=
Sern VT |
Qu.
1
Option A: | to ape
AY bete
Marks: 80
ELEC] POM Sysfem prokediont Surf hgcod
for following questions. AE the Questiony are |
hoose the correct opti
compulsory and carry equal marks
An olator i installed
¢ the relay of CB
[Option Beas substitute for CB. :
[Option C: generally. on one side ofa CB
[Option D7 generally, on both sides ofa Bo = - = =
LE - al
2 Circuit breakers usually operate under
Option A:_| steady short circuit current - a
Option B:_| sub transient state of short circuit current
[_ Option C:_| fransient state of short circuit current
Option D: | Zero sequence current
3. The relay operating speed does not depend upon
Option A:_| The spring tension
Option B:_| The rate of flux built up.
Option C:_| Armature core airgap
Option D:_| Area of the moving sector
a Plug setting of electromagnetic relay can be altered by varying _
Option A: Number of amperes turns
Option B:_| Air gap of magnetic path
Option C:_| Adjustable back stop
Option D:_| Time setting
5. A single phasing relays are used for protection of
‘Option A:_| Single phase motor only
Option B:_| Two phase motor only
Option C:_| Two phase motors running in parallel
Option D:__| Three phase motor only
6 Carrier current protection scheme is normally used for
Option Az_| HV transmission onl
Option B:_| HV cables onl
Option C:_[ HV transmission and cables
Option D:_| LY transmission only 1 5
Z The Overhead ground wires are used to protect a transn :
Option A:_| Line to ground faults
Option B:_| Arcing earths
‘Option C:_ | Voltage surges due to direct lightning stroke
Option D:_ | High-voltage oscillations due to switching |
1|Pageopnion A,
_ Option B:
Option
Option D
——
Option A
Option B:
Option C
“Its operation does not depend upon
h
ction of power
«en for low value of fault current
ar quantities as well
Tit can be ued to compare
The number of pilot wires required for protecting 3 phase transmission lines usin
[Option D:
i0.__| The relay is used for phast hort transmission line,
Option A:_ | Induction type a _|
Option B:_| Reactance 2
‘Option C:_| Impedance.
Option D:_[ Admittance
Q2. _ | Solve any Two Questions out of Three 10 marks each
(20 Marks)
A ‘Draw and explain construction and working of Pantograph Isolators.
= Draw and explain construction, working and operating characteristic of HRC
Fuse.
eC Explain working principle of induction type of relays and its characteristics
Q3. Solve any Two Questions out of Three 10 marks cach
(20 Marks)
A Explain the phenomenon of current chopping and its effect in the circuit breakers.
B Explain Numerical Relay in detail
c Explain phase comparison carrier current protection
Q4. Solve any Two Questions out of Three 10 marks each
(20 Marks)
fn Explain REF protection for altemator. How 100% winding is protected in an
alternator?
B Explain the operation of Harmonic restraint relay.
ic Explain the effect of power swing in distance relay.
d ) J )
2|Page