Professional Documents
Culture Documents
Wireless
Wireless
which parameter having no effect against underlay coverage and overlay coverage?
A) Rxqual Threshold
-B) TA Threshold
C) Rxqual Hysteresis
D) Rxlevel Threshold
Q2) Soft handover is introduced in the WCDMA system to improve the system
performance. Which of the following statements about the soft handover is
incorrect?
A) Soft handover occupies more system resource than hard handover.
B) If the link destined to the target cell is established before the link destined
to the source cellis interrupted the call "seam"can be avided.
-C) Soft handover is peculiar to the CDMA system and heappends between cells in the
same frequency
D) Soft hadover happends in only the different frquency
Q3) When BCCH and SDCCH share the same channel, which of the following CCCH
configuration mode requires modifying the system information?
A) Two non-combined CCCHs
-B) One combined CCCH
C) One non-combined CCCH
D) Three non-combined CCCHs
Q4) When Run EXP LOG command to export operation log, what is the saving directory
of the exporting file on the main area directory of the OMU?
--A. bam/version_X/ftp/oprator_log/exp_log/
B. bam/version_X/ftp/COLLOGINFO/PFM-LOG/
C. bam/version_X/ftp/COLLOGINFO/OPT-LOG/
D. bam/version_X/ftp/pfm_log/exp_log/
Q6) What is the maximum processing capacity of the DPUe for PS UL+DL data if the
capacity license if configured?
A) 115Mbps
--B) 335Mbps
C) 165Mbps
-D) 800Mbps
Q7) Physical Cell ID is formed by PSS and SSS, and it had a total of () IDs.
A) 512
B) 503
--C) 504
D) 768
Q8) How many RRU (2TX2RX mode) and antenna are required per site for a 3X15MHz and
2T2R configuration?
A) 2 RRU, 2 Antenna
B) 6 RRU, 3 Antenna
-C) 3 RRU, 3 Antenna
D) 1 RRU, 1 Antenna
Q9) Which of the following cause is NOT conidered as call drop in WCDMA?
A) "lu Release Request.png"
B) Uplin Syschronization Failure
C) O&M intervention
-D) User Inactivity
E) Failure in Radio Interface Procedure
Q10) In BSC6900/6910, the maximum storage capacity and storage duration of alarms
logs are restricted to () and () days.
A) 100,000; 60
--B) 150,000; 90
C) 90,000; 30
D) 100,000; 90
Q12) When replacing DPU board, the board needs to be inhibited first before
performing the replacement. Which command is used to checK there is no more user
data is being processed by the board?
--A) DSP CPUUSAGE
B) DSP DSP
C) DSP BRD
D) DSP UDSPRESOURCE
Q13) Which of the following hardware will not cause the VSWR alarm?
A) Antenna
B) Connector between jumper and feeder
--C) UMPT
D) RFU
Q14) The granularity of sub carrier in the frequency domain is () KHz during
scheduling in LTE.
A) 72KHz
--B) 15KHz
C) 200KHz
D) 180KHz
Q16) OFDM subcarriers are overlapping and orthogonal, thus greatly improving the
().
A) Spectral Efficency
B) RB Utilization
C) UE bandwidh
D) System Utilization
Q17) For GSM Phase 2 MS, which of the following parameter settings prohibits the MS
from initiating calls in the cell?
A) CBA = No, CBQ = Yes
B) CBA = Yes, CBQ = Yes
C) CBA(changeback acknowlegement) = No, CBQ(cell bar quality) = No
-D) CBA = Yes, CBQ = No
Q18) In BTS3900 systems, if the external power is 110/220V, which module must be
configured to convert 110/220V AC power into-48V DC power?
A) GATM
-B) PSU
C) DCDU
D) PMU
Q19) When configure SCTPLNK on Iub interface (IP-based), Set signalling link model
to (), Set Application type to ().
A) CLIENT.RANAP(Radio Access Network Application Part)
-B) SERVER.NBAP
C) CLIENT.NBAP(NodeB Application Part)
D) SERVER.RANAP
Q20) How many OVSF codes can be used in WCDMA when SF equals to 128?
-A) 128
B) 256
C) 32
D) 64
Q21) Which of the following RB is used for carrying low priority NAS message?
A) DRB
B) SRB1
--C) SRB2
D) SRB0
Q22) In WCDMA system, the range of spreading factor in the downlink is ().
A) 8 ~ 512
B) 4 ~ 256
--C) 4 ~ 512
D) 8 ~ 256
Q23) How many preamble signatures are used in LTE for each cell?
A) 16
B) 12
C) 1200
--D) 64
Q25) Which of the following board can be added in to BBU if we would like to
increase the supported "Maximum Number UEs in RRC connected Mode"?
A) UMPT
--B) UBBP
C) UTRP
D) UBRI
Q28) Which of the following commands can be used to verify the IPSec transmission?
A) DSP APPCERT
--B) DSP IKEPROPOSAL
C) LST ACLRULE
D) DSP TRUSTCERT
Q29) Which of the following statements will cause the cell setup failure?
-A) The configured cell frequency is out of RRU frequency range
-B) The configured logical cell power at RNC is smaller than RRU/RFU maximum output
power.
C) Number of cells are limited by NodeB licence
-D) NodeB having SCTP link, NCP/CCP failure alarm
Q30) Which of the following can affect the HSDPA Cell throughput?
A) Available NodeB channel element (CE)
B) Number of R99 users
C) Available HS-PDSCH codes
D) Available HS-PDSCH power
Q31) Which types of the Abis interface board can support BTS ring topology?
A) FG2c
B) PEUa
-C) OIUa
D) EIUc
Q32) What are the possible causes of low thorughput at the UE?
-A) High retransmission rate
-B) Round trip time (RTT) is too high
C) RSRP is above -85dBm
-D) UE capability
Q33) What are the possible causes of low thorughput at the UE?
A) High retransmission rate
B) Round trip time (RTT) is too high
C) RSCP of -65dBm with EcNo of 6
D) UE capability
Q34) Which of the following statements are correct about PIMS (Passive
intermodulation) interference?
-A) PIM interference exists when multiple frequency are generated.
--B) Stronger the power of input signal, stronger the power of PIM product
--C) PIM interference is produced by non-linearity of the passive component in the
TX system
-D) If an RF unit is properly connected to the antenna, high-power IM components
will generated due to insufficient PIM suppression degrees of the cables.
Q35) What are the forward error correction (FEC) scheme used by WCDMA channel
coding?
--A) Convolutional Code
--B) Channelization Code
C) Scrambling Code
--D) Turbo Code
Q37) Which of the following command can be used to check the status of signaling
connection on S1 interface?
A) LST SCTPLNK
B) DSP IPPATH
-C) DSP S1INTERFACE
D) LST IPPATH
Q39) Soft handover is introduced in the WCDMA system to improve the system
performace. Which of the following statement about the soft handover is incorrect?
-A) A soft handover is peculiar to the CDMA system and happends between cells in
the same frequency
B) Soft handover occupies more system resources than hard handover.
C) Soft handover happends in only the different frequency.
D) If the link destined to the target cell is established before the link destined
to the source cell is interrupted avoided.
Q40) Which of the following tool can browse the traced messages that are saved
in .tmf format offline?
A) File Manager
B) PUTTY
C) FTP
--D) Traffic recording review tool