ecommiendal
ion. & conclusion:
es ree ety Reed that the sub soil horizons in investigated area may 0
SY SONAL, DIST-DHE Consttion of PWSS for NAHAR CHILLE PWSS ander SUB
Looking (6 the soil profite and sot gation
soil strength of the investigation area, ISOLATED
fonndation of required dimension a ve es gee anit may be undertaken. The
fxston may be resedo minimum 280m depth from Ground Level: A plate foad Test
the proposed depth of foundation may be earied out for better bearing capacity estimates:
Frther forthe higher fonds on Foundation, bearing Pile shall be used. Forte Safe
vend capacity of Pile i sleet had Feld ‘and Laboratory test ests and shown
However, the type of foundation and d 2 we
: ‘ jepth may be decided by design engine
based on various data furnished in the report for safety and economy.
Also, if the design engineer consider the pile foundation then for employment of pile
foundation the following provisions shall warty os incorporated in the design wilt stall
form apart of structural analysis
«Reduction of safe loads shall be required to be made using suitable grow CCE
ioe — with pile group geometry. A design ‘de beam shall be provided 2
pile cap level at mutually icular direction
rin initial load test as per IS: 1888 (both single and in group) shall be conducted For
‘athentication of theoretical values, Two nos. minimum random. routine load test Sal
preferably be carried out to ascertain the actual soil-pile behavior under vertical
horizontal loadings. i s 7 ;
¢ Mud circulation boring shall be taken resorted to using suitable boring finid (anit ¥t
vot less than 1.20 MT/M3) to arrest caving in and wall instability.
| & Adequate grade of concrete considering zero lateral support up toa
f below the existing ground surface level.
depth of 3.06
_ Also, some important parameter/data of the construction area may be recommended for
design purpose ~
w Geiemic co-efficient of 0.36 shall be considered adequate in all respect for design &
‘construction of the proposed structure as per IS: 1893 & Water table of the constrection
area mentioned in the soil investigation report and the expected sub soil water Jevel
may be little rising up. ‘Type of structure is RCC & Foundation level of the structure
has vec safe bearing pressure chart of this report.
«@ Value of C sion), Value of @ (Angle of internal friction) & Vz sabmerged
! densify hias been considered for the table of shear: ES ES ae ee
—
aC.
(
& scanned with OKEN Scanner