Professional Documents
Culture Documents
PILOT HIGH
IGBT HF OUTPUT
The PowerPlasma 70 from Everlast fills the gap quite Reliable high frequency starting
easily. It offers quality cutting performance right up Nothing starts as quickly and reliably as high frequency.
through 1 inch, which is about the most the average It’s a proven, time tested method of starting the plasma
customer will cut. But when the time comes, you can arc. There is no perceptible delay and restarts are imme-
diate, without waiting for the air flow to stop to restart.
easily squeeze more out of it. The IGBT inverter design
gives good performance right up to the edge of the Pow- High duty cycle
erPlasma 70’s cutting limits. This assures you that you’ll With a high duty cycle of 60% at full power, the Power
PAC
always have just what you need to do the job. Plasma cutter does not stop cutting very easily. But there
are times when you may reach or exceed the duty cycle.
When that happens the unit automatically shuts down
RATED CUTTING CAPACITY* until the unit has cooled down to safe operating range.
MAXIMUM
Adjustable post flow timer
1 ⅛”
Perfect control of post flow cooling of the torch can al-
ways be maintained. For high duty cycle requirements or
MINIMUM thick cuts, time can be increased to improve consumable
28 gauge
and torch life.
everlastwelders.com
EVERLAST
1-877-755-9353
329 Littlefield Ave. South San Francisco, CA 94080
PowerPlasma 70
Included Accessories* Universal Connector
P-80 HF Torch, 15 ft. 300 Amp Work Clamp Regulator/Filter for Consumable Kit
Cable Assembly Compressed Air Efficient and safe, the
Euro style quick-connect
offers interchangeability
Up Close: with aftermarket torch
Digital meter allows the user to precisely adjust brands like Trafimet®.
the cutter to any amp setting desired.
Low air pressure warning interrupts cutting Maximum Pierce 1/2” Cart
when air pressure drops below safe limits. Heavy duty
Gouging medium < 3/8” 3 shelves
*Actual appearance of accessories may vary.
** Optional Equipment subject to change.
***Recommended for Plasma cutting and welding. EVERLAST
everlastwelders.com
1-877-755-9353
329 Littlefield Ave. South San Francisco, CA 94080