Supporting customers with quality results is
always important, so even the smallest detail in a
tile or stone installation can mean the difference
between success and failure. One of the most
common reasons for call backs and customer
complaints is groutimperfections.
Many of these concerns, especially color variation
in the installation and efflorescence on the grout,
can be prevented by using Epoxy Grouts.
However, tile contractors often shy away from
Epoxy.
There's good news, though: with new
technologically-advanced formulas,prepared
by Quartziock , Epoxy grout can be installed
much more easily and with the same
technical benefits and colorfast performance
that Epoxy Grout is knownfor.
BEFORE YOU START
* Ensure tile spacers are removed and tile joints are clean
{rom loosefexcoss coment residues.
* Mako sure that ies are adhered to base material and are
{ully imbedded. This reduces the chance of "sagging" or pin
holes developing during the curing of the Epoxy Grout.
* Always use rubber gloves and eye Protection wile
working
TOOLS
* Epoxy Grout Float
* White Nylon Scrub Pads.
* Cloth towels
* Tile Grout Sponges
* § Gallon Bucket ( Two)
* Liguid Dish washing Soap
OQuarr1=-1QGck Grozr
EST Se
MIXING
1. Mix Quartzlock Epoxy Paste “A” (Base ),&
(Curing Agent) Paste Mixture “B” ina clean pail
2. Mix‘A’ & B" together thoroughly using
margin trowel. (Dri mixing not suggested),
3. Alter mixing or 3-5 minutes the mixture is
ready fr groutng application.
4. Te open time varies from 60 minute to 90
minutes. depending on temperature range of 10
degre to 30 degree Centigrade.
5. Quartzlock 1 kg packing and long open
time is extremely suitable for easy working
in small sections ata time.
TUN
Mey
GROUTING
1. Force epoxy into the joint with epoxy float
‘Apply with pressure to fully fil the joints and its
voids.
2, Remove excess grout withthe epoxy float
held at a 90° angle. Removing excess grout
from the tie during the grouting wil make
clean-up easier.
INITIAL CLEANING
4. After 20 ~30 minutes, prepare to clean the tle}
work.
2. The higher the temperature, the earlier you
should begin cleanup.
3, Prepare a bucket of clean water mixed with
few drops of Dish washing soap solution,
4, Using the sorub pad, scrub the tiled area in a
circular motion, The scrub pad will cut the
remaining residue oft. if necessary,
‘add more water to make scrubbing easier,
“The goal is to remove the epoxy of of the
tile and smooth the joint, making sure they
are full and flush.”
5, Remove the film off the tle with cloth towels.
6. Leave grouted areas alone for 2-3 hours,
eg
eee)
ei)
re
FINAL CLEANING
1. The best time to finish the joints before final
Cure is when the epoxy joints are sof, ike putty.
‘Make sure the joint is not sticky to the touch,
‘Any dirt or surface debris can stick tothe joint
and become permanently imbedded,
2. Inspect the grouted areas for any resin haze,
misled joints, pin holes or receding joint.
3. Go aver the joints again with the same solution of
oo! water moxed with minimal drops of Dish Soap.
CConcenirataon the resin haze eft rom the frst
clean up procedure, This acts as a final finishing of
the joints
ot slg Shit
Bix i