Professional Documents
Culture Documents
DATA SHEET
Extinguishing Media
Content Content
Chemical Name CAS No.
(ABC40) (ABC70)
Monoammonium Phosphate 7722-76-1 38-42% >70%
Ammonium Sulphate 7783-20-2 48-58% >10%
Hydrophilic precipitated Silica 7631-86-9 1-3% 1-3%
12001-26-2 ; 1-3%
Mica 1-3%
310-127-6
Silicone oil 63148-57-2 <1% <1%
Propellant
Chemical Name CAS No. EC No.
Nitrogen 7727-37-9 231-783-9
After Inhalation: Remove victim to fresh air area. Seek medical assistance if breathing difficulty/ irritation
occur. May aggravate existing chronic respiratory conditions
After contact with skin: Wash exposed area with soap water. Seek medical assistance if irritation develops and persist.
May aggravate existing skin disease.
After contact with eyes: Flowing water while holding eyelids apart until pain-free and consult an ophthalmologist
After ingestion: If victim is conscious and alert, drink plenty of water (dilution effect). Seek medical
assistance. Do not leave victim unattended
In case of accidental release, use the appropriate respiratory protection. Clean up product using industrial vacuum,
wet sweep or shovel to minimize dust formation. Bag or drum product for disposal. Do not allow product to enter
waterway, soil or drains.
Avoid eye, respiratory, and skin exposure. Use appropriate personal protective equipment when handling. Be aware
of any signs of dizziness, fatigue, or any exposure symptoms Product should be stored in dry, well-ventilated areas
away from heat sources. Store in its original container/extinguishers. Containers are under pressure and present
significant safety hazards. Store away from heavily trafficked areas and paths for ingress/egress. Protect containers
from possible damage and falling. Secure cylinder to prevent accidental knock over.
Respiration Protection: Use an N95 mask for limited exposures and use air purifying respirators with HEPA
filters for prolonged exposure
Eye Protection: Wear Chemical Goggles or full-face air purifying respirator
Skin Protection: Use nitrile, latex, or similar gloves and coveralls. After product handling, avoid food,
tobacco products. Or other means of transferring the product from hand to mouth until
after thorough washing
Reactivity: none
Chemical Stability: Chemically stable under recommended conditions of storage, use and temperature
Possibility of hazardous reactions: none
Conditions to avoid: none
Incompatible Materials: none
Hazardous decomposition products: none
Acute toxicity: Based on available data, the classification criteria are not met
Irritation and corrosivity: Based on available data, the classification criteria are not met
Sensitising effect: Based on available data, the classification criteria are not met.
Effect on reproduction: Based on available data, the classification criteria are not met
STOT-single exposure: Based on available data, the classification criteria are not met
STOT-repeated exposure: Based on available data, the classification criteria are not met
Aspiration hazard: Based on available data, the classification criteria are not met
Avoid discharge to a wastewater treatment system. Contact supplier to recycle if powder in the cylinder is still non-
contaminated. Otherwise, observe all local regulation when accomplishing disposal of this material type.
Safety, health and environmental regulations. legislation specific for the substance or mixture:
Information according to 2012/18/EU (SEVESO III): Not subjectable
Observe all local regulations
Keep container in a well-ventilated place. Do not breathe the gas. Combat fire extinguishers are manufactured and tested to the
requirements of BS EN 3 or BS EN 1866.
The above information provides the safety requirements of the product and is based on the best of knowledge and information available
at the time of publishing. All information provided is in good faith and reference as guidance for handling, processing and storage etc.
Not to be consider warranty or quality specification, either expressed or implied, is hereby made.