Professional Documents
Culture Documents
0 of 0 points
Kalimuthu subramanian
Security 0 of 0 points
350552
25 Multiple choice questions on the subjects covered on day one. Select only one answer
from the four options.
ATEX categories have a relationship to which one of the following *0/1
abbreviations when used internationally?
OPL
LFL
EPL
IEC
Correct answer
EPL
If we have European ATEX Categories 1, 2 & 3, which letters are used to *1/1
relate the equipment internationally?
x, y & z.
a, b & c.
D, G & M.
A, B, C.
Which one of the following statements is accurate when talking about *1/1
Intrinsically Safe equipment?
Ex ia is not suitable for a place requiring EPL Ga (category 1G) with gas sub-division
(gas group) IIC
Ex ia is suitable for areas requiring EPL Ga, Gb & Gc (category 1G, 2G & 3G) with
appropriate gas sub divisions (gas groups).
What can we presume about the designed value, when a data plate *1/1
shows no marking for ambient temperature?
An oxygen supply.
An ignition source.
An enclosure.
A fuel supply.
Correct answer
IIB.
IIA.
I.
IIC.
Which of the following would be acceptable/safe for a zone 2 area, *1/1
unless the area classification documents state otherwise?
Gc (3G)
Gb (2G)
Ga (1G)
Dc (3D)
From the following equipment, which is suitable for use in a place *1/1
requiring EPL Gc (Category 3G) where the flammable gas is Acetylene?
Ex ia IIA T6.
Ex nR II T4.
Ex d IIA T6.
Ex d IIB T5.
Which hazardous area can Ex d type of equipment be installed? * 0/1
Correct answer
In the IEC 60079-14 it uses Equipment Protection Levels (EPLs) these are *1/1
now used to relate the equipment to the Zone. If the equipment is marked
Ga where can it be used safely, except where the risk assessment states
otherwise?
Zones 2 only.
The European Union has created many directives over the years. What *1/1
has been one of the purposes of these directives, including ATEX
2014/34/EU (ATEX 95) is :-
To allow different nations around the world to have a greater freedom to develop
their own laws & regulations.
There are a number of temperature classes (T ratings) which are used in *1/1
a flammable gas atmosphere. How may are there?
10.
8.
6.
12.
The maximum temperature an internal surface may reach when in contact with a
flammable gas.
The average temperature, measured at the hottest point on the equipment surface
that dust can come into contact with.
The temperature the surface of the equipment will never go above under normal or
fault conditions.
If a hazardous area has a zone which is described as an area where a *1/1
flammable gas and air mixture is UNLIKELY to be present during normal
operation, but if it does occur, will persist for a short period only?
Zone 1.
Zone 22.
Zone 0.
Zone 2.
Small circles.
The letters Ex are inside the shape of a hexagon followed with a group and
category marking.
The letters IEC Ex are inside the shape of a hexagon then followed with the EPL
marking.
The workers that are exposed to potentially explosive atmospheres and their health
and safety.
Which one of the following markings would represent an ability for the *1/1
equipment to operate in a greater than normal ambient temperature
environment safely?
Ex e II T6 40 degC amb.
Ex e II T4 T55.
Ex e II 55 °C T4.
Ex e II T4 -20°C ≤ Ta ≤ +55°C .
This content is neither created nor endorsed by Google. - Terms of Service - Privacy Policy
Forms