Professional Documents
Culture Documents
VBR-TN-02580-EN - Speed Sensor For Hydraulic Vibrator Heads Testing Technical Note
VBR-TN-02580-EN - Speed Sensor For Hydraulic Vibrator Heads Testing Technical Note
Testing
SPEED SENSOR TESTING 3. With an Ohmmeter you should get a reading greater
than 200 Ω. If the reading is 200 Ω or less, replace the
sensor (Part #W420-005). Even though it is functional, the
Testing at the Connector (General Maintenance) rotational speed will be incorrect.
1. Orient the speed sensor connector as shown in Figure 1.
Notice orientation notches located on left and right side
of the inner ring.
2. Use an Ohmmeter to measure the top and left pins. Use
the K Ohms scale.
Notch Top Pin
Notch
Left Pin
Speed
Sensor
Trademarks appearing in this document are the property of their respective entities.
Due to continuous research, product improvements and enhancements, Badger Meter reserves the right to change product or system specifications without notice, except to the
extent an outstanding contractual obligation exists. © 2018 Badger Meter, Inc. All rights reserved.
wycosales@badgermeter.com | www.wycotool.com
Phone: 262-639-6770 | 800-233-9926 | Fax: 262-639-2023