Professional Documents
Culture Documents
This device showsboth the bed number and the source usedto
make the call i.e. call made for staff assist, Emergency, and other
types of call. The input call size starts from 10 inputs to 40 inputs
module control (IMC).
Every type off call will be display at the same time and
continuously.
Connected to the Module Controller.
Dimensions:
730 mm X 110 mm X 50 mm for 3 (Three Colours Display)
500 mm X 110 mm X 50 mm for 2 (Two Colours Display)
270 mm X 110 mm X 50 mm for 1 (One Colours Display)
MODULE MATRIX
Module Controller is a device that receives the data inputted from various type of
call made i.e. patient call, staff assist call, emergency call and toilet call.
This data can then be stored and programmed according to the needs of the
hospital.
The data will then be shown is Digital Display Matrix where information can also
be customized.
Module control consists of one to two db25 pin, whereby each pin
accommodates up to 20 inputs.
It also contains rj485 pin on its' center to send the data it has received.
The device works on 24V D.C. , 5 Ampere
Module Matrix link to IP Alarm Dispatch Module& Display
Attached is the diagram to represent how the Module Controller device is connected to Display Matrix
DOME LED 3 LAMPS
DOME LED
DURES 1 LAMPS
ALARM
Dures Alarm is located at the Nurse Station in every hospital
room. Dures Alarm Call is used to call Security assistance in case
of an uncontrollable emergency occurs in the room. Security will DURES ALARM
Description
The Emergency Call Station is designed for higher priority call
That need the nurse attention most. This cater is placed in bedhead
Patient panel, or in the bathroom where the call source is an urgent
With priority more.
A call is made by pull the pull cord. Whilst the call button is fully
Pressed, all contacs are closed. When pressure on the button is released,
The continuous contacs and the button is fully realeased to original
Position. Yellow led provides visual indication when the system is idle
Position.
Features
Latct button / integral reset call and cancel
Large Surface for fast activation at any point and any angle
Reassurance led provided on an idle and an activated
Robust construction and quality assured manufacturer
Specifications
Dimensions : 117 x 75 x 12 mm
(overal : ( Height x Width x Depth)
Finish : Flame retardant ABS Plastic
Power : 24 Vdc 1a Contacts rated
SUB ANNUNCIATOR
1A
1-6
Description
The Sub Annunciator is installed near the entrance to the inpatient room
and next to the Nurse Presence button. The Sub Annunciator is specifically
designed for the One Way Communication system that is used to help nurses
know which bed is making the call. This button is useful for types of inpatient
rooms that have more than two beds in one room, which usually consists of 3
to 6 beds. Where the Annunciator Panel at the Nurse Station only shows
the patient's room number..
Features
Robust construction for durability and reliability
1 X 24VDC 12A or 1 X 12VDC 1A
Full battery backup
Constant voltage changeover
Self contained battery compartment
Conduit entry access
Specifications
Dimensions : 6.4 x 3.92 x 1.56
Brand : PowerSupply1
Complies with RoHS Directive
Input Frequency : 47-63Hz
Inrush Current : Cold Star, 20A/115V, 20A/230V
Input Leakage Current : <0.7mA/230V
Line Regulation (Full Load) : <± 0.5%
Output Voltage Adj.Range : ± 10%
Output Overload Protection : 110-150%
Output Overload Voltage Protc : 115-150%
Withstand Voltage : I/P-O/P: 3.0KVAC/1min; I/P-F/G: 1.5KVAC/1min; O/P-F/G: 0.5KVAC/1min
Rise Time : 50ms@full load (typical)
Operating temp.& humidity : -10°C to 50°C (14°F-122°F), 20%-93%RH (non-condensing)
Storage temp.& humidity : -20°C to 85°C (-4°F-185°F), 20%-93%RH (non-condensing)
MTBF : 100,000 hours
UL Ref. Number : E258719
EMC Standards : GB9254, EN55022 classB, EN55024, EN61000-3-2,3, EN61000-4-2,3,4,5,6,8,11
Cooling Method : Convection
CHIME PRIORITY MODULE
Chime Priority Module is a module that installed
inside the Panel Box Systems.
Dimention :15,5 x 11 cm
INPUT : 24 Vold DC
Module Relay is a module that installed inside the Panel MODULE RELAY
Box Systems.
Dimention : 5,5 x 3 cm
SMS alarm message text programmable 8 x Alarm Inputs N/C, N/O, State Change
Independent text message for each alarm DC8~15V Input
Independent text message for close or open 3 x Relay Outputs, NC/NO
triggered alarm 4Max. 230VAC, 1A relay
Configuration setup by GSM mobile phone or PC 8 x Alarm Phone Number
Arm/Disarm by GSM mobile phone Power Source: Power Rating
Relay triggered by Alarm or SMS command Send/Receive SMS: Standby Mode
Sound monitoring connecting to microphone Operating Temp: 30 ~ 70˚C ‐45 ~ 85˚C
Alarm Alert Modes – SMS, Phone Dial or Both Dimension:105 x 134 x 29 mm
GSM Network signal strength detection and alert GSM Module:GSM Quad Band
Automatic Health Status report to GSM HP
Automatic power supply voltage level checking
Automatic reprting on low power voltage level
Alert message when analog inputs are higher
or lower than preset values
Reply message verifying the receipt of each
command
PAGER UNIT
EEM ( EVEN MANAGEMENT MODULE )
EEM ( EVEN MANAGEMENT MODULE )
PROJECT SITE LISTING
DKI JAKARTA :
RS Pondok Indah RSPI Prof.Dr.Sulianti Suroso RS Puri Kedoya
RS Intl. MH Thamrin RSUD Budi Asih RSUD Depok Sawangan
RS PGI Cikini RSUD Pasar Rebo RS Polri Kramat
RS Budi Kemuliaan RSUD Cengkareng RSKJ Bina Waluya
RSUP Fatmawati RSIA Yadika Ciputat RS Bumi Serpong Damai
RSUD Al-Kamal RS Permata Ibu Depok RS Islam Pondok Kopi
RSUD Duren Sawit RSB Mulya Cipondoh RS Asri Duren Tiga
RSUD HarumKalimalang Puskesmas Palmerah RS Puri Cinere Kardio.
RSIA ZahirahJagakarsa Puskesmas Grogol Petamburan RS Cipto Mangun Kusumo
RS Dharmajaya Puskesmas Cengkareng RS Royal Taruma
RS Bunda Menteng RS Mata Salemba RS Intl. Puri Indah
RS Husada Mangga Besar RS Mata AINI RS Annisa Tangerang
RS Kanker Dharmais RS Mitra Keluarga Jatinegara RS Adhyaksa Kejaksaan Agung
RS Yadika Ciledug RS Petamburan Jakarta RS Sari Asih Jakarta
RSIA Kemang Jakarta RSIA Tumbuh Kembang Cimangis RS Sari Asih Ciledug
RS Graha Kedoya World Class Hospital RSCM JAKARTA HEART CENTER
NEC (Eye Center) Jakarta RS Sari Asih Ciputat Tangerang RS SUMBER WARAS
RSCM IBU ANAK JAKARTA RS Intl. Bintaro RS Gigi & Mulut YARSI
RS PMC PRIOK JAKARTA RSUD Pademangan RS Buddha Tzu Chi
RS Sari Asih Cipondoh RS Sari Asih Sangiang RSIA Mentari Bojong Nangka
RS Pertamina Jakarta Wisma Atlet RSUD Cempaka Putih
JAWA BARAT :
RS BinaHusada Cibinong RSUD Hasan Sadikin RSB Juliana Bogor
RS Pemda Cibinong RSB Juliana Bogor RSUD Ujung Berung
RS PMI Bogor RSUD Ujung Berung RS Melinda Bandung
RS Azra Bogor RSUD Ciawi RSUD Ciawi
RSIA Prasetya BundaTasik RS Mitra Plumbon Cirebon RS Imanuel– Bandung
RS Mery Cileungsi RS Sumber Waras Cirebon RS Thamrin – Cileungsi
RS Yadika Cibitung RS Arjawinangun Cirebon RSUD Bekasi
RS Atlet Cibubur RS Bersalin AMANDA – Lembang RSUD Cikalong Purwakarta
RS Citra Harapan Bekasi RS ISLAM BKSWI Bandung RSUD Cianjur
RS Gunung Jati Cirebon RS Bedah Plastik Gunung Gelis RSUD Cimacan
RS Panti Abdi Dharma Cirebon RSUD Hasan Sadikin RS Sari Asih Serang
JAWA TENGAH :
RSUP Karyadi Semarang RSI Sultan Agung Semarang RS POLRI Surakarta
RS Dr. Oen Solo Baru RSUD Salatiga RSUD Banyumas
RS Dr.OenKandangSapi RSUD Wonosobo RSUD Ungaran
RSUD Tugurejo RS PantiRapihJogyakarta JogyaInternasional Hospital
RSUD Madiun RS PKU Muh. II WatesJogyakarta RS Univ Gajah Mada Yogyakarta
RS PKU Moch Tegal RS ThamrinPurwokerto RS PKU Solo
RS Ardjowinangun RS ELIZABETH Semarang RS PKU MuhWatesJogyakarta
RS Slawi Tegal RSUD Suradadi Tegal RSUD Cikalong Wetan
RSUD Wates RSUD Klaten