Professional Documents
Culture Documents
CLIENT: Date
Page 1/2
DRILLING/INJECTION
1.0 Drilling of hole for installing of packer shall be done using mechanical drill unit with drill bit of
16mm diameter. Depth of the holes range from 1000 mm and up to 2500 mm from the surface.
2.0 Interval for injection hole shall be 1000 mm and up from 2500mm from centre to centre.
4.0 Depth shall be inspected by measuring the penetration of drill bit and length of steel tube.
5.0 Installation of 16 mm diameter and 100 mm length packers and mixing head with 1200mm steel
tube.
6.0 Installation of packer shall incorporate the mechanical packer for resin to flow in horizontal and
vertical directions
7.0 Point injection of AK2020 must be injected at surrounding area of sink hole interval of 2500mm to
create the barrier and set properly
8.0 Area of sink hole injected after surrounding area is already filling with AK2020.
9.0 Hydraulic or pneumatic pumping unit must be used for densification and void filling.
10.0 Injection of AK2020 shall be started after all connection securely tighten and continuously pumped
up to 800 PSI of pressure.
12.0 Patching the top layer holes with special coating / cement
METHOD OF STATEMENT Document number
CLIENT: Date
Page 2/2
WORKING HOUR
This work shall start at 9.00 a.m. and finish at 5.00 p.m. for day shift and start at 10.00 p.m. and finish at 5.00
a.m. for night shift. However the working hour and day will base on the regulation and suitability.
LIST OF EQUIPMENT
WHERE TO USE
For waterproofing
• Metal and concrete roofs;
• Balconies and terraces;
• Guttering and downpipes;
• Cupolas and curved roofs.
AK2020
may be applied on:
• Ceramic and stone dressings;
• Cementitious screeds and screeds made using special binders
• Concrete;
• Metal sheet roofing
TECHNICAL CHARACTERISTICS
Ready-to-use, liquid-applied waterproofing membrane for external applications made from synthetic resins
dispersed in water.
Resistant to all atmospheric conditions and UV rays, and provides long-lasting protection for the substrate.
Easy to apply using a long-haired roller or brush on horizontal, sloping and vertical surfaces. Once dry,
AK2020 forms a strong, seamless, flexible and tack-free waterproofing membrane suitable for occasional
light foot traffic.
Compatible with normal dynamic expansion and contraction stresses caused by temperature variations
and vibrations.
Substrate Preparation
All substrates, whether they are new or old, must be solid, clean, dry and free
of all traces of oil, grease, old paint, rust, mould and any other material which
could compromise the bond. All sharp protrusions must be ground smooth.
Concrete and cement substrates must be solid and dry with no rising damp.
Any loose parts must be removed. Any hollows in the surface must be repaired
with the ALGrout range of mortars and allowed to cure fully. All wax, water-
repellent treatments, etc, must be removed with a suitable detergent and/or by
sanding.
CONSUMPTION
1kg coverage = 35 – 40 sqft
PACKAGING
Available in 20, 25 and 225 kg pails.
.
TECHNICAL DATA
APPEARANCE BROWN
FLASHPOINT 210O C
VOLATILITY NON-VOLATILE
COMPRESSIVE STRENGTH 5.0N/mm2
SHELF LIFE (UNOPENED) 12 MONTHS
COMPARISON AK2020 WITH PENTENS T200
(WATERPROOFING WORKS)
AK2020 PENTENS FLESEAL
T200
1KG coverage 35-40sqft 1.5kg coverage 16sqft
RM200/sqft with warranty 3years** (labor included) (special mix AK2020 +other chemical)