Professional Documents
Culture Documents
E-KM15E Seisanchusi230329
E-KM15E Seisanchusi230329
B01-35-E
Production Discontinued
Applications close on September 29, 2023
Overview
KM15 is a pressure transmitter using a "vapor
deposition semiconductor strain gauge type
sensor" which is widely used in various industrial
applications. Since the pressure sensor is welded
to the fitting, durability is excellent.
(Only available for Lot production)
Features
•Available over wide temperature ranges
•All-welded construction
•High EMI/RFI rating
•Applicable to a wide range of applications from
low pressure to high pressure
RoHS
•IP 65 Ingress rating
Features of sensor
Waterproof
IP65 IP67
property
KM15
Production Discontinued Pressure Transmitter
Applications close on September 29, 2023
Specifications
Scope of specifications
Allowable
Pressure range*1 Direct connector
Accuracy*2 Shielded maximum
(MPa) type pressure
Lead type cable type
(Sealed pressure) (Gauge pressure)
Pressure range 3.5 MPa and below Pressure range 4 MPa and above
Compensated temp.
Environmental -20 to 70℃ -30 to 120℃ (Except cable type -30 to 105℃)
specifications
range
Operating temp.range -20 to 70℃ -40 to 120℃ (Except cable type -30 to 105℃)
Storage temp.range -30 to 80℃ -40 to 140℃ (Except cable type -40 to 120℃)
Standard: 500m/s2 (11ms or less, X, Y, Z 3 times for each at room temp.)
Shock resistance Option: 1000m/s2 (6ms or less, X, Y, Z 3 times for each at room temp.)
Standard: 150m/s2 (20 to 400Hz, X: 4h, Y: 2h, Z: 2h at room temp.)
Vibration proof Option: 300m/s2 (20 to 1000Hz, X: 4h, Y: 2h, Z: 2h at room temp.)
Durability More than 10,000,000 times. (10 to 100%F.S.)
IP65 (Direct connector type must be mated to mating connector. Cable type and lead type excludes harness
Protection rating
end, body only.)
Diaphragm SUS630 (17-4PH) Welded to fitting
Material Fitting SUS304
Case SUS304
7/16-20UNF flared 37° , 7/16-20UNF flared 45° Maximum working pressure: 5MPa
R1/8, R1/4, R3/8, G1/4A*3, G3/8A,
Fittings 1/8NPT, 1/4NPT,
G1/4A DIN3852 Form A, G1/4A DIN3852 Form E, Maximum working pressure: 50MPa
7/16-20UNF-2A SAE J1926-2*3,
9/16-18UNF-2A SAE J1926-2
Direct connector type HW090, EJⅡ (+), METRI-PACK 150, M12x1 (4pin), Deutsche DT04-3P
Flying leads 0.3m (Standard)
Lead type Econoseal J series〈MARK Ⅱ (+)〉
Electrical
(Tyco Electronics Japan G.K.)
connections
Shielded cable 1m (Standard)
Shielded cable type Econoseal J series〈MARK Ⅱ (+)〉
(Tyco Electronics Japan G.K.)
Approx. 60g (Connector direct type, R1/4)
Weight
Approx. 110g (Cable type, R1/4)
Applicable Directive: 2004/108/EC
CE marking Applicable Standards: EN61326-2-3:2006
*Please connect supply of electric power net that doesn't receive the influence of the excess voltage by the thunder.
*1 Units of psi and bar can also be manufactured. Note applications are limited to applications specified by Measurement Law. For more information,
please contact us.
*2 Accuracy includes the effects of followings: ①Linearity ②Hysteresis ③Repeatability
*3 G1/4A、7/16-20UNF-2A SAE J1926-2 T threads are manufactured by SUS416 fitiing with heat treatment for 10MPa range and above.
2
KM15
Production Discontinued Pressure Transmitter
Applications close on September 29, 2023
Dimensions 1 Unit: mm
3 2 1
plug housing mating connector F : 6189-0131
Common
2
Output (+)
Power (+) Power (+)
(φ25) (φ25)
(19)
(17)
(63.5)*1
(61.5)*1
Label
Label
14*1 7*1
14*1 7*1
R1/4 R1/4
φ1 φ1
9 9
9
9
17 Hex. 17 Hex.
KM15-17□ KM15-57□
M12×1Connector (4pin)
Power (+)
(φ25)
(15)
*1
Label
(59.5)
*1
7
*1
14
R1/4
19
9
17 Hex.
KM15-M7 □
3
KM15
Production Discontinued Pressure Transmitter
Applications close on September 29, 2023
Dimensions 2 Unit: mm
(32.5)
(26)
(70.5)*1
*1
(77)
Label Label
*1
*1
7
7
*1
*1
14
R1/4
14
R1/4
φ1
19 9
9
9
17 Hex. 17 Hex.
KM15-87□ KM15-47□
(Black)
Power (+) Output (+)
(Red) (White) Econoseal J series
Common (23.1) 〈MARK Ⅱ (+)〉
(Tyco Electronics Japan G.K.)
(Black)
(13.9)
Terminal: Sn plate
Part number of plug housing
(32.5)
(φ20)
(18.5)
(φ25) (φ25)
(75)
Label Label
*1
(49)
14*1 7*1
*1
7
*1
14
R1/4 R1/4
19 19
9
17 Hex. 17 Hex.
KM15-2 7□ KM15-3 7□
*The drain wire in the cable is not
connected to the transducer body.
4
KM15
Production Discontinued Pressure Transmitter
Applications close on September 29, 2023
Dimensions 3 Unit: mm
Fitting
KM15-□4□ KM15-□5□ KM15-□6□ KM15-□7□ KM15-□8□
Without With Without With
Hex. height
Hex. height
Hex. height
throttle throttle throttle throttle
7
11
7
7
13.5
14
10
45
14
15
φ4.9
°
φ5.5
7/16-20UNF φ9.25 7/16-20UNF φ9.2 R1/8 R1/4 R3/8
flared 37° flared Throttle φ0.7 Throttle φ0.7
SAE J514 Tightening torque Tightening torque
6N・m 6N・m
9 9 9 9
11.5
φ1 φ1 φ1 φ1 4.3
9
9
9
φ2
17 Hex. 17 Hex. 17 Hex. 17 Hex. 22 Hex.
Maximum working pressure: 5MPa (50bar, 750psi) Maximum working pressure: 50MPa (500bar, 7500psi)
Hex. height
Marking of NPT
Hex. height
throttle throttle
Hex. height
φ11±0.1
7
9.5
7
10
14.5
2.7
16
2.7
12
1/8NPT
O-ring O-ring
P11 1
* 1/4NPT
Throttle φ0.7 P14 2 Throttle φ0.7 Throttle φ0.7
*
11.5
4.3 φ1 φ1
9
φ2
19 Hex. 22 Hex. 17 Hex. 17 Hex.
1 JIS B 2401 Class 1 B NBR 2 JIS B 2401 Class 1 B NBR
* *
Hex. height
2.05±0.15
Hex. height
2.05±0.15
2.3±0.5
+0.2
9.5
11
11
+0.05
φ12.24
0
11
-0.08
2
11±0.2
3
3
12±0.2
12
12
11.5
φ2 φ2 φ2
22 Hex. 22 Hex. 19 Hex. 22 Hex.
Units of psi and bar can also be manufactured. Note applications are limited to applications specified by Measurement Law.
Options
5
KM15
Production Discontinued Pressure Transmitter
Applications close on September 29, 2023
Model number configuration Please specify the model number, each specs and the range for ordering.
Model
K M 1 5
Pressure transmitter ① ② ③ ④ ⑤ ⑥ ⑦ ⑧ ⑨ ⑩ ⑪ ⑫ ⑬ ⑭ ⑮
Model number Product specifications Additional specifications (Optional)
① 1 Direct connector type HW090 Sealed pressure type (Pressure range: 1MPa and above)
Type 2 Lead type (0.3m Standard) Sealed pressure type (Pressure range: 1MPa and above)
3 Shielded cable type (1m Standard) Gauge pressure type
4 Direct connector type Deutsche DT04-3P Sealed pressure type (Pressure range: 1MPa and above)
5 Direct connector type EJⅡ (+) Sealed pressure type (Pressure range: 1MPa and above)
8 Direct connector type METRI-PACK 150 Sealed pressure type (Pressure range: 1MPa and above)
M Direct connector type M12x1 (4pin) Sealed pressure type (Pressure range: 1MPa and above)
④ Scope of specifications
Pressure range ④ ⑤ ④Pressure range ⑤Accuracy Direct connector type, Shielded cable
Please specify pressure ⑤ (MPa) at room temp. Lead type type
range and unit of measure Accuracy
at room temp. 0 8 -0.1 to 0 ±2.0%F.S. − ○
along with corresponding
ordering code. (23±2℃) 1 8 -0.1 to 0.1 ±2.0%F.S. − ○
A 8 0 to 0.1 ±2.0%F.S. − ○
*Unit of psi and/or bar are
only available for export. B 8 0 to 0.2 ±2.0%F.S. − ○
C 8 0 to 0.3 ±2.0%F.S. − ○
E 8 0 to 0.5 ±2.0%F.S. − ○
6 7 -0.1 to 1 ±1.0%F.S. ○ ○
7 7 -0.1 to 2 ±1.0%F.S. ○ ○
G 7 0 to 1 ±1.0%F.S. ○ ○
J 7 0 to 2 ±1.0%F.S. ○ ○
K 7 0 to 3.5 ±1.0%F.S. ○ ○
L 7 0 to 5 ±1.0%F.S. ○ ○
N 7 0 to 10 ±1.0%F.S. ○ ○
Q 7 0 to 20 ±1.0%F.S. ○ ○
P 7 0 to 25 ±1.0%F.S. ○ ○
R 7 0 to 35 ±1.0%F.S. ○ ○
S 7 0 to 50 ±1.0%F.S. ○ ○