Professional Documents
Culture Documents
CX622 - Fuser Removal Instructions
CX622 - Fuser Removal Instructions
Fuser removal
Note: For a video demonstration, see Fuser removal.
1 Remove the right cover. See “Right cover removal” on page 293.
2 Remove the left cover. See “Left cover removal” on page 283.
3 Disconnect the cable (A) from the LVPS.
Parts removal
338
7529
4 Position the fuser cable so that it can be pulled through from the front of the printer, and then guide the
cable through the front.
Warning—Potential Damage: Do not pull the cable too hard or cut the cable insulation.
6 Remove the bin full/narrow media sensor flag. See “Narrow media sensor flag removal” on page 384.
7 Remove the right output bin deflector. See “Right output bin deflector removal” on page 388.
Parts removal
339
7529
8 Disconnect the cable (C), and then remove it from its retainer.
9 Unhook the two springs (D) from both sides of the fuser.
10 Disconnect the two cables (E), and then pull them over the retainer.
Parts removal
340
7529
Parts removal
341
7529
Installation notes:
a Install the flags (A) from the old fuser into the new fuser.
e Print approximately 15 test pages each in simplex and duplex modes to make sure that the belt is properly
working and the flags are properly installed.
Parts removal
342
7529
Bottom removals
Installation note: Install the new rubber tires with the surface texture turning in the direction as shown in
the following:
Parts removal
343