Professional Documents
Culture Documents
LED ALARMS/
LED COLOR Blink frequency Blink repetitions Threshold value
WARNINGS
3.1 PAIRING PROCEDURE 4.1. MAINTENANCE module and tank module cap are free of dust
and dirt. If necessary, clean the parts with a
The tank module and the parts of this product soft cloth. Fit the o-ring in the o-ring groove.
NOTE used to measure tank pressure should be 8. Wait for 30 seconds, then insert the new
Pairing is permanent and does not require serviced by an authorized Mares dealer every battery. Ensure that the side is facing
repeating, even after a battery replacement. other year or after 200 dives (whichever comes away from the base of the tank module. The
Once paired, the two devices (computer first). Aside from that, the tank module is tank module can be damaged if you do not
and tank module) are paired until either virtually maintenance free. All you need to do insert the battery correctly.
device is paired to a different one. is rinse it carefully with fresh water after each 9. The tank module will now perform an
dive (avoid any chemical products) and replace automatic test during which the LED blinks
- Open the tank valve (the tank pressure should the battery when needed. To avoid possible and switch into ready mode after 60 seconds.
be at least 30bar/435psi). You now have two problems, the following recommendations will
1
minutes to complete the procedure. help assure years of trouble free service:
- Ensure that other tank modules, if present, - avoid dropping or jarring the tank module;
are at least 3 meters/10ft away from the - do not expose the tank module to intense,
wrist unit. direct sunlight;
- Place the dive computer 10cm/4 inches - do not store the tank module in a sealed 5
away from the tank module (make sure dive container, always ensure free ventilation.
computer is parallel to the tank module). 4
(Pre dive mode on the dive computer) We recommend having the battery of the
If you have not been able to successfully tank module replaced by an authorized 4.2. WARRANTY
complete the pairing procedure within 2 Mares dealer. The change must be made
minutes, close the tank valve, depressurize with particular care in order to prevent Mares products are guaranteed for a period of
completely the first stage, wait for 20 seconds water from seeping in. The warranty does two years subject to the following limitations
then repeat the process from the beginning. not cover damages due to an improper and conditions:
placement of the battery. The warranty is non-transferable and applies
strictly to the original purchaser.
• 4. TECHNICAL INFORMATION Mares products are warranted free from defects
WARNING
The tank module/dive computer combination in materials and workmanship: components
has been tested and CE certified by RINA, - Never touch the metal surface of the that, upon technical inspection, are found to be
notified body 0474, located in Genova, Italy. battery with bare fingers. The two battery defective, will be replaced free of charge.
poles must never be short circuited.
The tank module/dive computer combination Mares S.p.A. declines all responsibility
- A leaking tank module cap may lead
is a Category III device as defined under for accidents of any kind that result from
to the destruction of the tank module
European Directive 89/686/ CEE, and tampering or incorrect use of its products.
by water seeping in or cause the tank
complies with the specifications set out in the module to switch off without prior notice. Any products returned for overhaul or repairs
harmonized European Standard EN250 for use - Always open the tank module in a dry under warranty, or for any other reason, must
with air compliant with Standard EN 12021 and clean environment. be forwarded exclusively via the vendor and
(oxygen content of 21%). - Only open the tank module to replace the accompanied with a proof of purchase slip.
The EC certification process and verification of battery. Products travel at the risk of the sender.
the operating performance under standards
EN250 are understood to be applicable to a
maximum depth of 50 m below the surface. NOTE 4.3. WARRANTY EXCLUSIONS
You do NOT have to repeat the pairing Damage caused by water seepage resulting
The tank module/dive computer combination
procedure after replacing the battery in the from improper use (e.g. dirty seal, battery
can be used in cold water (water at
tank module. compartment closed incorrectly, etc.).
temperatures below 10°C).
Marking 1. Remove the tank module from the HP port Rupture or scratching of the case, glass or
of the first stage regulator. strap as a result of violent impact or blows.
The instrument markings are located on the
tank module, and consist of the following: 2. Dry the tank module with a soft towel. Damage resulting from excessive exposure to
3. Remove the 2 screws (5) with a Phillips elevated or low temperatures.
• working pressure rating: 300 bar / 4,350 psi;
screwdriver. Damage caused by the use of compressed air
• reference standard: EN250;
4. Carefully remove the tank module cap (1). to clean the dive computer.
• reference marking: CE 0474.
5. Carefully remove the tank module cap o-ring
The conformity marking indicates compliance
(3) Be careful not to damage the sealing
with the essential health and safety
surfaces. • 5. DISPOSAL OF THE DEVICE
requirements as per attachment II D. and
6. Remove the battery (2) by holding it on both
89/686/EEC. The number alongside CE
sides. Do not touch the contacts or the
identifies RINA, notified body 0474, located in
electronic parts.
Genova, Italy, authorized to inspect the finished
product under art. 11 B D.e. 89/686/CEE. WARNING
Operating temperature: -10 °C to +50 °C /
If you notice traces of seeping water, damages
14 °F to 122 °F Dispose of this device as electronic waste. Do
or other defects on the o-ring, do not use the
Storage temperature: -20 to 70 °C / -4 to 158 °F tank module for further dives. Take it to an not throw it away with regular rubbish.
Power supply: authorized Mares dealer to be checked. If you prefer, you can return the device to your
- CR123A user-replaceable battery local Mares dealer.
- Battery life: 150-200 dives. Actual battery 7. Always insert a new o-ring when you replace
life depends on the number of dives per the battery and dispose the old o-ring. Make
year, usage of the LED, the length of each sure that the new, lubricated o-ring is in
dive and the water temperature. perfect condition, and that o-ring, o-ring
groove and the sealing surface of the tank
code 44201384 - 08/17 - Artbook 13844/17 Mares S.p.A. - Salita Bonsen, 4 - 16035 Rapallo (Ge) - ITALY
Tel. +39 01852011 - Fax +39 0185 669984
www.mares.com