Professional Documents
Culture Documents
FuseAndRelay.com
all fuse and relay box with diagram
MENU
pickupstoreke.com OPEN
Nissan X-Trail T30 , the first generation Nissan X Trail, was produced in 2001, 2002, 2003, 2004, 2005, 2006 and 2007. During this
time, the model has been restyled. In this article you will find a designation of fuses and relays Nissan X Trail T30 with decoding, photo
examples and box diagrams. Note the cigarette lighter fuse.
” The purpose of the elements may differ from that shown and depends on the year of manufacture, the region of delivery
(Japan, Europe, America) and the level of equipment. Check the description with your diagrams on the box lid.
➤
Contents
https://fuseandrelay.com/nissan/xtrail-t30.html 1/12
8/24/23, 10:06 AM Fuse box diagram Nissan X-Trail T30 and relay assignment with layout
1 Passenger compartment
2 Engine compartment
2.1 Layout
2.2 Fuse box
2.2.1 1
2.2.2 2
2.3 Relays box
Passenger compartment
Located at the bottom of the dashboard. Open the protective cover to access.
The photo
Diagram
➤
https://fuseandrelay.com/nissan/xtrail-t30.html 2/12
8/24/23, 10:06 AM Fuse box diagram Nissan X-Trail T30 and relay assignment with layout
Assignment (type 1)
5. Electronic Parts – Diagnostic connector, X-Trail automatic transmission shift lever lock, power window relay, TIME CONTROL
block (Control of the central lock, sunroof, interior light delay, heated rear window, etc.)
6. FR WIPER – Windshield wiper and washer
7. Starter Signal – Signal for starter, daytime running light, and YD ECU (to date) and for Nissan QR engines up to August 2003.
8. 4 WD ABS – Connectable power supply to the ABS, ESP, 4WD control unit.
9. AIR BAG – airbags
10. Fuel pump – fuel pump (QR engine), fuel transfer pump (YD diesel engine)
11. METER – Instrument panel, headlight washer relay timer
12. A / T Control – Reversing light, automatic transmission control system
13. Engine Control – Heated oxygen sensors, fan relays, starter blocking relay (X-Trail with automatic transmission)
14. Spare
15. AIR CON – Climate control, relay and clutch for turning on the air conditioning compressor
16. RR WIPER – Rear window washer cleaner
17. CIG Lighter – cigarette lighter
18. CIG Lighter – Cigarette lighter relay
19. Blower MOTOR – Blower motor for the interior of the stove
20. MIRROR – Power mirrors
21. Spare
22. STOP LAMP – Stop light, brake control signal for ABS, ESP, engine control unit
23. Power Socket – Electrical outlets (driver’s glove compartment and trunk)
24. Blower Motor – Blower motor for interior stove
25. RR DEFOG – Heated rear window
26. KROMM LAMP – Interior lighting lamps, including the luggage compartment, a lamp for maps and illumination of doorways
27. HEATER MIRROR – Heated mirrors
28. Electronic parts – Permanent power supply of the instrument panel, time control unit, clock, climate control, door remote
control unit
” If your cigarette lighter does not work, check the fuses with numbers 23, 17 and 18 at 15A.
Relay
Designation
R1 – PTC relay
R2 – Power window relay
R3 – Ignition relay
R4 – Heater fan relay
R5 – Auxiliary relay
➤
https://fuseandrelay.com/nissan/xtrail-t30.html 4/12
8/24/23, 10:06 AM Fuse box diagram Nissan X-Trail T30 and relay assignment with layout
Also, several relays can be placed in the front pillar at the driver’s feet (R1 – heated rear window / mirrors, R2 – Fuel pump relay)
Engine compartment
Layout
Fuse box
1
➤
https://fuseandrelay.com/nissan/xtrail-t30.html 5/12
8/24/23, 10:06 AM Fuse box diagram Nissan X-Trail T30 and relay assignment with layout
Diagram
Diagram
➤
https://fuseandrelay.com/nissan/xtrail-t30.html 6/12
8/24/23, 10:06 AM Fuse box diagram Nissan X-Trail T30 and relay assignment with layout
Appointment
A 100 / 120A Alternator, engine compartment fuse box (fuses: Nos. B to G, 39 to 43)
B 40A Central locking, power windows, sunroof, power seats
C 40A Cooling Fan
D 40A Cooling Fan
E 30A Headlight cleaners and washers
F 60A Glow plugs
G 80A Passenger compartment fuse box
H 80A Air conditioning / heating system, passenger compartment fuse box (fuses: No. 18, 20, 23)
I 50A Vehicle Stability Program (ESP)
J 30A Ignition lock
K 40А ABS
L 30 / 40A ABS, ESP (30A with ESP, 40A without ESP)
M –
31 10A Exterior lamps, headlamp cleaners and washers, warning devices and indicators
32 15A Audio system, navigation system, telephone
33 10A Engine control unit, anti-theft system
34 10A Generator, anti-theft system
35 15A Direction indicators
36 10A Rear fog lamp
37 10A ABS, four-wheel drive control system (4WD)
38 –
39 15A Engine control unit
40 15A Engine control unit, outdoor lamps
41 15A Outdoor lamps, fog lamps
42 15A Fog lights
43 20A Engine control unit, anti-theft system
Relays box
Diagram
➤
https://fuseandrelay.com/nissan/xtrail-t30.html 7/12
8/24/23, 10:06 AM Fuse box diagram Nissan X-Trail T30 and relay assignment with layout
Protected components
R1 Lamp relay
R2 Daytime lighting relay, left (with daytime lighting)
R3 Daytime running light relay, right (with daytime running lights)
R4 Rear fog lamp relay
R5 Front fog lamp relay
R6 Start inhibit relay (“P” / “N”)
R7 A / C relay
R8 Horn relay
R9 Cooling fan relay 1
R10 Throttle valve control relay
R11 Cooling fan relay 3
R12 4WD relay
R13 Cooling fan relay 2
R14 Headlight washer relay
In some models, the place of relay number 14 is located fuses: 10A – rear fog lamp, 15A – heated windshield (wiper zone), 15A –
engine control unit and 20A – xenon headlight control unit.
We have posted a video on our YouTube channel. Watch and subscribe.
That’s all. If you have any questions or have something to add – write in the comments.
Related Posts:
1. Nissan Avenir Expert W11 fuse and relay
2. Nissan March K11 K12 fuse and relay
3. Nissan Qashqai j10 (Rogue Sport 1G) fuse and relay
4. Nissan Sentra 2013 – 2019 fuse and relay
➤
https://fuseandrelay.com/nissan/xtrail-t30.html 8/12
8/24/23, 10:06 AM Fuse box diagram Nissan X-Trail T30 and relay assignment with layout
Comments 24
Hi I have a 07 my flashers started to go slow and now they don’t work at all would it be the relay or the flasher relay controller unit
thanks
REPLY
Hi John,
Did you get a reply as I have the same model with the same problem.
Regards
Hansie
REPLY
Hi I have a t31 diesel headlights are stuck in the down position. Normally when switched on they raise up but stopped working will this
be a fuse gone
Thanks.
REPLY
The warning bip before starting the engine and when switching off the engine while the front lights still on, of my Nissan X-trial 2.2
litter, YD 22, year 2002 just stop working. What could be the problem?
REPLY
I replaced the Starter Signal fuse, but it’s not receiving power, I checked all other fuses inside and outside in the motor with an
electrical test light all work and receiving power, except Starter Signal Fuse, Any advice?
REPLY
I had a fault on the rear numberplate light(s) of my 2006 Nissan X-Trail (T30 engine 2.2 Deisel) … which I thought was due to a broken
fuse.
➤
Amongst all of the searches I did through Google, yours was one of the sites I visited…. which I found was very helpful and informative
… Thank you!
https://fuseandrelay.com/nissan/xtrail-t30.html 9/12
8/24/23, 10:06 AM Fuse box diagram Nissan X-Trail T30 and relay assignment with layout
HOWEVER…
NONE of those sites, yours included, showed me which fuse controlled the circuit responsible for the rear numberplate lights! (Unless I
missed something?).
So, I decided I had to check EVERY fuse that may have been responsible for this circuit, in both the engine compartment AND the
dashboard fuse boxes…
NONE were found to be damaged/blown, and so the problem seemed to be either a connection or damaged cable issue.
Fortunately I found the broken wire at the rear hatch hinge point, where the harness passes through the flexible rubber tube into the
hatch.
It is great that I managed to make the repair, but I still do not know which fuse controls this circuit!
Many thanks again for your great efforts and information.
Best regards, Malcolm.
REPLY
Hi Malcom , the numberplate light would be fed power from the taillights , so it would use the same fuse. Good job at finding the fault
REPLY
Hi, great site, I wonder if you could point me in the direction to help me fix the lock on the tail gate. It has stopped locking when I lock
the other doors with the central locking on the key fob.
Thanks,
Mike.
REPLY
Hi Mike,
Not sure if you already resolved this…it happened to me with my ‘06. It ended up being detached wiring where the wire passes near
the hinges of the tail gate on the left side.
Once the wires were reattached, the lock worked with the key fob.
REPLY
I replaced a battery on my Xtrail nissan 2004 and now my radio has stopped working.
What could be the problem
REPLY
If the radio does not work after removing the battery, then the problem may be due to damage to the amplifier. It is extremely
sensitive to the immediate moment of power connection and power surges.
Contact your service
REPLY
Hi, I have a 2004 T30 2.2 dCi (RHD) which has been the most reliable car I’ve ever had until recently. After charging problem (now fixed)
which caused all the dashboard dials to violently vibrate my speedometer is not working everything else is operating normally. I would
be most grateful for any advice on how to resolve the issue including what fuses/relays might be involved.
REPLY
Te 21.03.2022 at 21:10
Hej! Mitt centrallås har slutat att fungera måste låsa/öppna med nyckel det är en Nissan X-trail-05 vad kan det vara.
REPLY
Hi I have a Nissan x trail T30 and one fues to ECU has no power supply. I checked the fues and it’s ok but n power to it? Some help
please. Thanks.
REPLY
➤
https://fuseandrelay.com/nissan/xtrail-t30.html 10/12
8/24/23, 10:06 AM Fuse box diagram Nissan X-Trail T30 and relay assignment with layout
Hey guys I have no central locking I’m trying to connect a fob but to exit the pairing mode I need to hit the central locking button on the
car.
I’ve cleaned the switches and checked the fuses what the hell do I do now?
REPLY
Hi Alex,
I have a Nissan T30 with no working reverse lights.
I’ve searched through the above and can’t see the relative fuse.
Can you assist please?
Thank you
Paul
REPLY
Ahoj Alex, mám Nissan T30. Klasicky smerovky pravá /ľavá mi fungujú ale po zapnutí výstražných 4x tak nefungujú.
Môžete mi prosím pomôcť?
Ďakujem
Juraj
REPLY
Hi I have 2005 xtrail the heater fan won’t turn off , where I’d the heater relay situated ,has anyone had the same problem is so how do I
fix it . I bought the heater controls on the dash but mate no difference cheers john
REPLY
Good morning,
I have a 2010 Xtrail and I recently 2 months bought a new battery. The lights radio and air-con work but it won’t start. No clicking, no
chugging nothing. Any ideas?
REPLY
Leave a Reply
Your email address will not be published. Required fields are marked *
Message
Your Name
Your E-mail
➤
Your Website
https://fuseandrelay.com/nissan/xtrail-t30.html 11/12
8/24/23, 10:06 AM Fuse box diagram Nissan X-Trail T30 and relay assignment with layout
Save my name, email, and website in this browser for the next time I comment.
Post Comment
FuseAndRelay.com © 2023
Privacy Policy
All data only for informational purposes
https://fuseandrelay.com/nissan/xtrail-t30.html 12/12