CALIBRATION AND VERIFICATION TEST PROCEDURE
FOR 3M 701 MEGOHMMETER
4. INTRODUCTION
tion and
‘This Speciation defines the suggested method of
io defines the
performance verficaton forthe 3M 701 Megohmmeter,
{est equipment tobe used,
2. TEST EQUIPMENT and DOCUMENTATION
‘A. AKeithley Model 619 Electrometer or equivalent (Input impedance = 4
x10°A),
18. A decade box with a range of 100KO. to 1060 +1 % or the following
Individual resistors
t00ka 21%
twa 21%
tooMa 21%
In the OFF postion and adjust the mechanical
the scale,
BATTERY TEST mode. Very that pointor
on the BATTERY TEST scale,
, Place the 100Ka resistor across the Input. Switch the unit to
CONTINUITY TEST. Verity thatthe unt reads within mits (2 2° of
*100K0 mark on the CONTINUITY TEST scale, Short the input; very
‘thatthe unit has full-scale deflection,
Remove the shor: place the decade box across the input. Vet that
‘the unit reads within limits for 1OGQ and 1 MQ in both the 10V and
100V SURFACE TEST modes. (Tolerances forthe 1 M&2/ 10 G2.readings are shown on the top scale ofthe meter as small dots on
either side ofthe respective resistance mark on the dial)
. Remove the decade box. Using the Kethiey 619, very that the output
Is Between €3V and 107V in the 100V SURFACE TEST mode,
F. Ifabove specifications can not be obtsined proceed to Section 4,
ration Procedures
4. CALIBRATION PROCEDURES.
A
°
°
Place the batteries Inthe
TEST positon.
ace the solectar switch inthe BATTERY
Press the TEST bution, adjust Ri 10.00\V + 01V appears
between U2 Pin 7 and ground. Release the TEST button.
Press the TEST button. Adjust R23 for 100.0V # 1V between SW 1 Pin 12,
‘and ground. Release the TEST button
Place the selector switch in 100V SURFACE TEST positon. Shot the
input jacks, Press TEST button. Adjust R21 so that pointer reads fll
scale, Release TEST button.
Return the selector suitch to BATTERY TEST. Press the TEST button.
ely witha short and then a 100K0.
138 in the CONTINUITY TEST mode, (NOTE:
100K9 mark on the
Continuity sale of the meter.)701 MEGOHMMETER VERIFICATION / CALIBRATION
(PT
ee ae =
R@t R23 R10-15¥ Cle
SE, cB.
e-11514L
ISSUE RL
Oo
®
2
O
76,
\@
ef
Figure 2. Main PC Board Assembly -Model T00486 30 701 (Issue 1)(Zenss) 402 me 9sy00. 1epOW- Aiqwessy pre0g od UIEW “¢ 8unByM701 Meter Sener
Seas ae nntiner,
A" seal -Sial ars dest midpoint betwen etch ange a ented
on ening