You are on page 1of 65

MOST COMMON SCIENCE FAQS

IS NEAR INFRARED THERAPY GOOD FOR DETOXIFICATION?


WHAT'S THE DIFFERENCE BETWEEN NEAR INFRARED AND FAR
INFRARED?
WHAT IS THE EMF/ELF OUTPUT OF THE POCKET SAUNA?
DO I NEED TO WEAR EYE PROTECTION DURING MY THERAPY?
IS THERE ANY DANGER OF OFF-GASSING OR VOC EMISSIONS?
DOES THE CANVAS ENCLOSURE HAVE ANY PETROCHEMICALS OR
DYES?
DO THE SAUNASPACE BULBS EMIT ONLY NEAR INFRARED LIGHT?
HOW DOES SAUNASPACE COMPARE TO JOOVV?
How Full Spectrum Incandescent Light
Breaks Down into Light and Heat
Therapy
Can I Get a Visual on That?
LEDs are all the rage now in the Biohacker and Light Therapy community right
now, so it’s important to say that fads come and go quickly. LED Light Therapy
is a fad, only a few decades old. Incandescent Light is as old as the universe
and has nourished all life on Earth for millions of years.

We’ve relied on the incandescent lamp to grow our food and heal our bodies for
over 100 years. It is the closest mimicker of incandescent sunlight, of ALL man-
made light technologies. Below is the ACTUAL emission spectrum of 250W our
Incandescent Heat Lamp, referenced from Philips Brand. [1]
INCANDESCENT
HEAT
HOW OUR ANCESTERS SWEAT
OUT THE TOXINS
SUPERIOR QUALITY &
EFFECTIVENESS OF
INCANDESCENT HEAT THERAPY
It’s All About the Water Absorption.
SaunaSpace incandescent heat lamps don’t produce as much ambient heat as
a far-infrared emitter. The Pocket Sauna (inside air temperature ~110-125°F)
doesn’t get as hot as a far-infrared (inside air temperature ~150°F) or traditional
steam sauna (inside air temperature ~110-125°F). This is because it doesn’t
have to. The benefits of sauna therapy don’t come from raising the temperature
of the air.

They come from raising the core temperature of the body. Granted, one
way to accomplish raising body temperature is by remaining in a hot enough
environment for an extended period of time.
How our incandescent sauna works instead is by heating the body radiantly,
from within.

Water absorbs different wavelengths of light to varying degrees. We see below


in the Water Absorption Spectrum that near infrared wavelengths consistently
penetrate tissue 2-3 orders of magnitude deeper than far infrared wavelengths
will ever penetrate.

This graph above was built using data points from the above referenced
Wikipedia article.

Further confirmation that near infrared is a more efficient, effective means of


heating biological tissue than far-infrared wavelengths can be seen below in this
old Philips Incandescent Heat Lamp Data Sheet showing Tissue Penetration of
Wavelengths. [2]
Farmers have understood this for over 100 years. Far-
Infrared Emitter Sauna Manufacturers Still Don’t Get It!
This is why near infrared wavelengths deliver radiant, penetrating tissue
heating. Near infrared wavelengths heat our bodies up much more efficiently
than far infrared. Far infrared wavelengths, because they exhibit very shallow
penetration into tissue, deliver less effective conductive surface-heating.

The beauty of having a incandescent full-spectrum sauna is that you get the


spectrally natural form of infrared, which means primarily Near Infrared Light,
and the Synergy of Photobiomodulation and Heat Detoxification. 

INCANDESCENT
LIGHT
HOW OUR ANCESTORS
PHOTOBIOMODULATED THEIR
MITOCHONDRIA
WHAT IS PHOTOBIOMODULATION
(PBM)?
Our Cells Eat Light!
Photobiomodulation (PBM), is a term from the field of photobiology, which
studies the biological effects – both beneficial and harmful – of light
wavelengths on living organisms. You may have heard of PBM referred to
alternatively as: low-level light therapy, red light therapy, mitochondrial
stimulation, mito-stim, or simply light therapy. Different names for the same
thing.

PBM occurs when light photons are absorbed by living tissue, but not just any
light will do. PBM is only possible within a certain wavelength range on the
electromagnetic light spectrum: specifically from 600-1000 nanometers. This
range is known as the ‘mitochondrial stimulation band’ (or ‘healing band’)
because only these wavelengths of light stimulate the cellular mitochondrial light
receptor enzyme, cytochrome-c oxidase. It thus encompasses both red light
(600-700nm) and a portion of near infrared light (700-1500nm). When light from
within this band of wavelengths is absorbed by the cells of the human body, the
cell responds by increasing ATP production, releasing Nitric Oxide, and forming
Reactive Oxygen Species – all of which work to produce large-scale systemic
benefits to the health of the body. Some, but not all, of the studied benefits of
PBM are: promotion of anti-aging, enhancement of athletic performance,
improvements in memory and cognition, accelerated muscle healing, and
boosted cellular regeneration.

The utility of PBM as a non-invasive therapy with such a wide range of benefits
is truly amazing. It’s no surprise, then, that there is a new and increasingly
crowded market for personal photobiomodulation devices, all making unique
claims to superiority. The question at the heart of this article and Joovv’s is this:
which of these various light technologies are actually effective at providing PBM
to consumers?

WHY IS INCANDESCENT NEAR


INFRARED LIGHT AN OPTIMAL WAY
TO DELIVER THERAPEUTIC PBM?
Ahh, the Synergy of the Natural Form…
SaunaSpace uses incandescent lamp technology. Dr. Michael Hamblin is a
renowned subject matter expert in PBM and has been named in countless PBM
literature, review articles, and scientific studies. He says:

“Most of the early work in this field was carried out with various
kinds of lasers, and it was thought that laser light had some
special characteristics not possessed by light from other light
sources such as sunlight, fluorescent or incandescent lamps and
now LEDs. However all the studies that have been done
comparing lasers to equivalent light sources with similar
wavelength and power density of their emission, have found
essentially no difference between them [emphasis mine].” [3]
To summarize, Dr. Hamblin is saying here that there is no difference between
different sources of light (LED and incandescent, for instance) in terms of ability
to provide PBM. Only two characteristics of light
matter: wavelength and power density. As long as the light produced is within
the recommended therapeutic ranges of both these variables, the source does
not matter.

So let’s examine how SaunaSpace’s incandescent lamps measure up in these


two categories, wavelength and power.

WAVELENGTH: THE NEAR INFRARED


HEALING BAND
Not All Wavelengths Were Created Equal.
LED lights, which are monochromatic, a word derived from Ancient Greek,
meaning “one color”. In modern physics, ‘monochromatic’ refers to light of a
single wavelength or frequency.  In context, this means that LEDs only emit light
in very narrow wavelength bands. In terms of visual light, this means that a
single LED can only produce light in one specific hue of a certain color. Contrast
this to SaunaSpace, where we use incandescent bulbs to deliver PBM.

What is Incandescence?
Incandescence describes the phenomenon wherein an object, when heated to
high enough temperatures, produces light — think of red-hot metal, coal, or the
sun. Incandescence is decidedly not monochromatic in terms of the
wavelengths of light that it produces. Our incandescent bulbs produce what we
call full-spectrum light, in a wavelength emission curve that spans, with our
bulb’s red filter from ~600 to over 4000 nanometers. To visualize, think about
the example of the sun: the sun’s light gives us every shade of every color of
the rainbow. The question becomes, which breadth of wavelengths is preferable
to get the full benefits of PBM?

Dr. Michael Hamblin’s research, and that of countless others, concludes that
PBM is achievable across the broad 600-1000nm range. Hamblin writes:

“Many wavelengths in the red (600–700 nm) and near-infrared


(NIR, 770–1200 nm) spectral regions have shown positive
results… [4]

Dr. Hamblin’s research shows that, in fact, PBM is achievable across the full
600-1200nm range. Mitochondrial stimulation PBM has been shown to occur
strongly across the 600-1000 range.[5]

Our Bodies Have an Optical (Light) Window?


Dr. Hamblin’s seminal publication Mechanisms of Low Level Light Therapy
describes our bodies as having an optical window, or a narrow band of
wavelengths of light, within which tissue penetration is profound. [6]  

The following Figure from Mechanisms clearly shows the ‘optical window’ from
600 to 1400 nm.

Wait, Let’s See some Math!


When we calculate the percentage across the broader, 600-1000nm mito-stim
band, we find that actually 14% of the energy emitted by an IR heat lamp
activates mitochondrial functions (see calculation below).

The Basic Physics Calculation that 14% of Emission from


our Incandescent Lamps Delivers PBM
We must integrate Planck’s Law across the wavelength band in question to
calculate the energy emitted from an incandescent light source (called a black
body radiator in physics).

For those who are intimidated by physics and calculus, not to worry, there are
many easy online calculators that do the tricky math for us!

1st calculate the TOTAL ENERGY emitted by our lamp by integrating Planck’s


law across all wavelengths:
CONSTANTS
Temperature of Filament = 2450K
Emissivity = 1 (we assume no light absorption by the glass bulb itself; real
emissivity is perhaps slightly below 1, but almost 1)
Recession velocity = 0 km/s (the light source is not moving away from us)
Wavelength = 1 µm

RESULT
Therefore the radiance, or total energy emitted, = 650336 W/m2/sr across all
wavelengths (0-10000nm)

And then to calculate PBM ENERGY from our lamp that is in the 600-1000nm


mitochondrial PBM band, we integrate from 600-1000nm:
CONSTANTS
Lower Limit = .6 µm (600 nm)
Upper Limit = 1 µm (1000 nm)

RESULT
Band Radiance = 90763 W/m2/sr

Finally, the PERCENTAGE OF PBM ENERGY OF TOTAL ENERGY from our


lamps:
90763 / 650336 * 100% = 14% of the energy emitted by a 2450K red-filtered
incandescent heat lamp is within the mitochondrial PBM band.

POWER: THE RELEVANCE OF


IRRADIANCE
So… What is Irradiance?
Here’s an example: you’re driving down a remote country road at night. There’s
no street lights, so you turn on your high-beams to see better. With your brights
on, the road immediately in front of your car can be seen almost as clearly as
during the daytime. But as you look further out, you can see the road less and
less clearly until, at about 400 feet, you can no longer see cars or animals in the
road any better than with your headlights off. This is because your headlights’
brightness decreases the further away it has to shine This effect of light
decreasing in intensity the greater the distance is from its source is known as
irradiance, and is the reason why it’s polite to switch off your brights if you get
too close to a car driving in front of you. Irradiance is measured in terms of the
amount of light power received by a surface, per unit area, in units of watts per
square meter.

In context, irradiance takes into account the amount of light energy that a
person will receive from a light therapy device at a given distance from the light
source. Proper irradiance is key to proper PBM, once we’ve established that the
light source is producing the right wavelengths of light, which we have at this
point. Using the analogy of light as medicine, now that we know that we have
the right type of pill (wavelength), it’s important that we’re taking the right dose
(irradiance) for the medicine to be effective. In this case, the known dose for
proper PBM with red wavelengths is between 10 mW/cm 2 and 100 mW/cm2.

Where’s my Irradiance Meter?


We use the Megger PVM210 Irradiance Meter[7] that Joovv uses in their article
so that we could perform the same tests they did on our actual lamps. The
PVM210 measures only 400-1100nm. There’s a minute quantity of 400-600 nm
light exiting our glass bulb because it’s red-filtered, so the irradiance readings
shown are approximately 100% PBM wavelengths. See our results below.

Irradiance of our SaunaSpace Single Light Panel at 12, 18 &


24 Inch Distances
We measure ~15-34 mW/cm2 irradiance at the recommended usage distance of
12-18 inches from the single 250W lamp, well within the therapeutic
photobiomodulation range of 10-100 mW/cm2.

So, in essence they are implying that only a small fraction of their already
undervalued irradiance measurement actually applies to PBM, where in reality,
virtually 100% of the wavelengths measured by the meter are PBM active and
the 3% calculation is totally irrelevant.

This is just one more in the list of misleading claims by Joovv. But wait, there’s
more…

Wait that was a Single Bulb, But I See 4…


The SaunaSpace Pocket Sauna’s 4 Light Panel uses FOUR such 250 Watt
bulbs.
With four of our bulbs clustered together in our Pocket Sauna’s Light Panel, you
get four times the heat, light, and and more than 4x the irradiance as just the
one 250W bulb.

Irradiance of Our 4 Light Panel (1000W Total) at 12, 18 & 24


Inch Distances
We measure ~30-67 mW/cm2 irradiance at the recommended usage distance
of 18-24 inches from the 4 250W lamps, landing firmly within the therapeutic
photobiomodulation range of 10-100 mW/cm2.

Take a look at the irradiance measurements of the fully operational Pocket


Sauna, delivering a very healthy dosage of PBM. So far, SaunaSpace
manages to fulfill both of Dr. Hamblin’s requirements
of wavelength and power, proving that we are PBM device to be taken
seriously.

PROTECTION FROM
EMF STRESS
OUR ANCESTRAL LIFE WAS FREE
FROM ALL MAN-MADE EMF
Real Luxury is Being EMF Free.
SaunaSpace understands the serious problem of EMF stress: man-made
magnetic and electric fields have been shown in many studies to be nervous
system stressors. You definitely don’t want EMF stress coming from your
therapy device!
SaunaSpace design solutions ensure our products exert ZERO EMF influence
on the body when used as directed. That means ZERO electric field stress and
ZERO magnetic field stress.

SaunaSpace follows the highest standards of EMF protection: Geovitals


Standards.

Geovitals, the world-renowned Austrian Academy for Radiation Protection and


Environmental Medicine, is known for setting the most stringent EMF shielding
standards on earth. They recommend that any electric field reading above 30
V/m is a serious problem. Ideally we want 0 V/m. To put it simply, ideally we
don’t want any part of our body to be in a space or on a surface that measures
above 0 V/m.

We test our product using the Geovitals EM Field Probe. [8] This incredibly


sensitive electric and magnetic field meter utilizes specialized gold-plated
sensors; it’s by far the most sensitive consumer electric field meter available.

SaunaSpace Design Ensures there is ZERO EMF, both


Electric & Magnetic, on your Body from our Product.

SAUNASPACE FARADAY GUARDS


Our Faraday Lamp Guards shield the user from electric fields that are emitted
by the incandescent lamp, even at 0 inches from the lamp.
SAUNASPACE LIGHT PANEL BODY IS SHIELDED
Our Leading Edge Shielding Design means there is 0 electric field emission
from the Light Panel Body and also none from the Power Cord.

We will only ever be satisfied with 100% Shielding.

SAUNASPACE EMITS ZERO EMF OUT IN FRONT OF OUR PANEL


No matter how close you are to our Light Panels, they exert 0 electric field
stress on your body.

At the SaunaSpace recommended use distance of 12-24 inches from the Single
Light Panel, you don’t get any EMF from our product.

Same goes for our 4 Light Panel, no EMF from it on the body at 12 inches,
much less at the 4 Light Panel’s recommended 18-24 inch use distance.

Ahh, no EMF feels good!


WHY SHOULD YOU
CARE ABOUT ALL
THIS?
INCANDESCENT THERAPY IS HOW
HUMANS ARE DESIGNED TO
REGENERATE AND OPTIMIZE
CELL FUNCTIONING
NEAR INFRARED LIGHT (NIR): THE
MAGIC WAVELENGTH
Near infrared light absorption by the light receptors in our cell’s
mitochondria promotes cellular regeneration and anti-aging (epigenetic re-
optimization)

Only 600-950 nm Light Has Been Shown To Activate Cellular Regeneration


& Anti-Aging Systems

A large and rapidly growing body of knowledge supports the use of near


infrared light to treat and prevent many illnesses, physical and toxic injuries, and
other health conditions.

There is a tremendous amount of medical and scientific research going on right


now, and it’s all about mitochondria and mitochondria-controlled systems!

More from Mechanisms of Low-Level Light Therapy:

“Mitochondria are thought to be a likely site for the initial effects of light, leading
to increased ATP production, modulation of reactive oxygen species and
induction of transcription factors. These effects, in turn, lead to increased cell
proliferation and migration (particularly by fibroblasts), modulation in levels of
cytokines, growth factors and inflammatory mediators, and increased tissue
oxygenation.”

Some of the observed cellular effects of stimulating the cells with 600-950 nm


light include:

 Increased Cellular Metabolism


 Increased Blood Circulation
 Increased Tissue Oxygenation
 Increased Collagen Production
 Production of Inflammatory Mediators that Reduce Cellular
Inflammation
 Production of Growth Factors that assist Cellular Regeneration
 Increased Cellular and Tissular Growth
 Activation of Anti-Aging Systems

What is Anti-Aging?
When we repair both the DNA architecture and the gene transcription systems,
we are restoring the optimal epigenetic state of the cell. Gene transcription
refers to how the cells rebuild themselves. Gene transcription is a tremendously
complex system that involves many steps of quality control. As our cells and
bodies age through exposure to environmental stressors like chemical toxins,
our epigenetic state degrades and our cells rebuilt themselves less optimally.
More errors occur over time, and the entire cell becomes less efficient and less
optimal: in short, we age.

That’s why heat therapy detoxification is not enough for us to fully heal and re-
optimize our bodies. We need to use Near Infrared Light to restore our
Epigenetics to the optimal biochemical and bioluminescent state.

Red Light wavelengths are from about 600-700nm. Near


Infrared Light wavelengths are from about 700-1200nm. Only this narrow band
of light can be accurately called the Light Therapy band.

NEAR INFRARED LIGHT, NATURE’S


MOST POWERFUL NUTRIENT
Near infrared light is contained within the spectrum of natural sunlight. In fact,
sunlight that reaches the earth’s surface contains 52% to 55% near
infrared light.  It’s clear that humans and other animal and plant species, by
Nature’s design, have been programmed to utilize near infrared light to
our benefit.

The light therapy effects of NIr light cannot be overstated. The interaction of


chromophores within our bodies with near infrared light is the key to
understanding the power of NIr light. [6]

The tungsten filaments in the incandescent light bulb produce the


same beneficial visible red & near infrared (also called NIR-A, 600nm – 950nm)
elements of natural sunlight. [7]
The tungsten-filament bulb not only emits the correct wavelengths of light
necessary for light therapy, they emit exclusively near infrared light and red
light. Tungsten does not emit any significant amount of mid-infrared or far-
infrared wavelengths of light. And our Red-Filtered Incandescent Heat Lamps
also don’t emit any UV or blue light, so no killer wavelengths, as the sun emits.

Why does Near Infrared Light Penetrate Tissue


5x or More Deeply than Far Infrared Light?
The human body has an optical window of light absorption of 600-1150nm.
That’s because hemoglobin absorbs most all light below 600nm, which is all
visible light except red light.

On the other side of the optical window, water absorbs all light of wavelengths
greater than 1150nm. [8]

Far infrared light wavelengths start at about 3,000-10,000nm, so all far infrared


light wavelengths are completely absorbed by water molecules.

Since we have water molecules everywhere in our bodies, it’s obvious that far-
infrared light won’t ever penetrate deeply; it is blocked by water in all tissues.

More importantly, even when far-infrared light manages to penetrate up to 1.5-2


inches into human tissue, it DOES NOT activate any cellular regenerative or
anti-aging systems of healing. It only provides a heating effect on the cells.

Far Infrared Saunas Are the Wrong


Wavelength, Use Inferior Technology & Lack
Smart Design
Far infrared saunas use heating elements that mainly emit light in the far-
infrared range (NIR-C, 3000nm – 1mm).
These far infrared heating elements typically emit harmful levels of EMF.

Far infrared sauna manufacturers are forced to use expensive metal shielding
to lower these high EMF levels, which increases costs & results in decreased
far-infrared light emission into the sauna. In other words, low-EMF far infrared
saunas primarily rely on heating up the air around the sauna user to heat the
user’s body, and are therefore little different than traditional saunas.

Furthermore, there are no photoreceptors for far infrared light in the


human body, so that unlike near infrared lamp saunas, far infrared saunas only
provide heat therapy, not near infrared light therapy.

Traditional Wet/Finnish Saunas only Provide Heat Therapy, not Light Therapy
Traditional saunas produce heat generated by electricity or less commonly
wood burning. They may be dry or wet.

Wet saunas create steam by utilizing steam generators or by throwing water on


electrically-heated hot rocks.

Dry saunas use electric heaters that typically emit harmful levels of
electromagnetic energy (EMF). A typical dry Finnish-type sauna operates at
180°F or greater and heats the body from the outside in.

Heat Therapy for Detoxification, Your Best


Defense Against the Modern Toxic World
Throughout history, humans have used sauna therapy as a safe and powerful
means of detoxification, from Native American sweat lodges to Finnish wood-
fired saunas.

It’s been called many things:

 Heat Therapy
 Sweat Therapy
 Hyperthermic Therapy
 Sauna Therapy
 Sweat Lodge Therapy

Heat Therapy is simple to achieve. All we must do is raise cell temperature by


several degrees for several minutes to activate cellular heat therapy effects.
What are these cellular heat therapy effects?

 Heat Shock Proteins are activated. HSPs repair misfolded and


damaged proteins and also help make cellular detoxification more
efficient
 Increased Cellular Metabolism
 Increased Oxygenation

When doing this in the tissues of the body’s core, we activate the whole body’s
detoxification response. This is called whole-body or systemic heat therapy. It’s
the full-body heat therapy that results in dramatic healing effects for the entire
organism:

 Increased Blood Flow to Tissues


 Increased Tissue Oxygenation
 Vasodilation of Blood Vessels, so Blood Pressure Decreases, even
as Blood Circulation Increases
 Increased Production of Human Growth Hormone
 Increase Insulin Sensitivity/Reduced Insulin Resistance
 Activation of Skin as Organ of Detoxification via Passive Sweating

We dramatically increasing blood-flow to the vital organs and skin, unlocking


even hard to reach toxins.

Sweating during vigorous exercise also raises the body temperature, but
actually decreases deep organ blood flow, which means very little detoxification
takes place.

When sitting quietly in your sauna, sweating passively, profound detoxification


begins to occur. The skin, your largest detoxification organ, is activated as a
toxin eliminator. This is in sharp contrast to sweating during aerobic exercise,
which again does not result in meaningful removal of toxic organic chemicals
and heavy metals.

In today’s toxic world no one can avoid exposure to harmful substances. Sauna
therapy is a cornerstone of defense in the fight against toxin related illness and
dysfunction.

Longevity
A recent landmark scientific study published in a major medical journal
demonstrated a significant decrease in mortality (increase in longevity) with
sauna use. [9]  Benefits observed included significant decreases in fatal heart
attacks and deaths from other cardiovascular diseases.

Relaxation & Stress Relief


Sauna use promotes parasympathetic nervous system activity (“rest & digest”
state) and decreases sympathetic (“fight or flight” state) activity.    Saunas
promote profound relaxation and stress relief through their parasympathetic
effect.
A number of factors synergistically and powerfully combine to produce these
changes. Sweating, moving blood to the periphery, Heating the body, Near
infrared light therapy, and more are all involved during the sauna experience.
Regular use produces genuine relaxation of body and mind-improving a sense
of well-being. Sauna therapy also decreases blood pressure as well as
improves both oxygenation and circulation.

Near Infrared Light Therapy Effects


Wound & Tissue Repair
Multiple studies show accelerated healing of wounds and other types of tissue
injury using near infrared light.    A great example is the use of NIR light therapy
to treat disorders and injury to the eyes. Rather than causing injury to the
eye, near infrared light helps the eyes heal.
In a scientific study, mice were blinded by chemical injury (methanol) and
the blindness was reversed with the application of NIR light therapy.  There is a
growing body of evidence demonstrating the powerful healing effects of NIR
light. NIR light promotes faster cell regeneration and human tissue growth.

Athletic & Physical Performance


Sauna bathing after exercise have been shown to increase athletic
performance, reduce fatigue and improve muscle recovery.    Muscle circulation
is increased. Innovative gyms are actually installing infrared lamp systems
integrated with exercise equipment for an enhanced experience. Growth
hormone release also occurs with sauna use and can increase muscle strength.

Saunas also provide many of the same benefits as aerobic exercise. Both result
in sweating which provides detoxification but of course, the sauna detoxification
is much more extensive and powerful. Sauna use also increases metabolism,
heart rate, and improves circulation like exercise but does so in a stress-free,
relaxing environment.

Joint & Muscle Pain


Low-level light therapy has been shown to reduce joint and muscle pain in
animal studies. Penetrating near infrared light appears to address joint and
muscle problems from multiple angles. Hand-held near infrared devices used
for pain relief are common in physical therapy and pain management offices.
Far infrared does not provide this effect.

Skin Rejuvenation
Care for your body’s largest organ!  Your skin is a major organ for eliminating
body wastes through sweating. Most people don’t sweat enough.

Near infrared saunas encourage sweating and unlock toxins stored beneath the
skin bringing deeper toxins to the skin for elimination. NIR light easily
penetrates the skin, boosts circulation and brings more blood and nutrients not
only to the skin itself but to deeper tissues as well.

Near infrared light therapy has been shown to stimulate vital collagen and


elastin production. Collagen helps plump the skin, while elastin firms the skin.
The visible red and NIR light energizes and repairs damaged cells, stimulating
collagen and elastin and returning the skin to a more youthful look.

NIR light is being used currently to treat specific skin problems such as acne
scars, eczema, rosacea and more.

Treating psoriasis with light therapy is probably the oldest known therapy for
this skin disease. Bathing in sunlight to relieve the symptoms of psoriasis is
an age old remedy.
NIR light provides new hope for those that suffer from psoriasis.  NIR light
therapy has been shown to help heal psoriasis non-invasively without side
effects.

Body Fat & Cellulite


Regular sauna use can reduce overall body fat. Near infrared light has been
shown to  decrease cellulite. NIR heat lamp saunas allow specific problem
areas to be targeted as needed. (E.g. cellulite in thigh skin). A study involving a
group of women riding stationary bicycles demonstrated a 444% increase in
weight loss for the group exposed to near infrared light when compared to
the exercise only group.   Infrared light combined with other therapies has been
shown to be effective in controlling cellulite.

REFERENCES

1. ↑ Laukkanen T, Hassan Khan H, Zaccardi F, Laukkanen J. Association Between Sauna Bathing and Fata
Mortality Events . JAMA Intern Med. February 23, 2015. doi:10.1001/jamainternmed.2014.8187.

2. ↑ Wilson L, MD. Why Does the Near Infrared Lamp Sauna Have An Extremely Parasympathetic Effect  .
2014.

3. ↑ Chung H, Dai T, Sharma SK, Huang YY, Carroll JD, Hamblin MR. The Nuts and Bolts of Low-level L
2012 Feb;40(2):516-33. doi: 10.1007/s10439-011-0454-7. Epub 2011 Nov 2.

4. ↑ Hamblin M, Demidova T. Mechanisms of low level light therapy . Proc. SPIE 6140, Mechanisms for L
doi:10.1117/12.646294.

5. ↑ Whelan H T, Buchmann E V, Dhokalia A, Kane MP,Whelan N T, Wong-Riley M, Eells J T, Gould L J


of NASA Light-Emitting Diode Irradiation on Molecular Changes for Wound Healing in Diabetic Mice
Surgery. April 2003, 21(2): 67-74. doi:10.1089/104454703765035484.

6. ↑ Eells JT, Wong-Riley MT, VerHoeve J, Henry M, Buchman EV, Kane MP, Gould LJ, Das R, Jett M, H
HT. Mitochondrial signal transduction in accelerated wound and retinal healing by near-infrared light th
6):559-67.

7. ↑ Eells JT, Henry MM, Summerfelt P, Wong-Riley MTT, Buchmann EV, Kane M, Whelan NT, and Whe
photobiomodulation for methanol-induced retinal toxicity . Proc Natl Acad Sci U S A. 2003 Mar 18; 10
Mar 7. doi: 10.1073/pnas.0534746100

8. ↑ Scoon GS, Hopkins WG, Mayhew S, Cotter JD. Effect of post-exercise sauna bathing on the endurance
runners . J Sci Med Sport. 2007 Aug;10(4):259-62. Epub 2006 Jul 31.

9. ↑ Hamblin M. Can osteoarthritis be treated with light? . Arthritis Research & Therapy. 2013, 15:120 doi:
10. ↑ Gale GD, Rothbart PJ, Li Y. Infrared therapy for chronic low back pain: a randomized, controlled trial  
Autumn;11(3):193-6.

11. ↑ Ablon G. Combination 830-nm and 633-nm light-emitting diode phototherapy shows promise in the tre
preliminary findings . Photomed Laser Surg. 2010 Feb;28(1):141-6. doi: 10.1089/pho.2009.2484.

12. ↑ Avci P, Gupta A, Sadasivam M, Vecchio D, Pam Z, Pam N, Hamblin MR. Low-level laser (light) thera
restoring . Semin Cutan Med Surg. 2013 Mar;32(1):41-52.

13, 15. ↑ Möckel F, Hoffmann G, Obermüller R, Drobnik W, Schmitz G. Influence of water-filtered infrared-A (
body weight by physical exercise . Ger Med Sci. 2006; 4: Doc05.

14. ↑ Alster TS, Tanzi EL. Cellulite treatment using a novel combination radiofrequency, infrared light, and m
device . J Cosmet Laser Ther. 2005 Jun;7(2):81-5.

16. ↑ Sasaki GH, Oberg K, Tucker B, Gaston M. The effectiveness and safety of topical PhotoActif phosphat
LED (red and near-infrared) light on Grade II-III thigh cellulite: a randomized, double-blinded study  . J
96.

References

1. ↑ Philips. R125 Incandescent Reflector Data Sheet.

2. ↑ Philips. R125 Incandescent Reflector Data Sheet Showing Tissue Penetration Depth of Wavelengths.

3, 4. ↑ Hamblin M. Mechanisms and applications of the anti-inflammatory effects of photobiomodulation. AIMS

5, 6. ↑ Hamblin M, Demidova T. Mechanisms of low level light therapy. Proc. SPIE 6140, Mechanisms for Low

7. ↑ The Megger PVM210 Irradiance Meter

8. ↑ The GeoVitals EM Field Probe


1.

2.

3.

4.

NEW
ThermaLight Bulb
0 star rating

The ThermaLight™ bulb from SaunaSpace is the first-ever near infrared


incandescent bulb designed entirely with health in mind.
Artisan-made using a mouth-blown process dating back to 50 B.C.

Featuring our custom-made tungsten filament that delivers 3-5x more red &
near infrared irradiance than any other bulb on the market, all through a
beautiful red-stained hard glass.

120V Version Backordered until December 2019.

240V Version Ships in 1-3 Business Days.

Voltage

Next Level Red & Near


Infrared Irradiance
Our ThermaLight Bulb has a uniquely designed filament that delivers a more
ideal emission spectrum than standard incandescent heat lamp models and
delivers two major advantages for the user.

MORE LIGHT THERAPY: a higher percentage of both photobiomodulation


wavelengths red (600 – 700nm) & near infrared (700-1000nm)

BETTER HEAT THERAPY: a higher percentage deep penetrating radiant-


heating wavelengths (1000-1500nm).

Targeted ThermaLight™: One Bulb in the Photon™


Here we see one ThermLight Bulb irradiance at 12-30 inch clearance range.
Full-Body ThermaLight™: Four Bulbs in the Luminati™
Sauna
Below shows irradiance measurements delivered during a typical near infrared
sauna session by four of our ThermaLight™ Bulbs at recommended 18-30 inch
distance range from the body.

vs Four Standard Heat Lamps in the Luminati™ Sauna


For comparison, we’ve measured the irradiance of four 250W standard heat
lamps of the Industrial Performance Brand sold with all SaunaSpace products
prior to July 2019. Standard heat lamp bulbs are emitting about 50% less
measured red and near infrared wavelengths.

PRODUCT SPECS
 ELECTRICAL INFO
Brand: SaunaSpace
UPC (120V version): 00810018190002
SKU (120V version): 3019TH10
UPC (240V version): 00810018190019
SKU (240V version): 3019TH20
Weight: .2 lb (.1 kg)

DIMENSIONS
Length: 6 in (15.2 cm)
Width: 5 in (12.7 cm)

ELECTRICAL INFO
Wattage: 250 W
Voltage: 120 V or 240V
Size: R4
Base: E26
Coating: None
Filament: Tungsten
Lifespan: up to 5000 hr
Light Type = Incandescent
Material = Mouth-Blown, Hand-Rolled Red-Stained Tempered Glass
Country of Manufacture = China

SaunaSpace Shielding Mitigates


the EMF
SaunaSpace Light Panels are fully shielded, ensuring zero emf influence on the
user from the electrical components. Here’s what we’ve measured.

Electric Field Measurements

Magnetic Field Measurements


FAQS
How is ThermaLight™ different from all other heat lamp bulbs?
Are ThermaLight™ bulbs hotter than standard brands of lamps because
they put out more far infrared energy?
Have a question and want to see it here in FAQs?
0 star rating 0 Reviews, 19 Q&As
250W Near Infrared Heat Lamp Bulb, 240V
International Voltage
Incandescent heat lamp bulbs emit a natural full-spectrum light emission,
including red, near infrared and thermal infrared. Our lamps operate at around
850 nm, so we get plenty of mitochondria-activating red and near infrared light
(600-1000 nm wavelength band) and they are ultra-low EMF.

The 1150 nm and greater wavelengths emitted comprise the “thermal infrared”
that heats our tissues, because water absorbs most light wavelengths above
1150nm. We get plenty of thermal infrared wavelengths from our incandescent
heat lamp for effective, gentle, feel-good sweat therapy.

We use red glassed bulbs in Near Infrared Sauna Therapy, because the red
glass minimizes glare by filtering out the blue, green and yellow visible light
(400-600 nm) emitted, so we only enjoy the healing full-spectrum thermal light
emission of red, near infrared and thermal infrared.

240 volt-rated for use in Europe, Middle East, UK, Australia, New Zealand,
South Korea and most other countries outside the USA that have 220-240 volt
electrical supply
Approved by Lawrence Wilson, MD, for use in Near Infrared Sauna Therapy.

MADE IN SOUTH KOREA


In Stock. Ships in 1 – 3 Business Days.

$16 – ADD TO CART

PRODUCT DETAILS
 ELECTRICAL INFO
Weight: .2 lb (.1 kg)

DIMENSIONS
Length: 6.8 in (17.3 cm)
Width: 4.9 in (12.5 cm)

ELECTRICAL INFO
Bulb: R40
Socket Type: E26
Glass Color: Red
Petrochemical Outer Coating: None
Wattage: 250 watts
Voltage: 230-250 volt
Rated Life: 5000 hours
Incandescent Near Infrared Sauna Shower
Converter Bundle
5 star rating10 Reviews

Convert your standard shower stall into a sexy SaunaSpace sauna.

A great solution if you just don’t have room for our Luminati™ or Faraday™.

Yes, it’s less convenient, requires some minimal setup before and after each
use, is not wheelchair-accessible, takes longer to pre-heat and can’t be used in
all showers. See the Installation Applications below under Specifications.

Your purchase of this bundle does include our comfy stool.

Ships in 1 – 3 Business Days.

Plug (Bulb Voltage)


$1,999
 — ADD TO CART

100 DAY RISK-FREE TRIAL | FREE SHIPPING BOTH WAYS


IN USA | LIFETIME WARRANTY

ONLY THE FINEST NATURAL


MATERIALS
We select only the most non-toxic, non-treated natural
materials so you’re protected from toxic chemical &
offgassing.
Our careful quality control ensures every piece of your
product is perfect and will last you a lifetime of use.

NATURAL CANVAS
UNTREATED, NATURAL, HYPOALLERGENIC
Our USA-grown cotton canvas is the ultimate hypoallergenic enclosure material: 100%
chemical free because we wash and clean our cotton yarn with only hot water, yet
durably machine-washable.
SOLID BASSWOOD
HYPOALLERGENIC WOOD
Select-grade, sustainably harvested North American Basswood is zero-VOC rated and
not treated with any chemicals or oils. so it won’t outgas.

CHROMED STEEL
NON-OFFGASSING, SAFE HARDWARE
USA-manufactured Double-Plated Chrome Steel Lamp Guards and Hardware is not
powder-coated or treated.

PROVEN EMF
PROTECTION
ZERO EMF STRESS ON YOUR
BODY FROM ALL SAUNASPACE
PRODUCTS
LEARN MORE  

PURPOSE-DRIVEN DESIGN
Our thoughtful sauna shower converter design addresses
usability, safety, material offgassing, non-native EMFs,
durability and more.

BEAUTIFUL FENG SHUI


Our Shower Converter Bundle brings that feel-good SaunaSpace vibe to your
shower stall. You are (mostly) surrounded by your natural human elements:
wood, cotton canvas.

Our hypoallergenic Shower Curtain hides that existing plastic shower curtain so
you don’t have to worry about if offgassing.

SaunaSpace aesthetic is soft to the touch, rounded over everywhere. And a bit
of steam-punk from our guards 

TIMELESS CRAFTSMANSHIP
We love our craft, and it shows in every piece of our products.

All basswood components are handworked and hand-polished buttery smooth.

All our textile parts are precision stitched by our expert sewers.

Our rigorous quality control involves inspection of every stitch and every
component.

That’s why we confidently guarantee our product for a lifetime of use.


THE WORLD’S ONLY ZERO EMF SAUNA
SYSTEM
We don’t just say it, we test and measure it. And so can you.

SaunaSpace’s shielding design ensures there is ZERO magnetic field (MF) and
ZERO electric field (EF) stress on your body from the 4 Light Panel.

MF is 0 mG (not detectable) beyond the face of the Faraday Lamp Guards.

EF is 0 V/m on the front and rear Panel body, 0 V/m in front of the Faraday
Guard & 0 V/m on the Shielded Power Cord.
Every Panel we craft is tested with the Geovitals EM Field Probe. Utilizing
specialized gold-plated sensors, the Geovitals meter is one of the most
sensitive electric and magnetic field meters available, far more sensitive than an
ungrounded Trifield meter. Check out our EMF testing results.

SAFE LIGHT PANEL DESIGN


Our signature rigid stainless steel Faraday Guards keep you safe and do not
offgas anything.

The guards’ front grille small mesh keeps even small fingers from accidentally
touching the bulbs, unlike inferior guard designs out there. The thin-gauge mesh
has low thermal mass so it never gets too hot, even after a full sauna session.

3-switch control gives you ultimate flexibility. 1 switch for each row of lamps.
Heat sensitive users start with 1-2 bulbs and work up to using all 4 lamps.

Porcelain sockets, stainless steel hardware and untreated solid basswood


means durability without any chemical offgassing, period.

WHAT'S IN THE BOX?


 TUNGSTEN™ PANEL
 PEDESTAL
 SAUNA STOOL
 SAUNA CURTAIN
 2 CURTAIN RODS
 PRODUCT MANUAL

TUNGSTEN™ PANEL
4 250W Low-EMF Incandescent Near Infrared (NIR-A) Bulbs for the ultimate natural
thermal light therapy experience.
Worldwide Voltage Compatible.
Our signature stainless steel Faraday Guards keep you safe from burns and from
electric fields.
Tool-free mounting hardware easily adjusts lamp height.
Carrying handle for easy transport.
HEALING HAPPINESS
Incandescent Light and Heat Therapy is
natural…that’s why it feels better than
far infrared and LED-alternatives.
LEARN THE SCIENCE  

SPECIFICATIONS
 GLOBAL BUNDLE SPECS
 TUNGSTEN™ PANEL
 STOOL & PEDESTAL
 SHOWER CURTAIN
 SHOWER RODS
Brand: Moen®
UPC: 03458401772

WEIGHT
1.75 lbs (0.8 kg)

DIMENSIONS
Rod Length: 40-72 in (102-183 cm)

MATERIAL
Stainless Steel

INSTALLATION NOTES
Rods can fit in 40 long shower stall minimum,
and can extend to up to 72 in wide shower stall.
They feature an simple and strong twist-lock design that installs easily and
stays in place securely.

START YOUR 100 DAY TRIAL


TODAY
FREE SHIPPING BOTH WAYS IN USA
FOR ALL ORDERS OVER $248 IN THE USA
Free insured trackable FedEx Ground Shipping to all 50 States in
USA. We also ship to every country on Earth. Calculate your
international shipping rates in the Cart.
100 DAY RISK-FREE TRIAL
PEACE OF MIND, AND YOUR SATISFACTION GUARANTEED
Use it for 100 days after arrival. If you are not completely satisfied,,
we’ll arrange the free return ship. As long as it’s returned in “like-
new” condition, we give you a full refund!

SAUNASPACE LIFETIME WARRANTY


OUR PRODUCTS ARE BACKED BY A LIFETIME WARRANTY
Rest assured: You’re buying a handmade product meant to last a
generation. All SaunaSpace Handcrafted Products come with our
Lifetime Warranty.
Mary L.
Verified Buyer

5 star rating
08/20/17
INCREASED ENERGY AND IMPROVED MOOD
I purchased my SaunaSpace this past February after having used a Far-infared sauna for
the past 8 years. I loved the detoxification effects of using the sauna, but it often left me
feeling depleted and tired. I noticed two very big differences when I started using the Near-
infared SaunaSpace. The first is that I had increased energy and mental cla
rity after the sauna. No more feeling tired! I also noticed improved mood and sense of well-
being.
The tungsten red heat lamps give the effect of being in the sun without the radiation. My
old sauna felt a little claustrophobic but I love the feeling of being in the tent. As you rotate
around the stool every 5 minutes, time flies. You leave the sauna with more energy and
better mood. Having used a hot rock sauna, steam shower, and Far-infared sauna, I can say
that the SaunaSpace is by far the best. It’s easy to put together and conveniently fits into
the corner of a room. I highly recommend it!
IMG_0918.JPG
Sarah T.
Verified Buyer

5 star rating
03/26/17
KHOA HUYNH PHARMD FAARFM
Wow! That was a hard winter with the cold and flu virus. I saw so many patients coming
thru my pharmacy with symptoms of the virus. Cold, wet winter, no sunlight, low vitamin D
may be a huge factors this year. Luckily for me, I have the Sauna Space. I used it twice a
week and I did not get sick at all.
Jolene M.
Verified Buyer

5 star rating
04/24/18
I LOVE MY SAUNA SPACE 4 LIGHT PANEL!
I have been using infrared sauna's for almost 20 years, but recently purchased the Near
Infrared 4 Light Panel and retrofitted it to the ceiling of my existing sauna. I find it is MUCH
better than my old far infrared sauna, as I sweat much more. I love the quality and
craftsmanship of the sauna space products and the customer service is excellent!

quality and craftsmanship of the sauna space products and the


customer service is excellent! ...Read More

 Share  ' Share Review by Jolene M. on 24 Apr 2018

Was This Review Helpful? 

 20 

 0

Nita
Verified Buyer

5 star rating

03/24/17

CONVERTING AN EXISTING FAR INFRARED SAUNA TO NIR

A few years ago I purchased a FIR Sauna after weeks of research


on everything pertinent to consider. This 3-person sauna is 100
percent cedar and I have used it often in the past three years.

Disadvantage #1 - Time

Preheating the sauna to 130F expended 30 minutes, this is when I


would enter the sauna. It took another 20-plus min ...Read More

   

 Share  ' Share Review by Nita on 24 Mar 2017

Was This Review Helpful? 

 75 

 3

Chelsea M.

Verified Buyer

5 star rating

10/15/19

BEAUTIFUL DESIGN

I love this sauna...amazing, healing, beautiful and light weight!

 Share  ' Share Review by Chelsea M. on 15 Oct 2019

Was This Review Helpful? 

 0 

 0

Carlene G.

Verified Buyer

5 star rating
05/28/19

WORTH THE WAIT...

I am really enjoying the Tungsten Sauna, chair and table. It seems


to be helping some skin issues I have. I use it every other day in
the open air. Thanks for the quality products.

 Share  ' Share Review by Carlene G. on 28 May 2019

Was This Review Helpful? 

 0 

 0

 1 2 3 4 5 6 7 

NEED SOME HELP?

CALL

FAQ

EMAIL

 REACH OUT TO US
sales@saunaspace.com
+1-573-66SAUNA
8am - 5pm CT Monday - Friday
  1330 E Prathersville Rd, Columbia, MO 65202, USA

STAY IN TOUCH!
SUBSCRIBE ME!

FIND US ON SOCIAL
 
UPCOMING   EVENTS  |  AFFILIATE PARTNERS  |  JOBS
© 2013-2019 SaunaSpace | terms | privacy | disclaimer | trademarks
Nita

Verified Buyer

5 star rating
03/24/17

CONVERTING AN EXISTING FAR INFRARED SAUNA TO NIR

A few years ago I purchased a FIR Sauna after weeks of research on everything pertinent to
consider. This 3-person sauna is 100 percent cedar and I have used it often in the past
three years.

Disadvantage #1 - Time

Preheating the sauna to 130F expended 30 minutes, this is when I would enter the sauna. It
took another 20-plus min

utes to reach 147-150F which is the minimum I need to feel the first drip of sweat. After the
sauna reaches 155F is when I really start sweating and I start counting those minutes, so
add on another 20-30 minutes. This is getting close to 2 hours including preheating and
sitting in there for approximately 50 minutes.

Disadvantage #2 - Electricity and EMF

I wasn't as concerned about electricity costs at first, until I got a few increases on my bill.
My goal was to use the sauna 3 times a week, but considering it was taking a big chunk of
time, I started to scale way back, plus I was thinking about EMF exposure, even though my
sauna is rated as low EMF. I was now using the sauna a few times a month in the winter,
and never in the warmer months.
Solution - Adding a NIR Panel

I began reading about the benefits of NIR therapy (including cancer therapy) and how one
could easily *make* their own light panel. I was intrigued and wanted to add these bulbs to
my sauna to speed up the sweating process. However, I have zero tools and I also know
that its not that easy considering supplies have to be thoughtfully researched regarding
EMF, off-gassing and wiring. Aesthetics are very important to me, I love the look of my
cedar sauna and what I was finding on line was plain ugly and HUGE. I spent another few
weeks researching, looking at DIY plans, blog sites offering chicken wire boxes with
exposed light switches, chandelier type units that I didn't want to risk drilling a hole into my
cedar wall for, etc. I was going to give up and then did a search on Amazon and found the
most sublime light panel, but horrors it was "currently unavailable" ! Thankfully, the
manufacturer was listed which turned out to be SaunaSpace.

Conversion to NIR

I found their website immediately and after contemplating my existing space and lots of
measuring, I purchased the table, stool and the 4-unit light panel. I have never tracked
anything so closely and when the Fed-X man delivered the boxes, I immediately knew I was
going to save them, they are that pretty and well-designed, so don't worry about shipping.
When I opened the box with the table and stool, I was blown away by the wood. It is like
Amish furniture, you would know the comparison because the wood is silky smooth and
very solid. Both pieces went together in 5 minutes without tools. When I opened the box
with the NIR 4-panel unit, I silently mouthed *no way* I was that impressed, same beautiful
wood, seamless construction! This is worth it, the workmanship is clearly evident in every
detail, the stainless steel cages are beautiful and easy to open, the light switch toggles are
solid, the rounded corners, totally furniture grade.

The interior dimensions of my sauna are 58 wide, 44 deep, 74 high. The bench in the sauna
is 18 inches high and deep. The table fits perfectly against the opposite wall from the sauna
control panel. It lines up with the height of the bench. There was NO need to drill anything
into the wall to hang the panel, since it is perfectly stable on the table alone, plus the height
was right where I wanted it. All I had to do was lift the sauna bench and drape the electrical
cord inside to the existing sauna's electrical connection at the other end, plenty of cord
length, fished it out the exit hole and plugged it into the wall with the sauna. No tools, no
revisions. I placed the stool at the far end and I have over 4 feet between myself and the
panel, plus there is room to turn, but I also use the existing bench. This took me about 10
minutes! See photos.

Results - The best part of the review

First use: I preheated the sauna using its existing FIR heaters to 125F degrees (in the past it
was 130). I stepped in and turned on all 4 lights of the SaunaSpace, whoooaaa! Instant
warmth, exactly what I was hoping for. I was watching the sauna control panel very
carefully as to temperature and time, checking it every minute. I couldn't believe it when I
felt the first trickle of sweat at exactly 7 minutes of elapsed time, and the temperature in
the sauna was.....136 degrees!!!

My sauna is so much more comfortable at these lower temperatures. I don't want to get
out, its like I'm in a gentle rain and even my shins sweat. Before, I felt I was suffocating at
155 degrees plus the time sitting and waiting to sweat was annoying. This is how I use both
technologies: I set the original FIR heaters to 125 degrees on the panel. When I get into the
sauna, I turn on the SaunaSpace NIR Panel, it shoots the temperature up to 135 very
quickly, which then turns off the FIR heaters. The SaunaSpace keeps the cabin heated to
about 131 degrees without the other heaters turning back on (no EMF). Concurrently, the
temperature, time and timers, plus music and above cabin lights are on until my timed
session comes to an end. It truly is the best of both worlds. I also leaned a Himalayan salt
slab against the floor heater for negative ions when the cabin preheats (see photo).

I have been using my *new* sauna for one month. Because it is so pleasant and time
efficient, I use it four times a week instead of sporadically as mentioned above.
Subsequently some nagging injuries from mountain biking have resolved themselves. I
thought I'd never get full function back in my hand, now I can get a glove on and shift gears
(plus I'm typing this at warp speed) without pain. I forgot about my hip when I realized that
twinge is gone and lastly, a nagging shoulder injury from going over the bars a few years
ago is also gone. I am not exaggerating, I wouldn't take the time to write this long review.
Lastly, for the women, my skin is looking different, firmer, and more even-toned. I have had
red patches on my jaw area for years which have largely abated and a strange red circle on
one cheek, that I could never understand. My dermatologist mentioned rosacea, but I
didn't want to use a prescription cream. Right now my skin looks really good!

What sealed the deal:

I was sold on the Company

Brian is the inventor and when I first called to inquire about his product, he answered the
phone. I subsequently e-mailed a few times about measurements and revisions, and I
know I was a PITA. He always answered quickly, and he was extremely helpful. I felt
completely reassured with the 100 day trial period, and the lifetime warranty. I like his
ideals and these are the businesses I want to spend money on. My own philosophy on how
to determine if the cost is worth it...is to divide the cost into how many times I was going to
use this (a lifetime) and that extra couple of hundred dollars was nothing in comparison to
its aesthetic appeal and function. Right now, I'm pretty popular with my other biking
buddies. Thanks for taking the time to read this very long review.
Yong T.
Verified Buyer

3 star rating
05/22/19
THIS IS THE BEST PRODUCT
This is the best product so far. It is very effective in carrying out the daily detox for me. I set
it up in my shower room in my basement toilet. It looks great.

You might also like