Professional Documents
Culture Documents
Untitled
Untitled
2. If we use lower thickness dice to produce higher thickness product,we will not get the desired thickness product. Thickness will be ups and down from desired thickness. Example:if we use 4 mm dice to produce 8 mm then thickness
will be 7 to 7.5 mm.
3. Labon dana is a design name which is produced from ARONG MH & ARONG ISLAM dice. For making laban dana design products we have to give some extra thickness in dice to get desired thickness.example: To get 3.5 mm
product we provide 3.6 mm.
4. Using the die with dedicated thickness will give us the desired size,thickness and tolerance value.
5. Dies without bit is not suitable to produce higher or lower thickness product Because thickness ups & down problem occur more in these kind of dies.
6. With the help of higher thickness die any kind of lower thickness die product is possible to make, but we have to keep in mind that thickness will vary or thickness will not match completely.
g issue, over cure under cure
Apex Husain Limited
Zamgora, Ashulia, Savar, Dhaka
TOTAL DICE RUBBER SHEET
CODE TOTAL A B C D
SL. No SHEET NAME Size
NO DICE 3mm 3.5mm 4mm 5mm
26 power(small) 12.75"X16.75
Date:-16.07.2022
E F G
Remarks
5.5mm 8mm Without Bit
4 mm dice used to make 3.5 mm product. Spot occurred on 3.5mm
1
product due to this reason.
2 2
Always show thickness difference in any kind of thickness product
12
due to this dice has no bit
2
Need chrome nickle coating.3 dice shows thickness difference
11 010 Plain Hard 26" X 37" 25" X 36" 3 1 1 1 Need chrome nickle coating.3 dice shows thickness difference