Professional Documents
Culture Documents
RFU-RST-317 Appendix C Introduction
RFU-RST-317 Appendix C Introduction
Issue 01
RFU-RST-317 Date 18/11/2021
TITLE
APPENDIX C INTRODUCTION
ORIGINATOR SUBJECT RELATED TO
VUD Commission Regulation (EU) 321/2013
(WAG TSI) amended by Reg. (EU)
2020/387
AMENDMENT RECORD:
Background:
TSI WAG 321/2013, Appendix C:
“The compliance with the following set of conditions C.1 to C.18 is optional.”
If the option of Appendix C is selected by an applicant, section C.5 requires that, that
the entire appendix C must in this case be applied (for GE marking) or the entire
appendix C with certain defined exceptions (for CW marking).
Note: The clauses C.19 and C.20 now also belong to the content of Appendix C and
should in a future TSI WAG revision be added into the introductory information of that
Appendix. Appendix D should also be amended accordingly to avoid
misunderstandings.
Issue 01
RFU-RST-317 Date 18/11/2021
RFU PROPOSAL
As Appendix C now includes 20 subsections, the first sentence in Appendix C shall be
understood as “The compliance with the following set of conditions C.1 to C.20 is
optional.”
In relation to ‘Mandatory standards or normative documents referred to in this TSI’
(normally summarised within Appendix D), these shall:
• for clause C.19 be taken from clause 4.2.3.4 of TSI WAG as defined for ‘line side
detection equipment’ and
• for clause C.20. be taken as indicated in that clause C.20 itself.
THIS RFU WAS AGREED ON
PLENARY MEETING 063
THIS RFU ENTERS INTO FORCE ON
18/11/2021
FROM THIS DATE ON THIS RFU CAN BE APPLIED INSTEAD OF THE PREVIOUS MANDATORY
VERSION.
ERA COMMENTS
PLE 63– 10/11/2021: NO COMMENTS