Professional Documents
Culture Documents
3D Weather Station by Lutz Pietschker
3D Weather Station by Lutz Pietschker
Order of assembly:
1. Reinforce the parts indicated on page 3 with 1 to 1.5 mm cardboard.
2. Cut out a track tile shape from 1.5 mm cardboard.
3. Glue that cardboard tile shape to the back of part 1 (base), fold the triangular tabs around and
glue them to the back. Cover the back of the tile with part 2.
4. Glue part 4 on top of part 3 (roof). Optional: glue parts 4a/b on top for a 3D effect.
5. Fold both parts 3a (air vents) and glue them to the roof (part 3) where indicated.
6. Fold part 5 and glue it to the back of the folded météo wall of part 3. This part stabilises the
wall; it is necessary because the wall does not connect to the base (part 1).
7. Optional: Add doors, windows and advertising boards (parts 6a) to the walls (part 6) as
desired for a light 3D effect.
8. Fold part 6 (outer walls) and glue them to the floor (part 1). Note that the outer tabs fold
towards you. Fold part 6a and glue it to the floor and to part 6 to complete the walls.
9. Glue either part 1b or part 1a to the base (part 1).
10. Cut out the indicator (part 8) and punch a 3 mm hole where indicated. Fold and glue the grid
girl supports (9a, 9b) onto the indicator.
11. Cut out the grid girls (your choice of different parts 10a, 10b) and glue them to the Indicator
and the supports. The base line of the girls should be flush with the bottom of the indicator
part.
12. Connect the indicator assembly to the base with the brass fastener and washer.
13. Glue the roof (pre-assembled parts 3/4/5) to the hut.
14. Optional: Add billboards (parts 11.*) to the eaves line as desired.
3 3 3
1 1 1
6a
3 3
1
3
1
3a
3
3
3 3
3
1
2
6a.1
3
1
4
6a.3
3 3a 3a
météo météo
3
1
6a.4
3
3
3
3
3
1
6a
8 9a
10a
3
5 8
10b 9b
10b 10a
Rommix’ Dynamic Weather Variant page 3
3D weather hut as track condition indicator v20200419
9b 9a
A CE
10b (rain) 8 10a (sun) R
T
E
W
4a
4b
Reinforce with
4 1 - 1.5 mm
CE
cardboard.
RA
RY
D
1a
2
6 6a
2 6a 2
6a
6 6
11.1
1
1a Reinforce only the area inside
6 6
or the dashed line of part 1 with
1b 1 - 1.5 mm cardboard. Use
part 2 as a template to punch
out an 8 mm hole in the
middle of that cardboard.
CE
RA
2 2
RY
D
RA E
W
CE
2
11.2
Brass fastener