Maintenance and cleaning
MAINTENANCE AND CLEANING
1 Air inlet filter cotton replacement
{Shut down the equipment, discon he power
‘supply and remove the battery. .
2. Remove the fits cotton
bottom she
8. Te out the intake fer cotton, Pay
Plas tention tothe intake ai ater
‘To ar coton may absorb and accumulate ot of dust, Pate operate
wnheae,
‘And do good jb of protection to avoid
inheling dust
4, Load new fiter cotton in the correct rection,
5. epce te ter eaton
Note: ture to instal or esace te iter ction for long time may attect the performance ofthe equipment or damage the equipment. Please
Feolace the fern ne
Coton, the reptacenant evel depends on he us eicnmen snd ure contin sade aera
2 Replacement and maintenance of
‘molecular sieve
1. when the equipment indicates thatthe molecular sive needs tobe relaeed please contact he
2. Leng te sterage may shorten the serves te of molecular seve
2. Leng arm opaation n huni erwtcnment my heren tha service eof molecu seve
Warning: do not disassemble and replace the molecular sieve without permission.
Only the equipment supplier or qualified maintenance engineer can disassemble and
replace the molecular sieve
3, Nasal oxygen tube
replacement
‘Usare con purehate natal oxygen tubes aecording to thelr need, bu they need to eneute thatthe flowing
‘conctons ae fully met:
1. esse cortect the equipment supp or purchase under the guidance of
Profersosale
2, Please purehase tom
‘eur channels
Scanned with CamScannerPacking list
PACKING LIST
‘uancity
marks
= enn one 1 =
wo Battery } 1 Sethe
~ AC adapter (with power cord) 1 Sow
ow oa 1 Ferete
Nite
5 Intake titer cotton 61 Sensbe contour un
6 eckage 1 So
oa instetons 1 oa
egg 1 =e. —
“1 centcate 1 ie
a Quick use guide 1
Warranty
description
WARRANTY DESCRIPTION
‘The oxygen generator host
(excluding consumables) is uaranteed fort yeor
from the date of purchase.
Ail maintenance serve
*s must be carried out by the designated maintenance
service center
During the werranty period,
{the faut caused by non-human reasons shal be
‘uarenteed tree of charge
After the warranty period, the maintenance cost
willbe charged
‘sused by imoroper use, paid msintenance services shall
consumables,
‘eta oxygen tube and fiter cotton are not covered
by waranty.
Scanned with CamScannerThe detailed alarm items of the equipment are shown in the
table below:
i ea Walarm 2 Po
| Alarmitems | Alarm reason status S¥BtEM
| lelay 2
oer
The complete charge discharge. | attery Ife un
Battery life exhausted —_cycle of the battery is greater than | <5S | Alarm prompt only "UN out, Pigg Will
Sod. the heath ese tan S056 ct le
t . eee — : - L Selle
| stanies | |The input voltage
Low adapter vottage Tsiutvtaseotiveatnrisioner + | rE! | swag atey Bower
_ L ___| check the adapter
No breathing was detected ! | Ne-beetning
No breathing detected in 185 consecutive days of <185 | Alarm prompt only check the nasal
normal operation | | | omgentabe
When only battery power | Low -
Low battery used, peahonin consumption <és ‘Aare OER ety: battery
is between 5% and 20% | Peasuas”
oe a ee ON a pe pe a
| Forced le breath
Respiratory i te
may esoieorysensordetectontehae tts | shutdown | falls, lease St
- Ler Contact the sett
Battery power is less | Forced + Replace the batter
Battery empty than 5% when using <10s | shutdown Provide external peg
battery power only | after 105 | when the battery'is mn ty
- - |} \ — a - mpty
{ 1 Forced 1 When the syst
smonnsmneesie Tearmencemn ier laos | dates ito, sf tombe
| iris, ~ |p | somal ra ay
too low iowerthanO"Cn <105 | shutdown om and meat tt
i 1 ‘and move to t
| i oe
| "igh system
sistem temperate Te eat tompertre ghar Forced i Winectoe
nm Bates jgen supply made. When using this equipment, it must be connected ,
5
Scanned with CamScannerCOMMON PlOVIEINS ANG SUMMONS
COMMON PROBLEMS AND SOLUTIONS
Recommended slain 77
Remove te
RORE Re ear
dead battery oe battery and connect
The device + poorconecton ot Ac ° meenous chee
cannot be POmersupy = soi con
opened exes 'f the above operation
problem, plea Cannot solve the
Ise
supplier contact your equipment
he device ot ‘Tumnon the
‘oxygen generator
Kink or obstruction of nasal Check then .
No onygen | Maker oat I: heck tha macl oxygen tbe adits connection tothe
output —
LL product sehematie diagram
1
11, Product parameters
2
i. introduction to Sten
the interface
3
IV. usage = ete 3
V. maintenance and cleaning = ----- - a
Vi, common problems and Solutions. 10
VII. Packing list, e
Vil. Warranty = ~~
description
[attachment 1} faut indicator Ss
12
{attachment 2}
Information
Scanned with CamScannerOnly adapter power
supply status is currently
used
(oat 4
80%00
:30
Insert the adapter and install
the battery in standby mode
«
status without alarm
There are currently multiple
alarm messages being
displayed cyclically
000 |
100%
2:30
Battery powered status only
0001 +
80%
0:30
Battery status is
' install
in the adapter power “e
Supply well
A
‘purzer status on | off when there fs alarm
information
‘Alarm information
content
Current abnormal state alarm items
and recommended measures
Scanned with CamScannerAttachment 1] fault indicator
FAULT INDICATOR
The detailed fault items of the equipment are
shown in the table below:
- Ee =
f Possible causes of failure esa | Display "|
Feu 3 “PRY Prompt | Fut indicator. |
I 2 | z i
au Forced If the fan fails, -
faire ermal operation of colng fin Shutdown, Please contact Red, long bri
Fan after 10¢ the seller eed
Forced | Ifthe molecul
7 ular sieve faite or faite 4 7
ovine Molecular sieve file shutdown "| eve fails, please 4 long.bright
after 108 contact the seller
Forced if the compressor
compressor feu Compressor operation failure shutdown fails, please Red, long bright
after108 contact the seller
Forced ifthe solenoid
solenoid Selenide shutdown valve fails, please Red, long bright
eek ened after 10s contact the seller
Attachment 2] alarm
information
ALARM INFORMATION
“The pritty of equipment slarm information and alarm status is low pity.
‘The alarm tone can be turned off or on globally.
O the alarm status cannot be turned off. As long as the equipment has
alarm information, the equipment will always alert the user through sound
signal or visual signal.
‘The warning light ofthe alarm is yellow and will be on fora long time after the alarm
information appears until the alarm state disappears.
O alarm sound volume > 450B (a).
‘Ommirum alr signal generation del: tss han Soom
Verification of alarm system: no breathing is triggered within 156 minutes after
the equipment is started up, and the alarm system shall have an alarm item of
“no breathing detected". If there is no such alarm, the alarm system is abnormal.
Scanned with CamScanner