5.6.3 SPECIAL LUBRICANTS
P80 Rubber Lubricant 2251651
[My Lube Dry Bonded Spray Lubricant 9339834
5.6.4 COMMON PART NUMBERS
‘COMPONENT TSC HTSC-BT
Traci Motor and inion A “TER =n
Wheel ours To6t2677
Ae iad Gage ENTS | Te Ane OD
Support Bearing Hoong aOUTSs68
Speer aoe
=e ro
Gers per € Lowe) ara RnNTEASE
ural Beings “0077569 “sae
Dearing Adar Aas OTTO “oma
Bearing Adair Bon Pe 05
Sander Bracket oR ame
Sing ~ Single Co eT o090atr
Spring Pad Set 0025675
Spring Pad Poyretane aT
Primary Tato ea
Damper Primary Vania oO Tao
Toston Rod Pray “719
Bogie ame As aOU7a880 ae
Bake Rigtng 0080256
Bake Cylinder aononen0s0268
Brake Ping rE
Pi As ars
Carboy Rod wih “ora?
Bushings
Rubber Spring Asm ~ Sx “aaa | sonnei
Secondary Ine Rs eaCa008NGE5
Primary Damper Brcko z00p9571066581 | s0OR99SCORNDD
‘Yas Dap = Sesndary “ams 090092
Ti Nose Link sar
TM Air Dt on
Where diferent
HTSC/HTSC-BI Trucks 90 utwoz3.4.6 SECONDARY YAW DAMPER APPLICATION
The yaw dampers should be installed with the right side up (as marked on the yaw
damper), with the smaller end of the yaw dampers attached to the bogie at the yaw
‘damper bracket, as shown in the appropriate bogie assembly print
3.5 BOGIE APPLICATION TO LOCOMOTIVE
1. Install nylon-alloy wear cylinder halves in. carbody pivot on bogie. Place
cylinder halves so that separation line faces sides of bogie. Ensure carbody pivot
has been cleaned of dirt and corrosion. Spray pivot with filly lube.
2. Roll rebuilt bogie assembly under raised locomotive, or if using a drop table,
install bogie on table and raise bogie up under locomotive. Ensure contact areas,
are cleaned of dirt and corrosion.
3. Align carbody pivot pin with pivot and secondary rubber spring pins with
appropriate holes in carbody underframe, Figure 64, and Figure 65. Note that the
‘atbody pivot will meet the bogie before the secondary spring pins meet the
‘eatbody. Anti-scize lubricant is permissible on the pins only of the secondary
rubber springs. The flat plate surface must remain dry for friction purposes.
Figure 64 Typical Carbody Pivot Pin Installation (HTCR Shown)
HTSC/HTSC-B1 Trucks "4 1102