INSTRUCTIONS: The Quiz is good from 6:30 – 7:30 pm. It must be
with solutions and figures. When finished, take very clear photos of your work and submit it to Google Classroom then to messenger (secret convo) with labeling. Follow instructions, please or you will get demerits.
1. If you are assigned to design the most efficient crosssections
of open channels with (a) rectangular section, (b) trapezoidal cross-section, and (c) circular cross-section, what size of open channels would you recommend for each of the above-described sections to carry a flow of 14.5 m3/s with a velocity of 4.75 m/s.
2. A 2-m diameter metal conduit with a slope of 1:900, is flowing
half-full. Compute for the discharge. Use n = 0.020.
3. What would be the cross-section of greatest hydraulic
efficiency for the trapezoidal channel shown below if the discharge 12.0 cu.m./sec with a channel slope of 0.000475. Roughness coefficient is given to be 0.020.
4. Given is an open channel of rectangular cross section 3.0
meters wide. Water flows through it at 9.0 cu.m./sec. The bottom slopes up, rising 3 mm per meter in the direction of flow. What should be Manning‘s roughness coefficient, n, if the water depth decreases from 2.0 m to 1.55 m in a 160-m length of channel?
5. Determine the most efficient cross section for an open
channel of semicircular section designed to carry 1.0 cu.m./s volume flow rate at a slope of 0.0060. The channel has a roughness coefficient, n, of 0.011
Irrigation Works: The Principles on Which Their Design and Working Should Be Based, with Special Details Relating to Indian Canals and Some Proposed Improvements