i«
THE HAND K LOX
Operating Instructions
Hand K Lox basic set
‘This illustrates all parts included in the basic K Lox
Starter Set (KLOX.01.).
A) Frame
8) Engraved anifox
C) Rubber roller
D) Weights
1. Pre-cut the substrate to size. Substrate width should be appx 150mm and its length can be up to
‘a maximum of 800mm.
2. Place the substrate on a smooth, flat bench top (a glass top bench is ideal) and secure one end.
3. Select the rubber and engraved (anilox) rollers to be used.
4. Install the rubber roller into the frame slots. Drop in from the top then move to the forward
position. Ths is held in place when printing by the anilox roller and weights.
ilPage
Hand Ktox ssue 4 | Jan 2018
RK PrintCoat Instruments LtdAK
6. With one hand, hold the K Lox as shown in the illustration below so that the thumb can exert
steady pressure between the rubber (printing) roller and the substrate.
7. Position the K Lox near the fixed end of the substrate. Before adding ink it is recommended to do
a dry run to practice the movement and pressure.
8. With the other hand, apply a bead of ink between the rollers and immediately draw the K Lox
along the substrate at a steady speed and while applying pressure with the thumb.
rw
Hint Applying the ink. itis important to apply the
right amount of ink, this will vary with the
volume of the anilox and viscosity. Typically,
approximately Sml is recommended between
‘the marked area in this picture.
31Page
RK PrintCoat Instruments Ltd
and KLox issue 4 | Jan 2019
ww skprint comKk
SOLVENTS
‘The rubber rollers are covered with E.P.D.M. rubber (50°shore hardness) which has an excellent resistance
to cellosolve, meths, methanol, |.P.A (alcohols) and to MEK, acetone, cellosolve, acetate (keytones and
esters).
However, the following solvents should not be used:
toluene, xylene, benzene, naphtha (aromatics),
“white spirit, petrol, paraffin, hexane (aliphatics),
CC, chloroform, methylene chloride (chlorinated solvents).
RUBBER ROLLERS
‘As standard the rubber roller will print a width of appx 115mm. An alternative "wide shoulder” roller
prints appx 84mm wide and is recommended when printing onto slippery substrates such as polythene.
‘STANDARD QCH TYPE ENGRAVED ROLLERS
el Screen Cells/ | CellVolume/
ve Linear Inch. | 1m/Sq inch
40/5 400 28
200/12 | 200 | 66
igo/14 | 180 | 10.7
40/10 140 13.0
too/1s_| 100 l 25.2
REFERENCE: RK Data Sheet D15/1 detailing the available engravings for all K Lox engraved rollers.
SiPage
RK PrintCoat Instruments Ltd
Hand Ktox issue | Jan 2019
wovwekprint.com