Professional Documents
Culture Documents
HP Laserjet 2300dn Solenoid Repair
HP Laserjet 2300dn Solenoid Repair
I/O cover
1 Press two release buttons (callout 1) on the back of the I/O cover.
2 Rotate the back of the cover away from the printer to remove the cover.
2
1
2
1
3 Pull the cover toward the front of the printer to release the cover from the frame, and then lift
the cover away from the printer.
4 Remove the DIMMs from the printer.
1
2
3
2
2
1
2
1 2
Reinstall note
Make sure that the connector shown in callout 2 in figure 45 is reconnected correctly. If, after
reassembly, the control panel malfunctions, unplug this connector and then reconnect it.
2
1
2
3
1
2
Reinstall note
Use the locator pin at the lower edge of the formatter plate (toward the back of the printer) to
place the plate correctly.
1
2
2
2
3
2
4
5
2
Reinstall note
Before replacing the screws, make sure that the connector (callout 5) is routed below the drive
assembly plate. Do not thread the cable through the holes in the plate.