Professional Documents
Culture Documents
Dwyer 1950g Manual
Dwyer 1950g Manual
Captive
Vent Drain
Screw
Plug Model 1950G Switches:
Operating ranges and deadbands
4-7/8
[123.8]
5-7/16
[138.1] Fig. A
1/2˝ NPT CAPTIVE
ELECTRICAL SCREW
CONDUIT
CONNECTION
INSTALLATION For units supplied with both internal and external bonding terminals, the
1. Select a location free from excess vibration and corrosive ground screw inside the housing must be used to ground the control. The
atmospheres where temperatures will be within the limits noted under enternal bonding screw is for supplementary bonding when allowed or
Physical Data on page 1. Switch may be installed outdoors or in areas required by local code. When external bonding conductor is required,
where the hazard of explosion exists. See page 1 for specific types of conductor must be wrapped a minimum of 180° about the external
hazardous service. bonding screw. See below.
2. Mount standard switches with the diaphragm in a vertical plane and LOCKWASHER CONDUCTOR
with switch lettering and nameplate in an upright position. Some switches
SCREW
are position sensitive and may not reset properly unless they are
mounted with the diaphragm vertical.
©Copyright 2014 Dwyer Instruments, Inc. Printed in U.S.A. 9/14 FR# 28-440332-10 Rev.10