Professional Documents
Culture Documents
Caterpillar 3512-B
Caterpillar 3512-B
Electric Power
Specifications
Generator Set Specifications
Minimum Rating 1230 ekW
Maximum Rating 1500 ekW
Emissions/Fuel Strategy Low Fuel, Low Emissions
Voltage 380 to 13800 Volts
Frequency 60 Hz
Speed 1800 rpm
Duty Cycle Standby, Mission Critical, Prime, Continuous
Engine Specifications
Engine Model 3512B TA, V-12, 4-Stroke Water-Cooled Diesel
Bore 170 mm 6.69 in
Stroke 190 mm 7.48 in
Displacement 58.56 l 3573.55 in
Compression Ratio 14.0:1 Std 15.5:1 HD
Aspiration TA
Fuel System Electronic Unit Injection
Governor Type Adem
Standard Equipment
Air Inlet System
Air cleaner; single element canister type with service indicator
Exhaust System
Exhaust flange outlet
Dry Exhaust Manifold
Flanged faced outlet(s)
Generator
IP23 Protection
SS-11425339-1000028914-130 SS Page 2 of 12
MSS-EPG-1000028914-155.pdf © 2021 Caterpillar All Rights Reserved Page: M-2 of M-9
3512B Diesel Generator Set
Electric Power
SS-11425339-1000028914-130 SS Page 4 of 12
MSS-EPG-1000028914-155.pdf © 2021 Caterpillar All Rights Reserved Page: M-4 of M-9
3512B Diesel Generator Set
Electric Power
Optional Equipment
Control Panels
Remote monitoring software
Digital I/O module
EMCP 4.3, EMCP 4.4
Load share module
Generator temperature monitoring & protection
Exhaust System
Exhaust mufflers
Flanges
Elbows
Flange and exhaust expanders
Mufflers
Y Adapters
Flexible fittings
Generator
Oversize and premium generators
Permanent magnet excitation (PMG)
Internal excitation (IE)
Anti-condensation heater
Air Inlet System
Heavy duty air cleaner
Single element filter
Power Termination
Circuit breakers, UL listed
Circuit breakers, IEC compliant
Cooling System
Standard installed radiators
Optional installed radicators
Coolant
Water level switch gauges
Fuel System
Primary fuel filter
General
SS-11425339-1000028914-130 SS Page 6 of 12
MSS-EPG-1000028914-155.pdf © 2021 Caterpillar All Rights Reserved Page: M-6 of M-9
3512B Diesel Generator Set
Electric Power
Starter covers
Amp battery charger
Engine barring device
Jacket water heaters
Electric starting motors
Dimensional Art
The International System of Units (SI) is used in this publication. CAT, CATERPILLAR, their
respective logos, ADEM, EUI, SOS, "Caterpillar Yellow" and the "Power Edge" trade dress, as well
as corporate and product identity used herein, are trademarks of Caterpillar and may not be used
without permission.
SS-11425339-1000028914-130 SS Page 9 of 12
MSS-EPG-1000028914-155.pdf © 2021 Caterpillar All Rights Reserved Page: M-9 of M-9
ELECTRIC POWER - Technical Spec Sheet
STANDARD
3512B
1400 ekW/ 1750 kVA/ 60 Hz/ 1800 rpm/ 480 V/ 0.8 Power Factor
3512B
1400 ekW/ 1750 kVA
60 Hz/ 1800 rpm/ 480 V
Metric English
Package Performance
Genset Power Rating with Fan @ 0.8 Power Factor 1400 ekW
Genset Power Rating 1750 kVA
Aftercooler (Separate Circuit) 30.0 ° C 86.0 ° F
Fuel Consumption
100% Load with Fan 371.1 L/hr 98.0 gal/hr
75% Load with Fan 276.8 L/hr 73.1 gal/hr
50% Load with Fan 189.8 L/hr 50.2 gal/hr
25% Load with Fan 116.9 L/hr 30.9 gal/hr
Cooling System¹
Engine Coolant Capacity 156.8 L 41.4 gal
Radiator Water Capacity High Temp Circuit N/A N/A
Radiator Water Capacity Low Temp Circuit N/A N/A
Radiator Total Capacity N/A N/A
Inlet Air
Combustion Air Inlet Flow Rate 127.9 m³/min 4516.3 cfm
Max. Allowable Combustion Air Inlet Temp 51 ° C 123 ° F
Exhaust System
Exhaust Stack Gas Temperature 429.3 ° C 804.7 ° F
Exhaust Gas Flow Rate 315.9 m³/min 11154.9 cfm
Exhaust System Backpressure (Maximum Allowable) 6.7 kPa 27.0 in. water
SS-11425339-1000028914-130 SS Page 10 of 12
TSS-EM2668-00-GS-EPG-11425339.pdf © 2021 Caterpillar All Rights Reserved Page 1 of 3
ELECTRIC POWER - Technical Spec Sheet
STANDARD
3512B
1400 ekW/ 1750 kVA/ 60 Hz/ 1800 rpm/ 480 V/ 0.8 Power Factor
Heat Rejection
Heat Rejection to Jacket Water 571 kW 32473 Btu/min
Heat Rejection to Exhaust (Total) 1345 kW 76492 Btu/min
Heat Rejection to Aftercooler 435 kW 24739 Btu/min
Heat Rejection to Atmosphere from Engine 124 kW 7052 Btu/min
Heat Rejection to Atmosphere from Generator 72 kW 4100 Btu/min
Alternator²
Motor Starting Capability @ 30% Voltage Dip 3673 skVA
Current 2105 amps
Frame Size 1445
Excitation IE
Temperature Rise 150 ° C
Emissions (Nominal)³
NOx 2965.2 mg/Nm³ 6.3 g/hp-hr
CO 598.3 mg/Nm³ 1.3 g/hp-hr
HC 199.7 mg/Nm³ 0.4 g/hp-hr
PM 64.7 mg/Nm³ 0.1 g/hp-hr
1. For ambient and altitude capabilities consult your Cat dealer. Air flow restriction (system) is added to existing
restriction from factory.
2. UL 2200 Listed packages may have oversized generators with a different temperature rise and motor starting
characteristics. Generator temperature rise is based on a 40° C ambient per NEMA MG1-32.
3. Emissions data measurement procedures are consistent with those described in EPA CFR 40 Part 89, Subpart D & E
and ISO8178-1 for measuring HC, CO, PM, NOx. Data shown is based on steady state operating conditions of 77° F,
28.42 in HG and number 2 diesel fuel with 35° API and LHV of 18,390 btu/lb. The nominal emissions data shown is
subject to instrumentation, measurement, facility and engine to engine variations. Emissions data is based on 100%
load and thus cannot be used to compare to EPA regulations which use values based on a weighted cycle.
Note: Codes may not be available in all model configurations. Please consult your local Cat Dealer representative for
availability.
SS-11425339-1000028914-130 SS Page 11 of 12
TSS-EM2668-00-GS-EPG-11425339.pdf © 2021 Caterpillar All Rights Reserved Page 2 of 3
ELECTRIC POWER - Technical Spec Sheet
STANDARD
3512B
1400 ekW/ 1750 kVA/ 60 Hz/ 1800 rpm/ 480 V/ 0.8 Power Factor
STANDBY:Output available with varying load for the duration of the interruption of the normal source power. Average
power output is 70% of the standby power rating. Typical operation is 200 hours per year, with maximum expected usage
of 500 hours per year.
Ratings are based on SAE J1349 standard conditions. These ratings also apply at ISO3046 standard conditions
Fuel Rates are based on fuel oil of 35° API [16° C (60° F)] gravity having an LHV of 42 780 kJ/kg (18,390 Btu/lb) when
used at 15° C (59° F) and weighing 850 g/liter (7.094 lbs/U.S. gal.). Additional ratings may be available for specific
customer requirements, contact your Cat representative for details. For information regarding Low Sulfur fuel and
Biodiesel capability, please consult your Cat dealer.
SS-11425339-1000028914-130 SS Page 12 of 12
TSS-EM2668-00-GS-EPG-11425339.pdf © 2021 Caterpillar All Rights Reserved Page 3 of 3