Professional Documents
Culture Documents
Project Name:
Location:
The HBS 300 (347-480V) High Bay Occupancy Sensor Key Features:
provides 360 degrees of occupancy based lighting control in
347/480 VAC, 60Hz high bay open area applications. • 360° coverage with up to 60 ft tangential reach
• Coverage area may be adjusted with plastic lens covers
The sensor performs at a wide range of mounting heights, up that snap to the front of the sensor
to 45 feet. It mounts directly to a high/low bay lighting fixture • 3 pyroelectric detectors with 1416 switching zones
or junction box. The EM1 Extender Module is provides better detection for high bay applications
recommended if the knockout at the end of the fixture is • Automatically adjusts to temperature changes keeping
located greater than 1/2” from the bottom edge of the sensitivity and coverage consistent
fixture. With three highly sensitive pyroelectric detectors • Light level feature allows lighting to remain off during
and a multi-segmented lens, the HBS 300 (347-480V) is daylight regardless of occupancy
able to achieve 1416 switching zones. • User-friendly “teach mode” automatically sets the daylight
level, saving time with commissioning.
Applications • Built-in surge protection with auto-reset
Voltage Passive Infrared Technology 360˚ Coverage Max 60 Ft Fixture or Junction Box 0.2 - 200 fc www.steinel.net
Mounting
HBS 300 (347-480V)
360° High Bay Occupancy Sensor
Wiring Coverage
LC3
10
Typical mounting
40 ft
20
30
40
height is 8 to 45 ft.
50 40 35 ft 35 ft 40 50
22 ft 22 ft
Maximum reach is
22 feet radial and
60 feet tangential.
Coverage may
vary depending on
mounting height
and environmental
conditions.
LC5
High
Time
Low
1 2 3 4
40 ft
20
1010 30 10
Light level
40 ft
2020 40 ft
40 ft
40 20
35 ft 40 50
Time delay setting 3030 30
22 ft
DIP switch 4040 40
ON
3030
ft ft 3030ft ft 35 ft 40 50
2222ft ft
2222
ft ft
Time
High 22 ft
ON Low
Time
1 2 3 4
High
teach mode
Low
1 2 3 4
High
Mounting The HBS 300 (347-480V)
Low is mounted directly to
EM1
EM1 a lighting fixture. The
EM1 Extender Module
is recommended if the
knockout at the end of
the fixture is located
greater than 1/2” from
the bottom edge of the
fixture.
www.steinel.net (800) 852-4343 9051 Lyndale Avenue South, Bloomington, MN 55420 M-04105-1