SAFETY DATA SHEET
Creation Date 10-Dec-2010 Revision Date 24-Dec-2021 Revision Number 7
1. Identification
Product Name Glycine
Cat No. : BP381-1; BP381-5; BP381-10; BP381-25; BP381-500; G45-12; G45-212;
646-1; 646-500; G48-12; 48-212; 648-500
CAS No 56-40.6
‘Synonyms Gly; Aminoacetic acid; Aminoethanoic acid: Gyn-Hydralin
(Crystaline/Granules/Powder/Certfied/USPIEPIBP/JP)
Recommended Use Laboratory chemicals.
Uses advised against Food, crug, pesticide or biocidal product use.
Details of the supplier of the safety data sheet
Company
Fisher Scientific Company
‘One Reagent Lane
Fair Lawn, Nu 07410
Tel: (201) 796-7100
Emergency Telephone Number CHEMTRECG, Inside the USA: 800-424-300
CHEMTREC®, Outside the USA: 001-703-527-3887
2. Hazard(s) identification
Classification under 2012 OSHA Hazard Communication Standard (29 CFR 1910.1200)
[This chemical is not considered hazardous by the 2012 OSHA Hazard Communication Standard (29 CFR 1910.1200)
Label Elements
None req
Hazards not otherwise classified (HNOC)
None identified
Page 1/63. Composition/Information on Ingredients
‘Component CAS No Weight %
Glycine 5640-6, 395.
4. First-aid measures.
Eye Contact Rinse immediately with pleny of water, also under the eyeids, fr at least 15 minutes. Get
medical attention
‘Skin Contact Viash off immediately with plenty of water for at least 15 minutes. Get medical attention
immediately if symptoms occur.
Inhalation Remove to fresh ar. Get medical attention immediately if symptoms occur
Ingestion Clean mouth with water and drink afterwards plenty of water. Get medical attention i
symptoms occur
Most important symptoms and None reasonably foreseeable.
ctfects
Notes to Physician Treat symptomatically
5. Fire-fighting measures
‘Suitable Extinguishing Media Water spray, carbon dioxide (CO2), dry chemical, aleohol-resistant foam,
Unsuitable Extinguishing Media No information available
Flash Point No information available
Method = No information available
Autoignition Temperature Not applicable
Explosion Limits
Upper No data available
Lower No data available
Sensitivity to Mechanical Impact No information avaiable
Sensitivity to Statle Discharge No information avaiable
Spe
‘Thermal decompostion can lead to relesse of
itating gases and vapors.
Hazardous Combustion Products
[Nitrogen oxides (NOx). Carbon monoxide (CO). Carbon dioxide (CO:).
Protective Equipment and Precautions for Firefighters
{As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full
protective gear.
NEPA
Health Flammability Instability Physical hazards
0 1 1 NA
6. Accidental release measures
Personal Precautions Use personal protective equipment as required. Ensure adequate ventiation. Avoid dust
formation,
Environmental Precautions ‘Should not be released into the environment.
‘Methods for Containment and Clean Swveep up and shovel into suitable containers for disposal. Avoid dust formation.
Page 2/6up
7. Handling and storage
fandling Wear personal protective equipmenviace protection. Ensure adequate venation. Avoid
Contact with skin, eyes or cothing, Avoid ingestion and inhalation. Avoid dust formation.
Storage. Koop container tightly closed in a dry and well-ventilated place. Incompatbe Material.
Bases, Oxidizing agent
8. Exposure controls / personal protection
Exposure Guidelines This product does not contain ay known or suspected reproductive hazards
Engineering Measures
Personal Protective Equipment
Eyelface Protection
Skin and body protection
Respiratory Protection
None under normal use conditions.
\Wear appropriate protective eyeglasses or chemical safety goggles as described by
OSHA's eye and face protection regulations in 29 CFR 1910.133 or European Standard
ENt66.
\Wear appropriate protective gloves and clothing to provent skin exposure.
'No protective equipment is needed under normal use conditions.
Hygiene Measures Handle in accordance with good industrial hygiene and safety practice
9. Physical and chemical properties
Physical State Powcer Soi
Appearance White
dor Odoriess
(Odor Threshold
pH
‘Melting PoinuRange
Boiling PoinRange
Flash Point
Evaporation Rate
Flammability (solid,gas)
Flammability or explosive limits
Upper
Lower
Vapor Pressure
No information available
59-64 @ 20°C 5% aq.solution
233 °C / 451.4 °F
No information available
No information available
Not applicable
No information available
No data available
No data available
No information available
Vapor Density Not applicable
Specific Gravity 1.595
Solubility, Soluble in water
Partition coefficient; n-octanolwater No data available
Autoignition Temperature Not applicable
Decomposition Temperature No information available
Viscosity Not applicable
Molecular Formula C2H5NO2
‘Molecular Ws 75.07
10. Stability and reactivity
Reactive Hazard
None known, based on information available
Page 3/6Glycine
Stability Moisture sensitive.
Conditions to Avoid Excess heat, Incompatible products. Exposure to moist air or water. Avoid dust formation.
Incompatible Materials Bases, Oxidizing agent
Hazardous Decomposition Products Nitrogen oxides (NOx), Carbon monoxide (CO), Carbon dioxide (CO:)
Hazardous Polymerization No information available,
Hazardous Reactions No information available,
111. Toxicological information
Acute Toxicity
Product Information
‘Component information
‘Component L050 Oral L050 Dermal LCSD inkalation
‘Giyine TOSO= 7380 mokg (Rat) NoTisieg ‘Notisted
Toxicologically Synergi No information available
Products
chronic effects from short and lon:
Irritation No information available
No information available
Carcinogenicity The table below indicates whether each agency has listed any ingredient as a carcinogen
‘Component CAS No TARC NTP AGG ‘OSHA Mexico
Giyne: 56406 iat ited Tat iso Rot sted Tot isted Rot isted
‘Mutagenic Effects No information available
Reproductive Effects No information available,
Developmental Effects No information available.
Teratogenicity No information available.
‘STOT- single exposure None known
‘STOT - repeated exposure None known
No information available
‘Symptoms /effects,both acute and No information available
delayed
Endoctine Disruptor Information No information available
Other Adverse Effects The toxicological properties have not been fully investigated.
12. Ecological information
Ecotoxicity
‘Component Freshwater Algae Freshwater Fish Wicrorox. Water Fea
‘ayone Notisted TEs0:> 1000 mai, 96h Not ised ‘Not ised
state (Oryzias lato)
Page 4/6Glycine
Revi
Persistence and Degradability
Bioaccumulation Accumulation
Mobility
‘Soluble in water Persistence is unikely based on information available,
No information available,
Will ikely be mobile in the environment due to its water solubility.
13. Disposal considerations.
Waste Disposal Methods
‘Chemical waste generators must determine whether a discarded chemical is classified as @
hazardous waste. US EPA guidelines for the classification determination are lised in 40,
CFR Part 261.3. Additionally, waste generators must consult state and local hazardous
waste regulations to ensure complete and accurate classification,
14, Transport Information
DoT. ‘Not regulated
TDG Not regulates
TA. Not regulates
IMDGAMO. Not regulates
15, Regulatory information
United States of America Inventory
Tampon CASK 15 SER venir nateaon | TSR EPR Reguatary
ama EE x see ae
Legend
TSCA US EPA (TSCA) -Tove Subsances Coto! et (0 GR Pa 710)
eRottsted
‘TP - Indicates a substance that is the subject of @ proposed TSCA Section 4 test re
TSCA 12(b) - Notices of Export
International Inventor
Not applicable
(Canada (OSLINDSL), Europe (EINECS/ELINCSINLP), Philippines (PICCS), Japan (ENCS), Japan (ISHL), Australia (AICS), China (IECSO), Korea
(Ke CL)
‘Component
‘CASNo[ DSL| NOSL_[ EINECS | PIccS [ ECS | ISHL_[_AICS _[TECSC | —KECL
Gycne
56-4056 x = fpowzre22p_x |x [x] x | x [RE ort6
KECL -NIER umber or KE number (htpncs rer. go h/en/main do)
‘ederal Regula
SARA 313,
SARA 311/312 Hazard Categ
CWA (Clean Wat
Act)
Clean Air Act
‘OSHA - Occupational Safety and
Health Administration
CERCLA
Not applicable
See section 2 for more information
Not applicable
Not applicable
Not applicable
Not applicable
Page 5/6Glycine
California Proposition 65 This product does not contain any Proposition 65 chemicals.
US. State Right-to-Know Not applicable
Regulations
U.S. Department of Transportation
Reportable Quantity (RQ): N
DOT Marine Pollutant N
BOT Severe Marine Pollutant N
U.S. Department of Homeland This product does not contain any DHS chemicals
‘Security
ther International Regulations
Mexico - Grade No information available
Authorisation/Restrictions according to EU REACH
‘Safety, health and environmental regulations/legislation specific for the substance or mixture
‘Component GAS No ‘OECDHPY | Porsistent Organic | Ozone Depletion | Restiction of
Pollutant Potential, Hazardous
Substances (ROHS)
Gane Eo Teed Not applicable —[ — Net appieabie [Not appicabie
‘Component CAS No Seveso li Directive | Seveso Il Direcive | Rotterdam | Basal Convention
(@oiziweC)-" | (2orz/twec)- | Convention (Pic) | (Hazardous Waste)
lauaiitying Quantities|Qualifying Quantities}
for Major Accident | for Safety Report
Notification Requirements
Cane TE TNot applicable | Not appicable | Not appicabie | Net appieabie
16. Other information
Prepared By Regulatory Affairs
Thermo Fisher Scientific
Email: EMSDS. RA@thermofisher.com
Creation Date 10-Dec-2010
Revision Date 24-Dec-2021
Print Dat 24-Dec-2021
Revision Summary This document has been updated to comply with the US OSHA HazCom 2012 Standard
replacing the current legislation under 28 CFR 1910.1200 to align with the Globally
Harmonized System of Classification and Labeling of Chemicals (GHS).
Disclaimer
The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the
date of its publication. The information given is designed only as a guidance for safe handling,
transportation, disposal and release and is not to be considered a warranty or quality specification. The i
relates only to the specific material designated and may not be valid for such material used in combination with any other
‘materials or in any process, unless specified in the text
End of SDS
Page 6/6