Professional Documents
Culture Documents
How To Install and How To Use WEB LCT Co
How To Install and How To Use WEB LCT Co
Index
Select a different folder, or keep the default one, and push Next>
To close the window and run the application push Finish. The software is installed and
can be loaded automatically any system start up (if the relevant box is marked): a
WebLctConsole tray icon will appear in tray zone.
In case of
- Internet Explorer: double click on Install Flash Player 9 ActiveX.msi, click Install
and when installation is completed, push Finish
- FireFox: double click on Install Flash Player 9 plugin.msi, click Install and when
installation is completed, push Finish
If desired operation is Repair or Remove, select the proper option
4. USB driver Installation
WEB LCT is the application you need to access ALC plus management.
Through an internet browser, a LAN and the IP address of its Ethernet port, the ALC plus can be
managed and configured.
When LAN is not present a USB serial connection must be used.
WEB LCT console is the application that establishes this USB connection and opens the internet
browser window necessary to manage it.
6. Select Connect using direct serial cable and push Settings see fig.3
7. Select the USB connection: Modem – Erio Connection USB ModemDirect , check if the
dialling number is 123 and push Configure
8. The Modem Configuration window appears (see Fig.4)
FIG. 4 – Configuration of USB Connection
9. All options must be not marked and the Max bit rate must be 230400 bps. Push OK to
close the Modem Configuration window
10. Push OK to close the Modem selection window
11. Pusk OK to close Options window. The USB connection is configured properly
12. Push Connect to start the connection towards the ALC plus. The browser will show the
WebLct window (see Fig.5)