TRVX 100 7 / 1 - C / A3 - M / Z Pompetravaini construction
Liquid ring vacuum pump
Construction type (impeller type)
V = single stage pump with valves and not direct shaft (own shaft) M = single stage pump with valves and direct shaft (motor shaft)
Suction/discharge port plates Laser cut from
AISI 304 or AISI 316 sheet
Suction and discharge flange size (mm)
Project impeller nominal dimension within the same flange dimension
range of pumps (the higher the numbers the bigger the impeller and the more capacity)
Constructive project number
Shaft seal type:
C = Nr. 1 o 2 mechanical seal (single or bilateral) C2 = Nr. 2 double back to back mechanical seals CS = Nr. 2 double tandem mechanical seals
Construction materials (AISI 304 suction/discharge port plates standard)
GH = cast iron construction, AISI 420 steel shaft, bronze impeller and AISI 304 steel plate F = cast iron construction, AISI 420 steel shaft, cast iron impeller and AISI 304 steel plate RA = cast iron construction, AISI 316 steel shaft and impeller and AISI 304 steel plate RX = cast iron construction, AISI 420 steel shaft, AISI 304 steel impeller and plate RZ = cast iron construction, AISI 420 steel shaft, AISI 316 steel impeller and AISI 304 steel plate A3 = AISI 316 stainless steel construction and AISI 316 plate R1 = RA construction with AISI 316 steel impeller casing and plate R4 = cast iron casing, AISI 316 steel impeller, port plate, casing cover and shaft (TRVX 255 only) R6 = AISI 316 steel parts and cast iron bearing housing (TRVX 255 only) R7 = RA construction with SAF 2205 shaft and parts that come in contact with pumped liquid
Close-coupled construction (on request) - TRVX construction only
M = Close-coupled construction for electric motor according to UNEL-MEC standard N = Close-coupled construction for electric motor according to NEMA standard
Special constructions Z = special features on request
Sexton's Pocket-Book for Boiler-Makers and Steam Users: Comprising a Variety of Useful Information for Employer and Workmen, Government Inspectors, Board of Trade Surveyors, Engineers in Charge of Works and Ships, Foreman of Manufactories, and the General Steam-Using Public
Triangulation - Applied to Sheet Metal Pattern Cutting - A Comprehensive Treatise for Cutters, Draftsmen, Foremen and Students: Progressing from the Simplest Phases of the Subject to the Most Complex Problems Employed in the Development of Sheet Metal Patterns with Practical Solutions of Numerous Problems of Frequent Occurrence in Sheet Metal Shops