You are on page 1of 20

Positive looks and

dynamic power in
compact
dimensions.
The 3-CD Triple-Tray
changer, the smart
and functional
Powered Rolling
Panel, and now
the Twin Hyper
Power-Drive
Subwoofers.
MX series
Powered Rolling Panel
To start the music, touch any
and ease of use.
Twin Hyper Power-Drive
Hyper Power-Drive Subwoofer Response
Subwoofer Response
First, the Bass Level Detection
Circuit checks the level of low
key on the front panel: the Subwoofers Woofer Response frequencies in the incoming signal
rolling control panel comes into (MX-J900/MX-J700) and sets the optimum boosting
view, revealing keys for sound The MX-J900 and MX-J700 each levels. Then the Level
adjustment and source control. present a sturdy appearance and Compensation Circuit applies the
At the touch of the deliver sturdy sound to go with it, optimum amount of bass boost.
OPEN/CLOSE key, the panel is reaching down to 30Hz. How? You fully enjoy wide dynamic range
rotated to conceal the They feature a 4-way bass-reflex as well as solid, rich bass from any
secondary controls. The design speaker design centered around Frequency music source—irrespective of
allows both a clean, sharp look the innovative Twin Hyper Power- volume level and program type.
Drive Subwoofers. And there is have a lightweight, elastic
more behind its doubly rich bass polyether urethane edge to help JVC Home-Theater Audio—Dolby
sound. extend bass frequencies. The 6- Pro Logic with a package of five
With the Multi-Amplifier layer and speakers (MX-J800)
System, the subwoofers and main 4-layer voice coils (MX-J900 and The MX-J800 comes complete with
speakers are driven by the MX-J700, respectively) allow a center speaker and a pair of
separate power amplifiers— efficient driving and pure bass surround speakers, as well as a
150W/channel and 50W/channel sound, stripped of unwanted Dolby Pro Logic decoder, a
(total 400W) with the MX-J900, frequencies. separate amp for each channel,
and 100W/ A weight ring is coupled to the and front speakers.
channel and 50W/channel cone diaphragm to keep bass
(total 300W)with the MX-J700, response under tight control. Play & Exchange 3-CD changer
respectively. This design ensures The 3-disc changer comes with
both efficient power delivery and Extended Super Bass Circuit three separate trays: conveniently,
higher clarity in mids and highs. (MX-J900/MX-J700) you can pull out trays not currently
The large-diameter diaphragms The Extended Super Bass Circuit in use and put in new discs without
is another JVC innovation for stopping music.
powerful bass. It generates
harmonics of bass frequencies Velocity-sensitive rotary encoder
that are below the lowest playable volume control (MX-J800)
frequency and adds them to the The rotary encoder volume control
audible signals by shifting them features two operation modes. Turn
into the audible range. The result the knob quickly to instantly
is high-density bass sound. The increase or decrease the level, or
boost circuit extends the low- turn it slowly to fine-adjust the level.
frequency range, and the Q Level is displayed on an attractive,
Control circuit actively controls its easy-to-read fluorescent display.
operation, to achieve bass that
remains clean and undistorted COMPU PLAY (all models)
even at high volume. Just touch a single button to choose
a source (CD, cassette or tuner),
S.A. BASS (Signal Adaptive Bass and the system will automatically
System) (MX-J800) turn on and initiate all steps to start
Conventional bass boost circuits the music.
are designed to increase a
specific frequency range, which 3 preset electronic equalizations
sometimes alters the tonal plus
character of the vocals and 3 manual settings
instruments. But this doesn’t apply Apply matched equalization
to JVC’s intelligent S.A. BASS according to the type of music you
(Signal Adaptive Bass System). play. Three custom responses for
ROCK, POP and CLASSIC reside
in memory for instant recall.
Moreover, with top models, you can
create three custom equalizations
on your own and recall them at a
touch.

Active Bass Extension


Active-Bass Extension gives you a
clean, profound bass. With the
MX-J500, you can customize the
response of low frequencies to your
preference in four steps.
MX-J900
Amplifier/General 3-CD Triple-Tray Changer Speaker System
Power output: Subwoofer: Play & Exchange System Twin Hyper Power-
Compact Component 150 watts per channel; Main Dual 1-bit D/A converters Drive 77/8” (20cm)
System Speaker: 50 watts per channel 32-track programming subwoofers
Powered Rolling Panel 16-track program chart 4-way bass-reflex
Multi-amplifier system 3-disc program/smart random/ design: 77/8” (20cm)
Independent subwoofer volume repeat play cone subwoofer,
control (8-step) with edge light Auto edit functions 77/8” (20cm) cone
Extended Super Bass Optical digital output woofer, 2” (5cm) cone
SPI (Spectro Peak Indicator) midrange, 13/16 ” (2cm)
Electronic equalizations Cassette Deck dome tweeter
(3 presets plus 3 manual Double auto-reverse transports
settings) Full-logic control
AUX input/output CD synchro start recording
Live Surround (Dance Club/Hall/ Auto tape selector
Stadium) (Normal/CrO2)
COMPU PLAY Music Scan

Tuner Hyper Power-Drive Subwoofer


15 AM and 30 FM station
memory
Programmable timer (Daily,
Record, Sleep)

Extended Super Bass Circuit


(MX-J900/MX-J700)

Response with
Extended Super Bass
The Extended Super Bass Circuit 1
generates harmonics of bass
frequencies that are below
the lowest playable frequency and
adds them to the audible signals by
shifting them into the audible range.
Response without The result is high-density bass
Extended Super Bass
sound. The boost circuit extends
the low-frequency range, 2 3
and the Q Control circuit actively
controls its operation, to achieve
Twin Hyper Power-Drive Subwoofers
bass that remains clean and
undistorted even at high volume. 1 Ultra Low Frequencies
Frequency 2 Low Frequencies
3 Ultra Low Frequencies
MX-J800
Compact Component
System

Amplifier
Power output: Front: 120 watts
per channel; Center: 30 watts;
Rear: 15 watts per channel
Powered Rolling Panel COMPU PLAY 3-disc program/smart random/ 4-way bass-reflex design:
Dolby Pro Logic Surround— repeat play 65/16” (16cm) cone woofer,
complete with 5 speakers Tuner Auto edit functions 2” (5cm) cone midrange,
Dolby 3 Stereo 15 AM and 30 FM station Optical digital output 1 5/8” (4cm) cone tweeter,
13
SPI (Spectro Peak Indicator) memory / 16” (2cm) dome supertweeter
Electronic equalizations Programmable timer (Daily, Cassette Deck Magnetically shielded
(3 presets plus 3 manual Record, Sleep) Double auto-reverse transports
settings) Full-logic control Center and Surround Speakers
AUX input/output 3-CD Triple-Tray Changer CD synchro start recording 33/ 16” (8cm) cone center
Subwoofer output Play & Exchange System Music Scan speaker—magnetically shielded
Live Surround (Dance Club/Hall/ Dual 1-bit D/A converters 33/16” (8cm) cone surround
Stadium) 32-track programming Speaker System speaker 2
S.A. BASS (2-step) 16-track program chart Labyrinth Aeroport System

MX-J700
Compact Component
System

Amplifier/General
Power output: Subwoofer:
100 watts per channel; Main
Speaker: 50 watts per channel
Powered Rolling Panel
Multi-amplifier system Tuner 3-disc program/smart random/ Speaker System
Independent subwoofer volume 15 AM and 30 FM station repeat play Twin Hyper Power-Drive
control (6-step) memory Auto edit functions 65/16” (16cm) subwoofers
Extended Super Bass Programmable timer (Daily, Optical digital output 4-way bass-reflex design:
Electronic equalizations Record, Sleep) 6 5/16” (16cm) cone subwoofer,
(3 presets plus 3 manual Cassette Deck 65/16” (16cm) cone woofer,
settings) 3-CD Triple-Tray Changer Double auto-reverse transports 2” (5cm) cone midrange,
13
AUX input Play & Exchange System Full-logic control /16” (2cm) dome tweeter
Live Surround (Dance Club/Hall/ Dual 1-bit D/A converters CD synchro start recording
Stadium) 32-track programming Auto tape selector
COMPU PLAY 16-track program chart (Normal/CrO2)
Music Scan
Notice: It should be noted that it may be unlawful to re-record pre-recorded tapes, records or
“Dolby,” the double-D symbol and “Dolby Pro Logic” are discs without the consent of the owner of copyright in the sound or video recording, broadcast
MX-J500
Compact Component
System

Amplifier/General Tuner 3-disc program/smart random/ Speaker System


Power output: 120 watts per 15 AM and 30 FM station repeat play 3-way bass-reflex design:
channel memory Optical digital output 65/ 16” (16cm) cone woofer,
Powered Rolling Panel Programmable timer (Daily, 2” (5cm) cone midrange,
Electronic equalizations Record, Sleep) Cassette Deck 13
/16” (2cm) dome tweeter
(3 presets plus 3 manual Double auto-reverse transports Punched metal grilles
settings) 3-CD Triple-Tray Changer Full-logic control
AUX input Play & Exchange System CD synchro start recording
Live Surround (Dance Club/Hall/ Dual 1-bit D/A converters Auto tape selector
Stadium) 32-track programming (Normal/CrO2)
Active Bass Extension (4-step) 16-track program chart Music Scan
COMPU PLAY Auto edit functions

MX-J300
Compact Component
System

Amplifier/General Tuner Cassette Deck Speaker System


Power output: 100 watts per 15 AM and 30 FM station Double transports: auto-reverse 2-way bass-reflex design:
channel memory with one 65/ 16” (16cm) cone woofer,
Powered Rolling Panel Programmable timer (Daily, Full-logic control 15/8” (4cm) cone tweeter
Level meter Record, Sleep) CD synchro start recording Dual Duct System
Electronic equalizations Auto tape selector Punched metal grilles
(3 presets) 3-CD Triple-Tray Changer (Normal/CrO2)
AUX input Play & Exchange System
Live Surround (Dance Club/Hall/ Dual 1-bit D/A converters
Stadium) 32-track programming
Active Bass Extension 3-disc program/smart random/
COMPU PLAY repeat play
MX-J200
Compact Component
System

Amplifier/General
Power output: 60 watts per Tuner 3-disc program/smart random/ Speaker System
channel 15 AM and 30 FM station repeat play 2-way bass-reflex design:
Level meter memory 65/16” (16cm) cone woofer,
Electronic equalizations Programmable timer (Daily, Cassette Deck 1 5/ 8” (4cm) cone tweeter
(3 presets) Record, Sleep) Double transports: auto-reverse Dual Duct System
AUX input with one Punched metal grilles
Live Surround (Dance Club/Hall/ 3-CD Triple-Tray Changer Full-logic control
Stadium) Play & Exchange System CD synchro start recording
Active Bass Extension Dual 1-bit D/A converters Auto tape selector
COMPU PLAY 32-track programming (Normal/CrO2)

MX-J100
Compact Component
System

Amplifier/General Tuner 24-track programming Speaker System


Power output: 40 watts per 15 AM and 30 FM station 3-disc program/smart random/ 2-way bass-reflex design:
channel memory repeat play 4 3/ 4” (12cm) cone woofer,
13
Electronic equalizations Programmable timer (Daily, /16” (2cm) cone tweeter
(3 presets) Record, Sleep) Cassette Deck Dual Duct System
AUX input Double transports
Active Bass Extension 3-CD Changer Full-logic control
COMPU PLAY Carousel-type changer, with CD synchro start recording
Play & Exchange System Dubbing
FS series
These are the upgraded lifestyle
CD systems from JVC for 2000.
They combine futuristic,
individualized styling, pure hi-fi
sound and fingertip ease of use
in handy dimensions.

FS -G6
FS Series Component
System

Amplifier/General
■ Power output: 25 watts per channel
■ MOS FET amplifier
■ Motor-driven sliding panel
■ Multi Jog Control
■ Active Bass Extension
■ Subwoofer output
■ Electronic bass/treble controls
■ AUX input
■ Velocity-sensitive rotary encoder
volume control
■ COMPU PLAY
■ Clock/timer

Tuner
■ 15 AM and 30 FM station memory
■ Auto preset
Attractive styling and fully separate transistors. Because the use of MOS FET
chassis allows the elimination of a drive stage and Linear phase
a much simpler circuit configuration, the speaker CD Player
Each component in the FS-G6 is self-
compact MOS FET amp lets you enjoy alignment ■ 1-bit P.E.M. D.D. Converter
contained and separate. This means (1)
■ Program (32 tracks)/random/
you can combine FS-G6 components as clear, pure sound. The voice coil of the
repeat play
you like, (2) you can lay them out the way woofer is vertically aligned
■ Optical digital output
you like, and (3) you enjoy consistently 1-bit P.E.M. D.D. Converter with that of the tweeter to
high sound quality because of well- JVC’s 1-bit P.E.M. D.D. Converter features ensure the sounds from both
Cassette Deck
regulated power supplies. accurate, high-precision D/A conversion. speakers reach the listener at
■ Full-logic control
The VANS 4th-order noise shaper reduces the same instant. Sharp sound imaging
■ Auto-reverse record/play
MOS FET amplifier in discrete quantization noise to a negligible level. A results.
■ Dolby B noise reduction
configuration pair of P.E.M. DACs improve resolution by
■ CD synchro start recording
MOS FETs (Metal-Oxide Semiconductor four times, ensuring the high signal-to-
■ Music Scan
Field Effect Transistors) provide higher noise ratio, while a simple low-pass filter
■ Auto tape selector (Normal/CrO2 )
linearity, better thermal stability and lower offers superior frequency and phase
drive currents than common bipolar responses. Speaker System
■ 2-way bass-reflex design:
Balanced Dome Tweeter 4 9/ 16” (11.5cm) cone woofer,
The Balanced Dome Tweeter provides 13/ 16” (3cm) Balanced Dome Tweeter
crisp high frequency sound with better ■ Linear phase speaker alignment
transient response Side-View
than conventional Schematic

Motor-Driven Sliding Panel tweeters. Linear Phase Speaker Alignment


F S S E R I E S

Active Hyper-Bass PRO COMPU PLAY


(FS-V30/FS-V10) Just touch a single button to choose a source (CD,
The Active Hyper-Bass PRO Sound System features a Q cassette or tuner), and the system will automatically
(bandwidth) control circuit instead of a cut-off frequency turn on and initiate all steps to start the music.
circuit. Dynamically controlling the range of the boost
frequencies through feedback according to output level,
it’s capable of dynamic bass response and clear vocals,
with no drop in the midrange response.

Motor-Driven CD Door with Vertical


Loading

FS-V30 ■ Motor-driven CD door with


disc illumination
FS Series Component
■ 1-bit D/A
System
converter
■ Program
(20 tracks)/
random/
Amplifier/General repeat play
■ Power output: 26 watts per channel ■ 15-track
■ Active Hyper-Bass PRO program chart
■ Electronic bass/treble controls ■ Optical digital

■ AUX input/output output


■ COMPU PLAY
■ Clock/timer (Daily, Record, Sleep) Cassette Deck
■ Display dimmer ■ Full-logic control
■ Auto-reverse record/play
Tuner ■ CD synchro/complete recording

■ 15 AM and 30 FM station memory ■ Multi-source one-touch recording

■ Auto preset ■ Auto tape selector (Normal/CrO2 ) 39/16” (9cm) cone woofer and
Speaker System 15/8” (4cm) cone tweeter
CD Player ■ Bass-reflex 2-way design: ■ Detachable grilles

■ Vertical loading system

FS-V10
FS Series Component
System ■ Motor-driven CD door
■ 1-bit D/A converter
■ Program
(20 tracks)/
random/
Amplifier repeat play
■ Power output: 26 watts per channel ■ 15-track

■ Active Hyper-Bass PRO program chart


■ Electronic bass/treble controls
■ AUX input Cassette Deck
■ COMPU PLAY ■ Full-logic control
■ Clock/timer (Daily, Record, Sleep) ■ Auto-reverse record/play
■ CD synchro/complete recording
Tuner ■ Multi-source one-touch recording

■ 15 AM and 30 FM station memory ■ Auto tape selector (Normal/CrO2 )

■ Auto preset Speaker System


■ Bass-reflex design: 33/ 16” (8cm) full-
CD Player range speaker
■ Vertical loading system
DVD digital theater system
The TH-A10 is a simple, stylish all-inclusive digital theater
system complete with a DVD Video player and a Dolby
Digital/DTS surround decoder. Having your dream home
theater is now much simpler than you think.

Simple operation connect the subwoofer to the center


The DVD Video player, control unit. Speaker cables are
Dolby Digital/DTS decoder, supplied with mini plugs for one
control functions and AM/FM tuner touch connection.
are all incorporated in a stylish,
low-profile unit. Two remotes are Satellite/subwoofer
included—an illuminated system—five satellites
full-function multi-brand remote with a powered
and a simple remote. GUI subwoofer
(Graphical User Interface) through Front, center and rear speakers are
OSD (On-Screen Display) allows bookend-sized so they may be
step-by-step instructions on easily set up wherever convenient.
operation. Just like pieces of art, these satellites
are finished in aluminum housing to
Easy connections enhance beauty and also to deliver
All six amplifiers for front, center, clear, uncolored sound. The
rear and subwoofer channels are powered subwoofer adds drama to
housed in the subwoofer enclosure. what you see on the screen.
It takes just a single cable to

Connection Diagram

Total 200W Power Output

■ 10-bit/27MHz video D/A converter ■ Compact full-range ■ Power output: Total 200W

TH-A10
■ 24-bit/96kHz audio D/A converter bass-reflex speaker system ■ Extra-large 10-inch
■ Digital Acoustics Processor: ■ Aluminum cabinet for quality sound (25cm) cone unit
DVD Digital 5 modes (Theater/Dance Club/ reproduction for powerful bass
Theater System Live Club/Hall/Pavilion) and decor matching
■ Fluorescent display ■ Wall-mounting
■ Two remote control units: bracket included
Full-function and simple Powered Subwoofer
■ DVD functions: Resume, Angle List ■ Built-in 6-channel
Digest, Strobe and Zoom amplifier
■ “Theater Position” for picture adjustment
■ AV COMPU LINK
■ Terminals: 4 analog and
■ All-in-one center unit combining a DVD 3 digital audio inputs,
Video/VCD/CD player and AM/FM tuner 2 analog and
■ 5-satellite-speaker/powered subwoofer 1 digital audio outputs,
system 2 composite and
■ Complete with Dolby Digital/ 2 S-VHS video inputs,
DTS surround decoder 2 composite and
Easy connection and installation 2 S-VHS video outputs
■ Easy operation: auto power on and auto ■ Enhanced COMPU LINK
speaker setting Control System
■ GUI (Graphical User Interface) Satellite Speaker
Center Unit
“Dolby,” the double-D symbol and “Dolby Digital” are trademarks of Dolby Laboratories Screen picture is simulated.
The KABOOM BOX from JVC! You know it as an
unshakable tubular CD portable that shakes you with
deep bass sound. But now it’s also a suite of
a musician’s tools with guitar amp, drum pad
and rhythm machine.

Be a DJ with four drum


pads and scratch
(RV-DP100)
Have a good
time playing
the DJ you’ve
always
wanted to
6 1/2” (16cm) be! The
Super Woofer RV-DP100 features a 4-drum pad
Total 52W output— with five different combinations
Super Twin
Ducts dynamic high power called standard, percussions, voice,
(RV-DP100) etc.—20 sound samples in all. The
The KABOOM BOX comes with scratch jog offers two types of
two Super Woofers and two effects simulating a stylus scratching
33 /16” (8cm) full-range units— the surface of an analog record.
a total of four speakers. And there
are two amps for the full-range Long labyrinth ducts
units and another two exclusively (RV-B550)

3 3/ 16” (8cm) for the dual woofers, delivering The sound from the rear is routed
Full-Range Speaker total power output of 52 watts. through long, winding labyrinth
61/2” (16cm) Using the Super Woofer volume ducts to extend the frequency
Super Woofer control, you can adjust deep bass response down to the lowest
Twin 61/2” (16cm) Super
to your liking. frequencies.
Woofers and Super Twin
This is
Ducts for rock-bottom
Play the guitarist— another JVC
bass (RV-DP100)
a built-in guitar amp approach to
A pair of extra-large 61/2” (16cm)
with rhythm machine delivering a
Super Woofers gives you powerful,
(RV-DP100) big sound
deep bass sound in combination
Brush up your guitar-strumming from a small
with a number of JVC technologies.
skills or play duets with your package.
Units are mounted back-to-back to
cancel out vibrations, while the favorite musician on CD or
cassette. The RV-DP100 features a Super Exciter Bass Circuit
Super Twin Ducts deliver crisp,
built-in guitar amp to let you rock (RV-DP100)
Foamed Diaphragm 6-Layer with the greatest. Two standard This is a compressor circuit that
Rubber Voice input jacks accept the plugs of your achieves deep, rich bass. It works
Edge Coil
guitar and your vocal mic, each by shifting inaudibly low
Weight with its own level control. frequencies into an audible, higher
Ring There’s no rhythm you can’t jam frequency range and adding them
along with as you master your to the original sound, with the
Damper
chords. The audible sounds boosted.
RV-DP100
comes with ACS (Active Clear Sound)
extended bass sound. A weight ring 36 rhythms ACS actively controls high
coupled to the woofer helps extend you can frequencies to prevent deterioration
response down to under 100Hz. choose of the signal-to-noise ratio and
A 6-layer voice coil shifts down the from— improve clarity for better balance
lowest resonance frequency and ranging with deep lows. The circuit delivers
increases driving power. The woofer from classic balanced response over the entire
units also feature foamed rubber 8 beat to audible range by activating only
surround to achieve both high funk and when a high-frequency signal
linearity and low distortion. rap. occurs.
Shoulder Strap

RV-DP100
Powered Woofer CD System

Guitar and mic inputs with level


controls
Built-in guitar amp
4-drum pad (20 patterns)
Rhythm machine (36 sound
samples)
Ambient sound patterns
(2 patterns)
Scratch jog (2 patterns)
Twin 61/ 2” (16cm) Super
Woofers with volume control
Super long twin ducts
Rugged tubular construction
Super Exciter Bass circuit
High power: Total 52W
4-amp configuration
Center-mount transformer 15 AM and 30 FM station CD synchro-start recording * With optional car battery adapter (CA-R150)
Full-logic auto-reverse cassette memory Clock/timer
AUX IN 1-bit D/A converter Shoulder strap with remote
DC IN for car use* Program (20 tracks)/repeat/ control case provided
ACS (Active Clear Sound) random play

Shoulder Strap

RV-B550
CD Portable System

RV-B550RD

RV-B550BU

Shoulder Strap

Active Hyper-Bass PRO DC IN for car use* Program (20 tracks)/repeat/


(2 Steps/Off) ACS (Active Clear Sound) random play
Long Labyrinth Duct Speaker illumination CD synchro-start recording
High power: 12 watts per 3 preset equalization patterns Clock/timer
channel (Beat/Pop/Clear) Shoulder strap with remote
4-layer voice coil 15 AM and 30 FM station control case provided
Full-logic auto-reverse cassette memory Speaker Illumination
* With optional car battery adapter (CA-R150)
AUX IN 1-bit D/A converter The illuminated center cap blinks
with the rhythm of the music.
Kaleido Clock Display indicator to help you set the built- controlling the range of the boost
with Multi Jog Control in timer in familiar analog style. frequencies through feedback
(RC-BZ6) according to output level, it’s
The Kaleido Clock Display brings Active Hyper-Bass Pro capable of dynamic bass response
lively animation to our CD (RC-BZ6) and clear vocals, with no drop in
Portable System. Normally it The Active Hyper-Bass PRO Sound the midrange response.
functions as an analog clock. System features a Q (bandwidth)
When used with the Multi Jog control circuit instead of a cut-off
Control it turns into an animated frequency circuit. Dynamically
Kaleido Clock Display with
Lively Animation

RC-BZ5LB

RC-BZ6 RC-BZ5RD

RC-BZ6 RC-BZ5
Active Hyper-Bass PRO (on/off) 1-bit D/A converter
1-bit D/A converter CD synchro-start recording
CD Portable System CD synchro-start recording CD Portable System Digital tuner with auto preset
COMPU PLAY 15 AM and 30 FM station
Digital tuner with auto preset memory
Remote control 15 AM and 30 FM station Remote control Repeat play
3 preset equalization patterns memory 3 preset equalization patterns Clock/timer (with sleep)
(Beat/Pop/Clear) Repeat play (Beat/Pop/Clear) Bass-reflex design speaker
Kaleido-Clock LCD display with Clock/timer (with sleep and COMPU PLAY Power output: 5W 2
back light wake-up)
Multi-Jog Control (Clock/timer, Bass-reflex design speaker
Volume) Power output: 5W 2

RC-BX30
CD Portable System

CD remote control Tone control


1-bit D/A converter PHONES/AC inputs
Bass boost ALC (Automatic recording Level
Repeat play Control)
AM/FM tuner Power output: 2W 2
portable CD/MD
T he magic of
digital sound—
anywhere,
anytime.
A line of portable
CD players for
rock concerts on
the run.

High-Speed Pickup Servo: Dynamic Suspension Remote Control for XL-PG51


Portable CD When mistracking occurs, the System: Contoured butyl rubber
Players High-Speed Servo moves the pickup dampers and springs protect the
quickly back to its original position. pickup from shocks and
Anti-Shock Protection vibrations.
40-Second Shockproof
Memory: The one-chip IC 40-Second Shockproof Storing Music in Restoring/Transmitting
combines 40-second memory with Memory Fragments Music
the “defrag” LSI. When a jolt
causes pickup mistracking, the
memory stores the music in
fragments. The LSI then “defrags”
the music and sends it out in the
correct order to the D/A Fragmented Music No break in music due to shocks
converter—your music is proof lasting 40 seconds or longer
Newly-Developed One-Chip IC
against shocks.

Portable MD DACB (Digital Active DACB’s sound is especially rich ensure interruption-free playback.
Clear Bass) and distortion is low because a
Recorder DSP (Digital Signal Processor) is Long play time
DACB gives you crisp lows and
clear, wide-range response responsible for the signal control. The XM-R70 keeps the music
Jog control editing
irrespective of volume levels. coming nonstop. It plays for up to
The XM-R70 lets you record live
The boost circuit is controlled 40-Second Anti-Shock 38 hours* and records up to 18
mic sound, an analog line source
according to the detected output Memory hours* continuously.
or a digital source. It’s easy to edit
level, ensuring low distortion, even During playback, forty seconds of
recorded tracks thanks to the jog * When running on the built-in rechargeable
at high volume. Low frequencies, music are constantly stored in battery and an optional alkaline battery.
dial and oversized display. Just
centered at about 70Hz, are memory. When a jolt affects
turn and click the dial to join,
boosted without degrading clarity playback, the stored music is
divide, shuffle, erase and name
in the mid and high ranges. recalled from the memory to
tracks.
P o r t a b l e C D P l a y e r s

XL-PG51
Heat-resistant casing
Auto power-off
Portable CD Player Hold switch
PHONES/DC inputs
AC adapter and headphones
with remote control provided
40-second Anti-Shock Rechargeable batteries ( 2)
Protection provided
Remote control Car battery adapter (Optional)
Hyper-Bass Sound (on/off)
11-hour playback* * With alkaline batteries.
1-bit D/A converter
Program (20 tracks)/repeat/
intro/shuffle (random) play

XL-PV310
Program (20 tracks)/repeat/
intro/shuffle (random) play
Portable CD Player Heat-resistant casing
Auto power-off
Hold switch
PHONES/DC inputs
Cassette adapter and car AC adapter and headphones
battery adapter provided provided
40-second Anti-Shock Rechargeable batteries
Protection (Optional)
Hyper-Bass Sound (on/off)
11-hour playback* * With alkaline batteries.

1-bit D/A converter

XL-PG31
Heat-resistant casing
Auto power-off
Portable CD Player Hold switch
PHONES/DC inputs
AC adapter and headphones
provided
40-second Anti-Shock Rechargeable batteries
Protection (Optional)
Hyper-Bass Sound (on/off) Car battery adapter (Optional)
11-hour playback*
1-bit D/A converter * With alkaline batteries.
Program (20 tracks)/repeat/
intro/shuffle (random) play

P o r t a b l e M D R e c o r d e r

XM-R70
Remote control with backlit LCD
Digital synchro recording
Portable MD Recorder Mic and line (analog/digital)
inputs
DACB (Digital Active Clear Bass)
Random/repeat play
Hold switch
Optical digital cable/
rechargeable lithium ion battery/
Easy 5-mode editing with side headphones/carrying case
jog (Join/Divide/Move/Erase/Title) provided
Sampling rate converter Slim, compact and lightweight
(32kHz/44.1kHz/48kHz)
Extra-long 38-hour playback and * With rechargeable and alkaline batteries.
18-hour recording*
40-second Anti-Shock Protection
SPECIFICATIONS
FS Series
FS-G6 FS-V30 FS-V10
AMPLIFIER SECTION
Output Power 25 watts per channel, min. RMS, at 6 ohms, at 1kHz, 26 watts per channel, min. RMS, at 4 ohms, from 80Hz 26 watts per channel, min. RMS, at 4 ohms, from 80Hz
with no more than 10% total harmonic distortion to 20kHz, with no more than 10% total harmonic distortion to 20kHz, with no more than 10% total harmonic distortion
CD PLAYER SECTION
Dynamic Range (1kHz) 95dB 85dB 85dB
S/N Ratio 100dB 90dB 90dB
CASSETTE DECK SECTION
Frequency Response 30 - 16,000Hz (Chrome) 60 - 15,000Hz (Chrome) 60 - 15,000Hz (Chrome)
Signal-to-Noise Ratio 63dB (Dolby B NR, Chrome) 52dB* (Chrome) 52dB* (Chrome)
Wow and Flutter 0.1% (WRMS) 0.15% (WRMS) 0.15% (WRMS)
TUNER SECTION
Bands FM/AM FM/AM FM/AM
Dimensions (W H D): Amplifier 7 3/ 1 6 3 1/ 4 123/ 8 inches (182 81 313 mm) 61 /4 9 3/ 1 6 10 7/8 inches (158 233 275 mm) 6 1/ 4 9 3/1 6 107 /8 inches (158 233 275 mm)
CD Player/Tuner 7 3/1 6 3 1/4 123/ 8 inches (181 81 313 mm)
Cassette Deck 7 3/1 6 3 1/4 12 inches (181 81 304 mm)
Weight: Amplifier 8.4 lbs (3.8kg) 7.3 lbs (3.3kg) 7.3 lbs (3.3kg)
CD Player/Tuner 4.2 lbs (1.9kg)
Cassette Deck 4.2 lbs (1.9kg)
SPEAKER SECTION
Type 2-way, bass-reflex 2-way, bass-reflex Bass-reflex
Speakers: Woofer 4 9/ 1 6-inch (11.5cm), cone 39 /1 6-inch (9cm), cone 3 3/ 1 6-inch (8cm), full-range, cone
Tweeter 1 3/ 1 6-inch (3cm), dome 15/ 8-inch (4cm), cone
Impedance 6 ohms 4 ohms 4 ohms
Dimensions (W H D) 6 3/1 6 11 5/8 9 3/ 1 6 inches 59/ 1 6 91/1 6 81 5/ 1 6 inches 5 9/ 1 6 9 1/ 1 6 8 5/ 1 6 inches
157 295 232 mm 140 230 226 mm 140 230 211 mm
Weight 7.3 lbs (3.3kg) 4.2 lbs (1.9kg) 4.0 lbs (1.8kg)

KABOOM BOX CD Systems


RV-DP100 RV-B550
Bands FM/AM FM/AM
Power Source: AC 120V, 60Hz 120V, 60Hz
DC D (13F) 10 D (13F) 8
Car battery* Car battery*
Speakers: Full-Range 33 /1 6” (8cm) 2 4” (10cm) 2
Subwoofer 61/2” (16cm) 2
Power Output: Full-Range 6 watts per channel, min. RMS, at 4 ohms 12 watts per channel, min. RMS, at 4 ohms
(with no more than from 150Hz to 15kHz from 150Hz to 15kHz
10% THD) Subwoofer 20 watts per channel, min. RMS, at 4 ohms at 60Hz
Dimentions (W H D) 25 101/ 2 121/ 4 inches 21 3/8 89/1 6 101/ 4 inches
634 256.5 311 mm 542 216 260 mm
Weight (without batteries) 22.5 lbs (10.2kg) 13.5 lbs (6.1kg)
*CA-R150 car battery adapter is optionally available.

CD Portable Systems
RC-BZ6 RC-BZ5 RC-BX30
Bands FM/AM FM/AM FM/AM
Power Source: AC 120V, 60Hz 120V, 60Hz 120V, 60Hz
DC D (13F) 8 D (13F) 8 D (13F) 6
Car battery* Car battery*
Speakers 4-inch (10cm) 2 4-inch (10cm) 2 3-inch (8.9cm) 2
Power Output: 5 watts per channel, min. RMS, at 4 ohms, 5 watts per channel, min. RMS, at 4 ohms, 2 watts per channel, min. RMS, at 4 ohms,
(with no more than 10% THD) from 150Hz to 15kHz from 150Hz to 15kHz from 150Hz to 10kHz
Dimensions (W H D) 17 1/4 6 1 5/1 6 101/ 1 6 inches 17 1/4 61 5/1 6 10 1/ 1 6 inches 15 1 3/1 6 61 1/1 6 9 3/1 6 inches
438 176 255 mm 438 176 255 mm 401 169 232 mm
Weight (without batteries) 9.3 lbs (4.2kg) 8.9 lbs ( 4.0kg) 7.3 lbs.(3.3kg)
*CA-R150 car battery adapter is optionally available.

Portable CD Players
XL-PG51 XL-PV310 XL-PG31
Power Source: AC 120V, 60Hz (AC adapter) 120V, 60Hz (AC adapter) 120V, 60Hz (AC adapter)
DC 15A 2 15A 2 15A 2
Rechargeable battery ( 2) Rechargeable battery** ( 2) Rechargeable battery** ( 2)
Car battery* Car battery Car battery*
Power Output: Headphones 9mW 2, at 10% THD, 16 ohms 9mW 2, at 10% THD, 16 ohms 9mW 2, at 10% THD, 16 ohms
Dimensions (W H D) 5 9/1 6 1 5/1 6 5 1 3/1 6 inches 59/1 6 15 /1 6 51 3/ 1 6 inches 5 9/1 6 1 5/1 6 5 1 3/1 6 inches
140 33 147.5 mm 140 33 147.5 mm 140 33 147.5 mm
Weight (without batteries) 8.8 oz (250g) 8.8 oz (250g) 8.8 oz (250g)
*Car battery adapter is optionally available. **Optional.

Portable MD Recorder
XM-R70
Power Source: AC 120V, 60Hz (AC adapter)
DC 15A 3
Rechargeable battery ( 1)
Power Output: Headphones 5mW 2, at 10% THD, 16 ohms
Dimentions (W H D) 3 5/ 1 6 1 3/1 6 3 5/ 8 inches
83.2 19.5 91 mm
Weight (without batteries) 5.18 oz (147g)
MX Series
MX-J900 MX-J800 MX-J700 MX-J500 MX-J300 MX-J200 MX-J100
3-CD Changer Double 3-CD Changer Double 3-CD Changer Double 3-CD Changer Double 3-CD Changer Double 3-CD Changer Double 3-CD Changer Double
Cassette Receiver Cassette Receiver Cassette Receiver Cassette Receiver Cassette Receiver Cassette Receiver Cassette Receiver
AMPLIFIER SECTION
Output Power: Front Subwoofer: 150 watts 120 watts per channel, Subwoofer: 100 watts 120 watts per channel, 100 watts per channel, 60 watts per channel, 40 watts per channel,
per channel, min. RMS, min. RMS, driven into per channel, min. RMS, min. RMS, driven into min. RMS, driven into min. RMS, driven into min. RMS, driven into
driven into 6 ohms, 6 ohms, at 1kHz, driven into 6 ohms, 6 ohms, at 1kHz, 6 ohms, at 1kHz, 6 ohms, at 1kHz, 6 ohms, at 1kHz,
at 63Hz, with no more with no more than at 63Hz, with no more with no more than with no more than with no more than with no more than
than 10% total 10% total harmonic than 10% total 10% total harmonic 10% total harmonic 10% total harmonic 10% total harmonic
harmonic distortion distortion harmonic distortion distortion distortion distortion distortion
Main Speaker: 50 watts Main Speaker: 50 watts
per channel, min. RMS, per channel, min, RMS,
driven into 6 ohms, driven into 6 ohms,
at 1kHz, with no at 1kHz, with no
more than 10% total more than 10% total
harmonic distortion harmonic distortion
Center 30 watts, min RMS,
driven into 8 ohms,
at 1kHz, with no more
than 0.9% total
harmonic distortion
Rear 15 watts per channel,
min. RMS, driven into
16 ohms, at 1kHz,with
no more than 0.9% total
harmonic distortion
Total Harmonic Distortion at Half-Rated Power 0.07% 0.05% (1kHz) 0.07% 0.07% (1kHz) 0.05% (1kHz) 0.05% (1kHz) 0.05% (1kHz)
(63Hz, at Subwoofer) (63Hz, at Subwoofer)
CASSETTE DECK SECTION
Frequency Response 50 - 14,000Hz (Chrome) 50 - 14,000Hz (Chrome) 50 - 14,000Hz (Chrome) 50 - 14,000Hz (Chrome) 50 - 14,000Hz (Chrome) 50 - 14,000Hz (Chrome) 50 - 14,000Hz (Chrome)
50 - 14,000Hz (Normal) 50 - 14,000Hz (Normal) 50 - 14,000Hz (Normal) 50 - 14,000Hz (Normal) 50 - 14,000Hz (Normal) 50 - 14,000Hz (Normal) 50 - 14,000Hz (Normal)
Signal-to-Noise Ratio 57dB* (Chrome) 57dB* (Chrome) 57dB* (Chrome) 57dB* (Chrome) 57dB* (Chrome) 57dB* (Chrome) 57dB* (Chrome)
Wow and Flutter 0.15% (WRMS) 0.15% (WRMS) 0.15% (WRMS) 0.15% (WRMS) 0.15% (WRMS) 0.15% (WRMS) 0.15% (WRMS)
CD CHANGER SECTION
Dynamic Range 85dB 85dB 85dB 85dB 85dB 85dB 85dB
Signal-to-Noise Ratio 90dB 90dB 90dB 90dB 90dB 90dB 90dB
Total Harmonic Distortion 0.01% 0.01% 0.01% 0.01% 0.01% 0.01% 0.01%
TUNER SECTION
Bands AM/FM AM/FM AM/FM AM/FM AM/FM AM/FM AM/FM
Dimensions (W H D) 107/ 1 6 131/4 141 /2 in. 107 /1 6 127 /1 6 137/ 1 6 i n .1 07/1 6 13 1/ 4 14 1/2 in. 10 7/1 6 131/4 141/ 2 in. 107/ 1 6 12 7/1 6 141/4 in. 107/1 6 127 /1 6 141/ 4 in. 101 1/1 6 121/ 2 15 7/1 6 in.
265 335 368 mm 265 315 341 mm 265 335 368 mm 265 335 368 mm 265 315 361 mm 265 315 361 mm 270 317 392 mm
Weight 22.7 lbs (10.3kg) 20.9 lbs (9.5kg) 21.8 lbs (9.9kg) 21.6 lbs (9.8kg) 19.2 lbs (8.7kg) 15.9 lbs (7.2kg) 15.3 lbs (6.9kg)
Speaker System Speaker System Speaker System Speaker System Speaker System Speaker System Speaker System
Type 4-way, 4-speaker, bass- 4-way, 4-speaker, bass- 4-way, 4-speaker, bass- 3-way, 3-speaker, 2-way, 2-speaker, 2-way, 2-speaker, 2-way, 2-speaker,
reflex, Twin Hyper reflex, Labyrinth Aeroport reflex,Twin Hyper bass-reflex bass-reflex, bass-reflex, bass-reflex,
Power-Drive Subwoofer Speaker System, Power-Drive Subwoofer Dual Duct System Dual Duct System Dual Duct System
Speaker System magnetically shielded Speaker System
Speakers: Woofer 77/ 8” (20cm), cone 6 5 /1 6” (16cm), cone 6 5/1 6” (16cm), cone 6 5/ 1 6” (16cm), cone 65 /1 6” (16cm), cone 65/1 6” (16cm), cone 4 3/ 4” (12cm), cone
Midrange 2” (5cm), cone 2” (5cm), cone 2” (5cm), cone 2” (5cm), cone
13
Tweeter /1 6” (2cm), dome 15 /8” (4cm), cone 13
/ 1 6” (2cm), dome 13
/1 6” (2cm), dome 15/ 8” (4cm), cone 15/8” (4cm), cone 13
/1 6” (2cm), cone
13
Supertweeter /1 6” (2cm), dome
Subwoofer 77/8” (20cm), cone 6 5/ 1 6” (16cm), cone
Power Handling Capacity 150 watts (Subwoofer) 120 watts 100 watts (Subwoofer) 120 watts 100 watts 60 watts 40 watts
50 watts (Main Speaker) 50 watts (Main Speaker)
Impedance 6 ohms (Subwoofer) 6 ohms 6 ohms (Subwoofer) 6 ohms 6 ohms 6 ohms 6 ohms
6 ohms (Main Speaker) 6 ohms (Main Speaker)
1 1 1 7 3 5 3 3 5 3 11 1 7 3 1 7 3
Dimensions (W H D) 13 13 / 4 16 /16 in. 8 /2 12 /16 10 /4 in. 11 /16 13 /16 14 / 8 in. 9 /16 13 / 16 10 /16 in. 8 /2 12 /16 10 /4 in. 8 /2 12 / 16 10 /4 in. 85/8 121/2 85/8 in.
330 335 407 mm 215 315 273 mm 286 335 365 mm 235 335 270 mm 215 315 273 mm 215 315 273 mm 219 317 219 mm
Weight 18.1 lbs (8.2kg) 8.6 lbs (3.9kg) 13.9 lbs (6.3kg) 8.2 lbs (3.7kg) 7.8 lbs (3.5kg) 7.8 lbs (3.5kg) 6.9 lbs (3.1kg)
Center & Surround
Speakers
CENTER SPEAKER
Type Full-range, bass-reflex, DVD Digital Theater System
magnetically shielded TH-A10
Speaker 3 3/1 6” (8cm), cone Center Unit
Power Handling Capacity 30 watts AUDIO SECTION
Impedance 8 ohms Dynamic Range 97dB
11 3 3
Dimensions (W H D) 9 /1 6 4 /8 5 /4 in. Total Harmonic Distortion 0.007%
245 110 145 mm Output Level 2.0V RMS
Weight 1.8 lbs (0.8kg)
VIDEO SECTION
SURROUND SPEAKER
Horizontal Resolution 500 Lines
Type Full-range, bass-reflex
Signal-to-Noise Ratio 60dB
Speaker 3 3/1 6” (8cm), cone
Output Level: S-Video-Y 1.0Vp-p/75 ohms
Power Handling Capacity 30 watts S-Video-C 0.286Vp-p/75 ohms
Impedance 16 ohms Composite 1.0Vp-p/75 ohms

Dimensions (W H D) 6 5 /1 6 43 /8 5 3/8 in. Dimensions (W H D) 15 1 5/ 1 6 3 3/8 101 3/1 6 inches (403 85 273.5 mm)
160 110 136 mm Weight 11.0 lbs (5.0kg)
Weight 1.2 lbs (0.55kg) Powered Subwoofer
*Measured at peak level, weighted, without Dolby NR. AMPLIFIER SECTION
Output Power: Front/Surround/Center 20W 5, 4 ohms, 1kHz, 0.7% total harmonic distortion
Woofer 100W, 4 ohms, 100Hz, 0.7% total harmonic distortion
SPEAKER SECTION
Type Bass-reflex
Speaker 10 inches (25cm)
Frequency Range 25Hz - 200Hz
Dimensions (W H D) 11 1/1 6 181 5/1 6 19 1 5/1 6 inches (280 480 506 mm)
Weight 41.4 lbs (18.8kg)
Satellite/Center Speakers
Type Bass-reflex, magnetically shielded
Speaker 2 1 3/1 6 15/8 inches (7cm 4cm)
Power Handling Capacity 20 watts
Frequency Range: Satellite/Center 110Hz - 20kHz/100Hz - 20kHz
Dimensions (W H D) Satellite/Center 2 1/2 41/1 6 45 /1 6 inches/6 21/ 2 4 5/ 1 6 inches
62 102 109 mm/152 62 109 mm
Weight Satellite/Center 0.98 lbs/1.1 lbs (440g/475g)
Diana Krall
Photographed at the 1999 JVC
International Jazz Festivals

The JVC Jazz Festival is JVC’s


Wallace Roney
proud contribution to the world
We Bring the Music to You music scene. Through this annual
event, JVC has brought the best
of live jazz to audiences in both
the United States and Europe for
the past fifteen years.
Jazz and JVC—the best in
music and the best in music
reproduction come together at
the JVC Jazz Festival. Be sure to
join us.

JVC—Supporting the Best in Wor ldwide Ent ertainment


JVC is Proud to
Support Soccer
As a true “corporate citizen” of the world, JVC is
dedicated to community-building activities on a
global scale, like promoting the world’s sport—
soccer.
In the spirit of global citizenship, JVC is proud
to support the most international sporting event
of all—World Cup Soccer. As we have done five
consecutive times since 1982 we are sponsoring
the 17th FIFA World Cup that will take place in
Japan and Korea in 2002. JVC is also an official
sponsor of the European Football
Championship—EURO 2000. JVC is proud to
support soccer.

Design and specifications subject to change without notice


The photos of the products featured in this brochure may not
Distributed By be of actual products that are available in your country
Copyright 2000, Victor Company of Japan, Limited (JVC).All rights Reserved

http://www.jvc.com.

JVC COMPANY OF AMERICA


DIVISION OF JVC AMERICAS CORP. This catalog is made from 100% recycled
170 0 Valley Road, Wayne, N.J. 07470 paper using soy-based ink.
CONSUMER INFORMATION CENTER

You might also like