Professional Documents
Culture Documents
Datasheet
Datasheet
7V 250mAh Rechargeable in
stock now. Starting at $0.034. This EEMB part is fully warrantied and traceable.
00000005981LF-000
1 INCH-D-MV
EOS
AllPower
Sensors
Buy Now
Buy Now
Give us a call
1-855-837-4225 1-415-281-3866
International: 1-415-281-3866
1-555-555-5555
Arrow
Arrow Electronics,
Electronics, Inc
Verical Division
9201 East Dry Creek Road
P.O. Box 740970
Centennial,
Los Angeles, CO 80112
CA 90074-0970
This coversheet was created by Verical, a division of Arrow Electronics, Inc. (“Verical”). The attached document was created by the part supplier,
not Verical, and is provided strictly 'as is.' Verical, its subsidiaries, affiliates, employees, and agents make no representations or warranties
regarding the attached document and disclaim any liability for the consequences of relying on the information therein. All referenced brands,
product names, service names, and trademarks are the property of their respective owners.
Signed Original On File
w.allsensors.com
Signed Original On F
Millivolt Output Pressure Sensors
R
Low Pressure (0.5” H2O to 30 “ H2O) Sensors
R
www.allsensors.com
Features
all sensors
Applications
www.allsensors.com
Signed Original On File
• Medical Instrumentation
General Description
The Millivolt Output pressure sensor is based upon a proprietary technology to reduce all output offset or common mode errors.
e www.allsensors.com
R
This model provides a calibrated millivolt output with superior output offset characteristics. Output offset errors due to change in
R
www.allsensors.com
temperature, stability to warm-up, stability to long time period, and position sensitivity are all significantly reduced when compared
to conventional compensation methods. In addition the sensor utilizes a silicon, micromachined, stress concentration enhanced
structure to provide a very linear output to measured pressure.
These calibrated and temperature compensated sensors give an accurate and stable output over a wide temperature range. This
The output of the device is ratiometric to the supply voltage and operation from any D.C. supply voltage up to +16 V is acceptable.
www.allsensors.com
Signed Original On File
R
a 16035 Vineyard Blvd. Morgan Hill, CA 95037
R
www.allsensors.com
-Vout +Vout
Pin 1: N/C
Pin 2: +V supply
Pin 3: +Voutput
-Vs upply
Pin 4: -Vsupply
Input Resittance 4.5 k ohm
Pin 5: -Voutput
Output Resistance 1.5 k ohm
www.allsensors.com
Original On File
Pin 6: N/C
Signed Original O
Approvals
MKT DATE MFG DATE ENG DATE QA DATE
R
Pressure Sensor Ratings Environmental Specifications
R
www.allsensors.com
(non condensing)
Standard Pressure Ranges
www.allsensors.com
Signed Original On File
Part Number Operating Pressure Nominal Span Proof Pressure Burst Pressure
R
R
www.allsensors.com
Signed Original On File
R
R
www.allsensors.com
Signed Original O
R
Performance Characteristics for 2 INCH-D-MV
R
www.allsensors.com
all sensors
Offset Position Sensitivity (1g) -- -- ±50 uV
www.allsensors.com
Signed Original On File
e www.allsensors.com
R
Performance Characteristics for 5 INCH-D-MV
R
www.allsensors.com
www.allsensors.com
Offset Long Term Drift (one year) -- -- ±100 uV
Signed Original On File
R
a 16035 Vineyard Blvd. Morgan Hill, CA 95037
R
Signed Original O
R
Performance Characteristics for 20 INCH-D-MV
R
www.allsensors.com
www.allsensors.com
Offset Long Term Drift (one year) -- -- ±100 uV
Signed Original On File
R
Performance Characteristics for 30 INCH-D-MV
R
www.allsensors.com
www.allsensors.com
Signed Original On File
R
R
www.allsensors.com
Specification Notes
NOTE 1: ALL PARAMETERS ARE MEASURED AT 12.0 VOLT EXCITATION, FOR THE NOMINAL FULL SCALE PRESSURE AND ROOM TEMPERATURE UNLESS
OTHERWISE SPECIFIED. PRESSURE MEASUREMENTS ARE WITH POSITIVE PRESSURE APPLIED TO PORT B.
NOTE 2: SHIFT IS RELATIVE TO 25°C.
NOTE 3: SHIFT IS WITHIN THE FIRST HOUR OF EXCITATION APPLIED TO THE DEVICE.
NOTE 4: MEASURED AT ONE-HALF FULL SCALE RATED PRESSURE USING BEST STRAIGHT LINE CURVE FIT.
NOTE 5: THE VOLTAGE ADDED TO THE OFFSET VOLTAGE AT FULL SCALE PRESSURE.
Pressure Response: for any pressure applied the response time to get to 90% of pressure applied is typically less
Signed Original O
All Sensors reserves the right to make changes to any products herein. All Sensors does not assume any liability arising out of the application or use of
any product or circuit described herein, neither does it convey any license under its patent rights nor the rights of others.