The document provides instructions for resetting ND Dome Luminaires using the Interact Agri app. It instructs the user to power cycle the luminaires, open the app settings, access the Bluetooth scanning function, select all luminaires, tap "Factory Reset" and then "Reset Lights" to reset all lamps at once. It notes that after resetting, lamps will show as "Uncommissioned" and can then be re-commissioned to the gateway normally.
The document provides instructions for resetting ND Dome Luminaires using the Interact Agri app. It instructs the user to power cycle the luminaires, open the app settings, access the Bluetooth scanning function, select all luminaires, tap "Factory Reset" and then "Reset Lights" to reset all lamps at once. It notes that after resetting, lamps will show as "Uncommissioned" and can then be re-commissioned to the gateway normally.
The document provides instructions for resetting ND Dome Luminaires using the Interact Agri app. It instructs the user to power cycle the luminaires, open the app settings, access the Bluetooth scanning function, select all luminaires, tap "Factory Reset" and then "Reset Lights" to reset all lamps at once. It notes that after resetting, lamps will show as "Uncommissioned" and can then be re-commissioned to the gateway normally.
• Start on main screen of Interact Agri app > tap “Settings” wheel in top right of screen > enter Project Settings page • Tap and hold in the right hand corner of the screen (just below your battery, wifi, and signal icons) to access Bluetooth scanning • Tap “Discover Lights” > tap “Select all” > once call luminaires are selected, tap “Factory Reset” in the pink banner at the bottom of the page > tap “Reset Lights” • In the Bluetooth function, you can confirm which luminaires are “Uncommissioned” (reset) or “Commissioned” (tied to the gateway) • Once all lamps are “Uncommissioned”, you can exit the Bluetooth function and re-commission gateway and lamps normally
1 NatureDynamics BLE mass factory reset (installer-only function)
Hidden App will search for available lights, not using
button Zigbee but Bluetooth. In order to find all lamps, its best to stand in the middle of the Press 5 secs barn.
Easily see if there are uncommissioned
lamps, or if all lamps are connected to a mesh.
Lamps can be blinked individually and reset
by checking the box. Factory reset max 100 lamps in one time. Note that each lamp will take few secs to reset. When lamps are reset with this feature, there is no longer the need to reset gateway, as released slots are automatically cleaned by Interact app. You are going to use the Bluetooth connectivity of the ND Dome lamps. Powercycle (switching power on/off) is needed to open the Bluetooth connectivity. After 24 hrs the Bluetooth is automatically 2 NatureDynamics switched off.