8,
“fe doe not work t DEFEAT pon
‘Change over REC OUT slsctor ete szaring 12
‘th rogram source to be eoree,
isl(B-@ _scHemanic DIAGRAM .‘= @ YAMAHA
PEON GAKKI 00, LTO HAMAMATSU JAPAN