Professional Documents
Culture Documents
Ea 445-En
Ea 445-En
LOCTITE® EA 445
Known as LOCTITE® Fixmaster® Fast Cure Epoxy Mixercups
January-2015
NOTE: LOCTITE® EA 445 are not recommended for Flexural strength , ASTM D790 N/mm² 55
polyethylene and polypropylene. (psi) (7,960)
Flexural modulus , ASTM D790 N/mm² 5,410
TYPICAL PROPERTIES OF UNCURED MATERIAL (psi) (784,600)
Resin:
Specific Gravity, g/cm³ 1.68 Compressive Strength, ISO 604 N/mm² 91
(psi) (13,260)
Flash Point - See SDS Compressive Modulus, ISO 604 N/mm² 5,425
(psi) (786,300)
Hardener: Tensile Strength, ISO 527-2 N/mm² 26.3
Specific Gravity, g/cm³ 1.4 (psi) (3,815)
Flash Point - See SDS Tensile Modulus, ISO 527-2 N/mm² 7,600
(psi) (1,102,320)
TYPICAL PERFORMANCE OF CURED MATERIAL For safe handling information on this product, consult the
Shear Strength Safety Data Sheet (SDS).
Lap Shear Strength, ISO 4587:
Grit Blasted Mild Steel (GBMS) N/mm² 13.5
(psi) (1,955)
120 °C
150 95 °C 180
°C Technical Tips for Working With Epoxies
Working time and cure depends on temperature and mass:
100 65 °C ● The higher the temperature, the faster the cure.
● The larger the mass of material, the faster the cure.
To speed the cure of epoxies at low temperatures:
50 ● Store epoxy at room temperature.
● Pre-heat repair surface until warm to the touch.
0 To slow the cure of epoxies at high temperatures:
0 250 500 750 1000 ● Mix epoxy in small masses to prevent rapid curing.
Time, hours
● Cool resin/hardener component(s).
Note:
The information provided in this Technical Data Sheet (TDS) including the
recommendations for use and application of the product are based on our
knowledge and experience of the product as at the date of this TDS. The product
can have a variety of different applications as well as differing application and
working conditions in your environment that are beyond our control. Henkel is,
therefore, not liable for the suitability of our product for the production processes
and conditions in respect of which you use them, as well as the intended
applications and results. We strongly recommend that you carry out your own
prior trials to confirm such suitability of our product.
Any liability in respect of the information in the Technical Data Sheet or any other
written or oral recommendation(s) regarding the concerned product is excluded,
except if otherwise explicitly agreed and except in relation to death or personal
injury caused by our negligence and any liability under any applicable mandatory
product liability law.