Professional Documents
Culture Documents
|
HOME APPLIANCES
Installation Instructions
Part No. 9752179
o Injury Hazard
Injury from ranges tipping
could result.
See Installation Instructions.
IMPORTANT:
Read and save
these instructions.
IMPORTANT:
Installer: Leave Installation Instructions with the
homeowner. " (76.2 cm)
Homeowner: Keep Installation Instructions for future
reference. ectric ide-in ange
Save Installation Instructions for local electrical
with self=cleaning
inspector's use.
therrnallconvection oven
Cabinet opening dimensions
25" (63.5 cm) countertop
Before you start...
Read electrical and carpentry
instructions.
The cooktop sides of the slide-in range fit If countertop opening width is greater
over the cutout edge of your countertop. than 30-3/8" (77.2 cm), adjust the 1/4"
If you have a square finish (flat) (0.64 cm) dimension.
countertop and the opening width is 30- Countertop must be level. Place level on
3/8" (77.2 cm), no countertop preparation countertop, first side to side; then front to
is required, back. If countertop is not level, range will Injury Hazard
Formed front-edged countertops must not be level. Oven must be level for To eliminate the risk of burns or fire,
have molded edge shaved flat 1/4" (0,64 satisfactory baking conditions. avoid installing cabinet storage above
cm) from each front corner of opening, the cooking surface. If cabinets are
Tile countertops may need trim cut back already installed, reduce the hazard of
1/4" (0,64 cm) from each front corner reaching over a heated cooking surface
and/or rounded edge flattened. by installing a range hood.The range
hood should extend a minimum of 5
inches out from the bottom front of the
22-6/8" cabinets.
(67.6cm)
cooktop depth_ Reaching over a heated cooking
surface could result in a serious burn
or other personal injury.
width Cooktop sides
64 cm) of range fit
over edges of Note: The metal chassis of the range MUST
30-7/8" countertop be earth-grounded in order for the control
(76.4 cm) opening.
panel to work, If the metal chassis of the
range is not earth-grounded, NO keypads will
,_/J trimmed or
Formed 1/4"
tiled
(0.64
countertop
cm) operate. Check with a qualified electrician if
back at front corners of you are in doubt as to whether the metal
countertop opening. chassis of range is earth-grounded.
Panel A
Tools needed for Now start... Before moving range, slide it onto
cardboard or hardboard.
wrench
other two corners.
Place corners
QT,
spacers
lengthwise on the
safety
measuring tape floor in back of range so corners will support
s outer side edges of range as shown.
Press on front
of storage
drawer and
release to open. Pull drawer open
to first stop position. Lift front of drawer to
Injury Hazard clear white wheels in drawer guides.
Because of the weight and size of the Remove drawer and set it aside on a
range, two or more people are needed protected surface.
to move and safely install it.
Failure to do so could result in
serious injury.
rack
Placein []
[_ Firmly grasp the range and gently
lay it on its back on the cardboard oven. Place level
corners. on rack, first side to side; then front
to back. If range is not level, slide range out
of position and use a
3/8" (95 mm) ratchet to adjust the leveling
-='] base
ull cardboard bottom and shipping
firmly to remove. legs up or down. Then slide range back into
position.
NOTE: Oven must be level for satisfactory
% baking conditions.
Numbers
correspond
to steps.
Panel B
BAKED OTHER
OFF
Panel C
if the ran e does For cleanin and if you need
not operate... maintenance... assistance...
+ Check that the circuit breaker is not If removing the range is necessary for The KitchenAid Consumer Assistance
tripped or the house fuse blown. cleaning or maintenance, disconnect the Center will answer any questions about
+ Check that power supply cord is plugged electrical supply. operating or maintaining your range not
into wall receptacle. If electrical supply is inaccessible, lift the covered in the Installation Instructions. The
range slightly at the front and pull the range call is free.
away from the wall. Pull the range out only
When you call, you will need the range
NOTE: as far as necessary to disconnect the model number and serial number. Both
Refer to Use and Care Guide for electrical supply line.
numbers can be found on the model/serial
operating instructions and cleaning Before moving range, slide it onto rating plate located on the oven frame
instructions. cardboard or hardboard. behind the door.
Remove the range to complete cleaning or KitchenAid Consumer Assistance Center:
maintenance.
English 1-800-461-5681
Move range back into operating position.
Remove drawer. Level the range. French 1-800-461-5703
injury Hazard Reconnect the electrical supply. Make sure
Do Not step, lean or sit on the range, that left rear leveling leg is engaged in the
anti-tip bracket.
if you need
or the drawer or door of the range. []