Professional Documents
Culture Documents
CONRATULATION..............
1 / 1 point
1. A lubricant is necessary to *
Choice 2
Choice 3
Choice 4
1 / 1 point
2. The general ratio of soluble oil and water used as coolant is *
Choice 2
Choice 3
Choice 4
1 / 1 point
3. The best example for semi-liquid lubricant is *
A. grease B. graphite
Choice 2
Choice 3
Choice 4
1 / 1 point
4. Best example for gravity feed lubrication is *
Choice 1
Choice 2
Choice 3
Choice 4
1 / 1 point
5. Most common type of cutting fluid used in almost all the machining operations is *
Choice 2
Choice 3
Choice 4
1 / 1 point
6. Fire point is *
A. the temperature at which an oil gives off sufficient vapour to burn it continuously when
ignited
Choice 1
Choice 2
Choice 3
Choice 4
1 / 1 point
7. Graphite is a *
Choice 1
Choice 2
Choice 3
Choice 4
1 / 1 point
8. The best example for splash lubrication is *
A. ring lubricator B. wick feed lubricator C. grease gun D. pump lubricator
Choice 1
Choice 2
Choice 3
Choice 4
9. Slideways of a machine are frequently lubricated by * 1 / 1 point
Choice 1
Choice 2
Choice 3
Choice 4
1 / 1 point
10. Which one of the following is the reason that tap water is not preferred as coolant on
machine tools?
B. Danger of corrosion
C. It has insufficient cooling effect
D. Due to high cooling effect the cutting edges of tool break off
Choice 1
Choice 2
Choice 3
Choice 4
1 / 1 point
11. Which one of the following frictions occurs in an un-lubricated journal bearing? *
Choice 1
Choice 2
Choice 3
Choice 4
1 / 1 point
12. In which one of the following materials no cutting oil is used when drilling? *
Choice 1
Choice 2
Choice 3
Choice 4
1 / 1 point
13. The effective cutting of steel with hand hacksaw, which one of the following
coolants is suitable? *
Choice 1
Choice 2
Choice 3
Choice 4
1 / 1 point
14. Which among the following is NOT the purpose of grease? *
Choice 2
Choice 3
Choice 4
1 / 1 point
15. Which one of the following is NOT the property of a good lubricant? *
Choice 2
Choice 3
Choice 4
1 / 1 point
16. The most important quality of any lubricant is *
Choice 1
Choice 2
Choice 3
Choice 4
0 / 1 point
17. Which one of the following is the best way for preparing an emulsion? *
Choice 2
Choice 3
Choice 4
1 / 1 point
18. Which one of the following is common method for applying cutting fluid on the tool
point? *
A. With high pressure jet B. With a brush C. With an oil can D. Either ‘b’ or ‘c’
Choice 2
Choice 3
Choice 4
1 / 1 point
19. While machining cast iron, the coolant used should be *
Choice 2
Choice 3
Choice 4
1 / 1 point
20. Identify the oil cup shown in figure. *
A B C D
Choice 1
Choice 2
Choice 3
Choice 4