Professional Documents
Culture Documents
S508
TM
Specifications
Power Supply Board PFC-8000
No. Item Specification fire alarm system
1 Input at full load 228VA
2 Frequency 50/60Hz
ANALOG ADDRESSABLE
3 Output voltage 24VDC
4 Output full load current 6.5A
Specifications
PCA-2440X S508 (Main Control Unit)
No. Item Specification
1 Maximum 24VDC current rating 202mA
2 Maximum 24VDC alarm current rating 322mA
3 Ambient operating temperature 0°C to 49°C (32°F to 120°F)
NOTICE 4 Dry contact output ratings 2A at 30VDC (resistive)
・These instructions do not purport to cover all the details or variations in the equipment described, not provide for every possible contingency 5 24VDC output wiring style NFPA Style Y or Z
to be met in connection with installation, operation and maintenance. 1.5A per output × 4 outputs, 3.0A per output × 2 outputs,
6 24VDC maximum output current
・Specifications are subject to change without notice. Contact Nohmi before relying on above specifications. 3.0A per output × 1, 1.5A per output × 2 outputs
・Actual performance is based on proper application of the product by a qualified professional. 7 Applicable SLC wiring style NFPA Class A (Style 6 & 7), Class B (Style 4)
・Should further information be desired or should particular problems arise, which are not covered sufficiently for the purchaser’s purpose, 8 Maximum no. of address per SLC 127 addresses
the matter should be referred to Nohmi or a distributor in your region. 9 Maximum SLC resistance 50Ω
10 Maximum SLC capacitance 0.5 µF
11 Remote annunciator bus wiring style NFPA Style 4
12 Maximum remote annunciator number 31 units
13 Maximum circuit resistance of RA bus 1.2km (4,000 feet), 40Ω, 0.4µF
Contact 14 Remote annunciator bus connection RS-485
15 Serial output connection RS-232C
16 PCCP connection RS-232C
• Head Office: 4-7-3 Kudan-Minami, Chiyoda-ku, Tokyo 17 ALE connection RS-485
18 Dimensions 220mm (8.66inches) (H) × 320mm (12.60inches) (W) × 43mm (1.69inches) (D)
102-8277, Japan
• Phone: (81) 3 - 3265 - 0231
• F A X: (81) 3 - 3265 - 5348
URL http://www.nohmi.co.jp/english/
SCI
S+1S-1S+2S-2
module S+
S- S+
C1
NC1
Systems Normal S- NO2
FRRU004-MCM C2
FQIU004-SCI
S+1S-1S+2S-2
NC2
LED
ALM000 SUP000 TBL000 FQIU004-
S+1S-1S+2S-2
FQIU004- SCI FRRU004-TRM4
PCA-2440X S508 SCI
AC POWER ALARM PRE/DISCHARGE GENERAL ALARM ACK JP1
S+ B+ JP1
SUPERVISORY TROUBLE GROUND FAULT BATTERY TROUBLE SIGNAL SILENCE S- B-
S+
24+ A+
1 2 3
S- OUT+
LAMP SIGNAL 24- A-
Addressable
24+ OUT-
TEST SILENCE S+1S-1S+2S-2
ABC DEF GHI Analog 24-
S+1S-1S+2S-2
detector module LED
4 5 6 Addressable FQIU004- LED
S+1S-1S+2S-2
JKL MNO PQR ACK SYSTEM FQIU004- FRRU004-CIZM4
INFO RESET module SCI SCI FRRU004-MOM4
7 8 9
STU VWX YZ
FQIU004-SCI
GENERAL FIRE
ESC 0 ENTER ALARM DRILL C1
NO1
S+ Z1
S- C2
NO2
Z2
LED
FQIU004-
S+1S-1S+2S-2
CONTACT1 CONTACT2 CONTACT1 TROUBLE
Battery Battery SCI FRRU004-DCM4
NAC3 NAC4
B+ B- A+ A- B+ B- A+ A- NC NC COM NO NC COM NO NC COM NO NC COM NO S+1S-1S+2S-2
Analog Addressable
TB2 → detector Addressable module
module Analog detector
S+
C
NO
TB1 →
S-
Z
AC POWER
AC120V/AC230V,50/60Hz LED
B+
NAC1
B- A+ A- B+
NAC2
B- A+ A- S+1
LOOP
S-1 S+2 S-2
AuxiliaryPower ANNUNCIATOR
TxD
PRINTER
RxD CTS RTS GND
BATTERY H N G
+ - + - + -
S+1S-1S+2S-2 FRRU004-SCM4
Signal Line Circuit AC POWER
TB1 These SCIs shall be
120VAC/230VAC50/60Hz S+1S-1S+2S-2 S+1S-1S+2S-2
installed within 20
Wiring in NFPA Style 4 FQIU004-
SCI S+1 S-1 S+2 S-2
FQIU004-
SCI feets from TB1 of
TB1 PCA-2440X S508
NAC3 NAC4 NC CONTACT1 CONTACT2 CONTACT1 TROUBLE
B+ B- A+ A- B+ B- A+ A- NC COM NO NC COM NO NC COM NO NC COM NO
CONTACT 1 - 3 CONTACT 1 - 3
NC COM NO NC COM NO
31.8mm
28.6mm
CONTACT 1 - 3 CONTACT 1 - 3
NC COM NO NC COM NO
TB1 Note: No end of line resistor
31.8mm or is required for style Z wiring.
(1.25") TB2 TB2 TB2
15.0mm
(0.59")
(2.00")
(2.00")
Releasing Device
50.8mm
(2.00")
615.98mm
578.9mm
TB1
(24.25")
(24.25")
(22.79")
or
+
203.5mm
DC24V
(8.01")
-
140.0mm
TB2
(5.51")
G
NAC 1-4
RS485 B+ B- A+ A-
-+
Wiring of wet contact output with
50.8mm
50.8mm
(2.00")
(2.00")
releasing device
FIRU004-LCD
TB1
TB1 PCA-2440X
24VDC(+) S508
+
31.8mm 376.9mm DC24V PRINTER
(1.25")
-
(14.84") 24VDC(-)
TxD RxD RTS CTS GND
G
28.6mm Power Limited RS- 485 RS485
+
(1.12")
-
P22.5/28.5mm(0.886/1.125") double-knockout 2 3 7 5
*Note: Connect GND line, only in the case of
TB1
transmission can not successfully.
P22.3mm(0.875") knockout Keltron’ s Printer
DS25S Connector
ANNUNCIATOR PRINTER
+ - TxD RxD RTS CTS GND
368.3mm
(14.50") Wiring of RS-485 remote annunciator bus Wiring of RS232C